IKEA KLASEN User manual
KLASEN
Design and Quality
IKEA of Sweden
ENGLISH 4
DANSK 14
SUOMI 24
NORSK 34
4
WARNING
For outdoor use only.
Read these instructions before using the barbecue. Failure to follow these instructions
and safety warnings may result in serious bodily injury or death, and/or property loss.
Warning: accessible parts may be very hot. Keep children and pets away from the
barbecue.
Do not attempt to move the barbecue during use.
Turn off the gas supply at the gas cylinder after use.
Anymodicationofthebarbecue,misuse,orfailuretofollowtheinstructionsmaybe
dangerous and cause harm to you or others.
Leaktestthebarbecuebeforerstuse,annually,whendismantled,whenpartsare
replaced, or if the gas cylinder is removed or replaced.
Retain these instructions for future reference.
DANGER:
1. If you smell gas:
2. Shut off gas to the barbecue.
3. Extinguishanyopename.
4. Open lid.
5. If the odour continues, keep away from the barbecue and immediately call your gas
supplierortheredepartment.
WARNING:
Donotstoreorusepetrolorotherammableliquidsorvapoursinthevicinityofthisor
any other appliance.
A LP cylinder not connected for use shall not be stored in the vicinity of this or any other
appliance.
ENGLISH KLASEN gas barbecue
5
SAFETY SYMBOLS
The safety symbols and their meanings
are explained below. Read and follow the
instructions in this manual carefully.
DANGER
DANGER: Indicates an imminently hazardous
situation which, if not avoided, will result in
death or serious injury.
WARNING
WARNING: Indicates a potentially hazardous
situation which, if not avoided, could result in
death or serious injury.
CAUTION
CAUTION: Indicates a potentially hazardous
situation or unsafe practice which, if not
avoided, may result in minor or moderate
injury.
WARNING
Failure to read and follow these
instructions could result in serious injury
or damage to property. Installation must
conform to local codes.
This product is for OUTDOOR USE ONLY.
NEVER use in an enclosed space such
as a carport, garage, veranda, covered
patio, or under an overhead structure of
any kind.
Important – LEAK TEST THE BARBECUE
WHEN FULLY ASSEMBLED BEFORE FIRST
USE.
IN ADDITION always leak test the
barbecue annually, when dismantled,
when parts are replaced, or if the
gas cylinder is removed or replaced.
FAILURE TO DO THIS COULD CAUSE
SERIOUS INJURY, OR DAMAGE TO THE
BARBECUE.
Always keep the cylinder vertical.
Important – Ensure the barbecue is
positionedonat,levelgroundtoaid
with fat/grease run off.
KLASEN gas barbecue is designed for
usewitheitherliquidpropane(LP)gas
orliquidbutane(BP)gas.Donotuse
withnatural(pipedincity)gas.The
valves,orices,hoseandregulatorare
for LP gas only.
This barbecue has been supplied with
apropaneregulator(onlyusewith
propanegas).
Should you need to change the gas
cylinder, make sure the barbecue is
switched off, and that there are no
sourcesofignition(cigarettes,open
ame,sparks,etc.)nearbybefore
proceeding.
Never use indoors, in an enclosed area
or below ground level.
This barbecue shall only be used above
ground in an open-air situation with
natural ventilation, without enclosed
areas, where gas leakage and products
of combustion are rapidly dispersed by
wind and natural convection.
This barbecue is not intended to be used
in or on boats or in or on recreational
vehicles.
This barbecue should not be used under
overhead combustible construction.
Never use an adjustable regulator with
this barbecue.
This barbecue will become very hot
when in use - take care when touching.
Keep children and pets at a safe distance
from this barbecue when in use.
Do not attempt to move this barbecue
when in use.
Always turn off gas supply at the gas
cylinder when not in use.
Anymodicationofthisbarbecuemay
be dangerous.
Do not leave this barbecue unattended
when in use.
Any parts sealed by the manufacturer
or his agent must not be altered by the
user.
When igniting, always have the lid open.
Onlyusethebarbecueonaat,level
non-ammablesurfaceorground.
When positioning, ensure the barbecue
is a minimum of 1 metre from
ammableitemsorstructure.
6
This barbecue is not intended for use
with charcoal or other similar fuel.
Do not use petrol, white spirit, lighter
uid,alcoholorothersimilarchemicals
to ignite a barbecue.
When storing the barbecue or gas
cylinder, ensure they are away from
ammablematerialsorliquids.
The gas cylinder must not be stored
next to this or any other appliance.
Always follow care and maintenance
instructions – regularly maintain your
barbecue.
Do not allow grease, fat or food residue
to build up in or on the barbecue – RISK
OF FIRE.
Always replace worn parts – do not use
the barbecue if a leak, wear or damage
is found.
Never overload the grill with food
– evenly space over the cooking
grillsurface,ensuringsufcientair
circulation to the burners.
Do not store or cover the barbecue until
fully cooled.
This product is not suitable for lava
rocks.
Donotobstructtheowofcombustion
and ventilation air.
Keep the ventilation opening of the
cylinder enclosure free and clear from
debris.
Keep the area around your gas barbecue
clear of any combustible materials,
petrolorotherammableliquidsand
vapours.
Pressure regulator and hose assembly
supplied with this barbecue must be
used.
Replacement pressure regulators and
hose assemblies must be the same
as those supplied originally with the
barbecue. Never use an adjustable
regulator with this barbecue.
Do not hang any combustible materials
from the hand rails of this barbecue.
Accessible parts may be very hot. Keep
young children away.
Always wear protective gloves or a
barbecue mitt when handling hot
components or items such as pots.
Before each use inspect the gas hose
to ensure it is free of any twisting or
tension.
LEAK TESTS
IMPORTANT – PERFORM LEAK TESTS
BEFORE USE
Always leak test the unit – annually, when
dismantled, when parts are replaced, or if
the gas cylinder is removed or replaced.
• Neveruseanopenametocheckfor
leaks at anytime. DO NOT IGNITE THE
BARBECUE DURING LEAK TESTING.
•To be performed in a well-ventilated area.
•Be sure all control knobs are in the ‘OFF’
position.
•Check for leaks by brushing a solution
of 1/2 water and 1/2 soap over all the
gas system joints, including all valve
connections, hose connections and
regulator connections.
•Ensure the soap solution has been applied
to all connections – connect the regulator
to the gas cylinder, open the gas control
valve on the regulator allowing gas to
ow.
•OBSERVE – if bubbles form over any part
of the joints there is a leak.
•Turn off the gas and tighten all joints
•Repeat test. If bubbles form again, do not
use the barbecue. Please contact your
local dealer for assistance.
GAS AND REGULATOR INSTRUCTIONS
•This barbecue can use either propane or
butane LPG bottled gas. If using butane
you must change the regulator.
•Propane cylinders will supply gas all year
round, even on cold winter days.
• Butanecylinderswillsupplysufcientgas
in summer. Butane gas must not be used
in colder temperatures. Contact your local
gas supplier for advice.
•The cylinder should be positioned
underneath the main barbecue body and
stored upright.
•Gas cylinders should never be stored or
laid on their side.
User Instructions
Before assembling your barbecue, remove
all protective packaging from each part.
The gas cylinder must have a connection
compatible with the regulator supplied with
the barbecue and have a minimum capacity
of 4kg / 9lbs.
Do not store a spare LP gas cylinder under
or near this appliance.
7
Neverllthecylinderbeyond80%full.
Failure to follow these instructions exactly
mayresultinrecausingseriousinjuryor
death.
Place dust cap on cylinder valve outlet
whenever the cylinder is not in use. Only
install the type of dust cap on the cylinder
valve outlet that is provided with the
cylinder valve. Other types of caps or plugs
may result in leakage of propane.
Connecting to the Cylinder
• Conrmallbarbecuecontrolknobsarein
the ‘OFF’ position.
•Connect the regulator to the gas cylinder,
tighten it securely and proceed according
to instructions below and the instructions
from the gas cylinder supplier.
Read carefully before use
Fig 1
1
2
3
Fig 2
OFF
Fig 3
Fig 4
Fig 5
ON
Fig 6
OFF
Table (A)
COUNTRY INLET OUTLET
DK/FI/NO Jumbo HOSE NOZZLE
Ø10
Operating and installation instructions
•KOSAN 35 is a domestic regulator used to
supplygastoutilitiesatspecicpressure
andow,asindicatedonthelabel(1).
• KOSAN35mustbetteddirectlytothe
cylinderfeaturingaØ35mm(G.56)quick
connection valve. Make sure the regulator
inlet and outlet are compatible with the
cylinder and the appliance being used.
•The gas cylinder must always be kept
in the vertical position. Do not move
the cylinder during operation. When
the device is used outdoors, it shall be
positioned or protected against direct
penetration by any tracking water
•KOSAN 35 versions feature a release
valve(themarking“PRV”isvisibleonthe
label(1)aregenerallynottypeapproved
foruseinclosedpremises(seelocallaws
onthesubject).
• Neverlookforgasleakswithaliveame.
Use instead a solution of water and soap.
•In the event of any faults being found,
close the gas supply and immediately
8
contact your gas supplier.
• Avoidthattheholeonthecover(VENT)is
obstructedorstopped(2).
•This regulator is not for use in caravans
and motor caravans.
Fitting the regulator on the valve
Make sure that:
•All the taps of the user appliance are
closed.
•The rubber hose is correctly fastened to
the regulator and user appliances.
• Makesurethehandleisinthe“closed”
position(thishappenswhenonthehandle
is visible a red rectangle with the marking
“OFF”)(Fig2).
•Remove the plastic protective plug from
the automatic valve.
• Pullthering(3)upwardsasshownin
gure3andttheKOSAN35ontothe
valve.Afterwardsgivethering(3)a
strong push downwards as shown in
gure4.A“CLICK”shouldbeheard,
meaning the regulator has been correctly
tted.
Operation
OPEN(ON):Aftercorrectlyttingthe
regulatorontothevalve,thegasow
can be opened by turning the knob a
half turn counterclockwise until the
stop, until you reach the opposite
horizontal position. In this position a
redamewith“ON”isvisibleas
showningure5.Inthispositionthe
valveisopenedandthegasowis
allowed.
CLOSED(OFF):Thegasowcanbe
stopped by turning the knob a half
turn clockwise until the stop, until you
reach the opposite horizontal position
“OFF”.Inthispositionthevalveis
closed.
Replacing the gas cylinder
Make sure that:
All taps of the user appliance are closed.
The opening knob of the KOSAN 35 is in the
closedposition(byturningitahalfturnuntil
thestop,theredameisnotvisible,“OFF”).
Afterwards, remove the regulator by pulling
thering(3)asshowningure6.Note:itis
not possible to pull the ring until the knob
is in the horizontal position and the marking
“OFF”isnotvisible.Thisisanimportant
security feature. The user must not try to
pull the regulator ring if the knob is not in
the“OFF”position.Pleasecontactyourgas
supplier if you have any problem.
System maintenance
• Toensurecorrectoperationoftheow
limiting device during gas supply, the
appliances hose length should be 1.5m at
maximum.
•If the system is not used for long periods
oftime(e.g.,inwinter),disconnectthe
pressure regulator of the tank. Protect the
pressureregulatortopreventanyying
mud.
•Normally the hose must be changed every
5 years.
•In normal conditions of use, to ensure
correct system operation, it is best to
replace the pressure regulator every
10yearsfromthedateofstartup.The
pressure regulator must conform to the
EN12864standard.
•When replacing the pressure regulator or
the hose, it may be necessary to replace
the clamps.
•After performing any maintenance
operations, always check the seal of the
system before starting it again.
• Thepressureregulatordoesnotrequire
any special maintenance jobs, but always
makesurethevent(2)isnotblocked.If
it is blocked, it can be freed by means of
a needle.
LIST OF FEATURES
The numbering of the product features
shown refers to the illustration of the
barbecue on the graphic page.
1. Handle
2. Hood
3. Cooking grill
4. Burners
5. Vaporizer bars
6. Grease tray
7. Control knobs
8. Barbecue body
USER INSTRUCTIONS
Before proceeding, make certain that you
understand the WARNING statements in this
manual.
•Preparation before cooking – To prevent
Other manuals for KLASEN
10
Table of contents
Other IKEA Grill manuals
Popular Grill manuals by other brands
Kenmore
Kenmore 415.16123800 Use and care guide
Camp Chef
Camp Chef PG24CLAU Warning & instruction booklet
Tucker Barbecues
Tucker Barbecues GTR Series Assembly, installation and operating instructions
Monogram
Monogram ZGG540NCP1SS owner's manual
Equipex
Equipex Sodir Savoy Operation manual
Gaggenau
Gaggenau VR 414 610 use and care manual
