Heta SCAN-LINE GREEN 300 User manual
1
OPERATING AND INSTALLATION
INSTRUCTIONS
DANISH DESIGN . DANISH QUALITY . DANISH PRODUCTION
www.heta.dk
EN
SCAN-LINE GREEN 300
2
Declaration of Performance EN
__________________________________________________________________________________________________________________________________
Regulation No. 305/2011
DOP-Green 300 2330
1. Unique identification code of product-type Pellet Stove
2. Product name Green 300
3. Usage prévu du produit par rapport à l’homologation
actuel
Room heating appliance, fueled by pellets without hot water
supply
4. Raison sociale et adresse du fabricant Heta A/S, Jupitervej 22, DK-7620 Lemvig. heta@heta.dk
5. Raison sociale et adresse du revendeur Fabrikschef Martin Bach, E-mail: martin.bach@heta.dk
6. Système d’évaluation et de vérification selon AVPC System 3
7. Notified body relevant to the assessment and
verification of constancy of performance
Teknologisk Institut, DK-8000 Aarhus
Notified body No. 1235
Rapport nr. 300-ELAB-2330-EN
8. Declared Performance
Harmonized technical
specification EN 14785:2006 Nominal load EN 14785:2006 Nominal low load
Emission CO 0,01% / 133 Mg/Nm3
Nox 161 mg/Nm3
Dust 19 mg/Nm3
Dust (NS3058/3059) --- g/kg
OGC (CEN/TS 15883) 6 mgC/Nm3- 13% O2
Energy consumption 33 W/h
CO 0,02% / 279 Mg/Nm3
Nox 145 mg/Nm3
Dust --- mg/Nm3
Dust (NS3058/3059) --- g/kg
OGC (CEN/TS 15883) 14 mgC/Nm3- 13% O2
Energy consumption 11 W/h
Fire safety
Reaction to fire A1
Testing of fire safety in connection with burning of wood pellets Approved
Distance to combustible materials
Rear
Sides distance to combustible materials
Distance to floor from lower edge of the door
Furniture distance
Minimum distances in mm
50
75
---
700
Safety
Mechanical resistance (to carry a chimney / flue) Pas testé (NPD)
Electrical safety Pass
Surface temperature Pass
Cleanability Pass
Thermal output
Nominal heat output 2,4-6 kW
Room heat output 2,4-6 kW
Energy efficiency Ƞ97%-94%
Fluegas temperature at nominal heat output T 35oC-76°C
Water heating output NA
Maximum water operating pressure NA
9.
The performance of the product identified in points 1 and 2 is in conformity with the declared performance in point 8. This
declaration of performance is issued under the sole responsibility of the manufacturer.
Signed on behalf the manufacturer of 01.07.2019
____________________________________________________________________________________________________________________
In case of any change of the above-mentioned production type this Declaration of Performance becomes invalid.
Heta A/S, Jupitervej 22, DK-7620 Lemvig, Tlf. +45 9663 0600, www.heta.dk
Side 1 of 1
Certifikat no. 2330
3
Congratulations on your new wood stove, we are confident that you will be more than satis-
fied with your new Heta stove. Especially if you follow the following advice and instructions.
The Green 300 pellet stove is approved under EN 14785.
These approvals are your guarantee as a consumer that the pellet stove meets a number of
specifications and requirements which confirm that the stove is made of high-quality mate-
rials, that it is economical to use, and it is not harmful to the environment.
Please read these instructions for use carefully prior to installation and operation to avoid
personal injury or damage to building parts or the product itself.
Heta A/S
Jupitervej 22,
DK-7620 Lemvig
Phone: +45 9663 0600
E-mail: [email protected]
Copyright © 2014
Heta is a registered
trademark of Heta A/S
08.03.2020
0037-1555 Version 1,3
Printed in Denmark
Subject to printing errors
and changes.
Operating Instructions Contents
Declaration of Performance ............................................................... 2
Before installation........................................................................... 4-5
1. Operating instructions........................................................................ 6
Before using ....................................................................................... 6
Påfyldning af træpiller ........................................................................ 6
First firing ........................................................................................... 6
Lighting............................................................................................... 6
Manual pellet feeding......................................................................... 6
Wood pellets ..................................................................................... 6
Display................................................................................................ 7
Menu structure ................................................................................... 7
Menu overview ................................................................................... 8
Timer setting .................................................................................... 10
Settings ............................................................................................ 12
Safety systems................................................................................. 12
2. Cleaning and Service
Daily Cleaning ...................................................................................13
Weekly cleaning ............................................................................... 13
Monthly cleaning ...............................................................................13
Semi annually / Annually ...................................................................13
Vermiculitestone................................................................................14
Service interval..................................................................................14
Cleaning interval................................................................................15
Troubleshooting ................................................................................16
Chimney fire ..................................................................................... 16
Error codes and descriptions............................................................17
Test run .............................................................................................18
Stove data table EN 14785 .............................................................. 19
Garantee........................................................................................... 19
Træpiller ............................................................................................20
3. Installation Instructions .................................................................... 21
4
BEFORE INSTALLATION
Heta stoves are quality products, therefore, your first impression is very important! We have a good
logistics network, which transports Heta products with great care for our dealers. Nevertheless,
when in transport or handling, damage of the often-heavy stoves can occur. It is important that
upon receipt check your Heta product completely and report any damage or defects to your dealer.
The packaging must be disposed of as follows:
Wood is untreated and able to burn. Plastic and cardboard you can drop off at your local recycling
center.
Unpacking the stove
1
2
17 mm
Bolts should only be
loosened so that transport
brackets can be removed
and then reattached.
5
With your new wood stove you should find the following:
Operating /
Instruction manual
Data plate
Q.C. check
8056-0000-D
K
CE
Heta A/S Jupitervej 22
7620 Lemvig Denmark
Produk�ons år: 2016
Produkt beskrivelse Produk�onsnummer
Afstand �l brændbart materiale - bag ovn
Afstand �l brændbart materiale - side af ovn
Afstand �l møbel
Middel CO emission nominel last ved 13% O2
Middel CO emission I Mg/Nm3 ved 13% O2
656 Mg.
Røggas Temp. Nominel last
261 C°
Støv
> 3 Mg/Nm3
OGC
32 Mg/Nm3
Ydelse nominel last 4,5 k
w
Virkningsgrad nominel last
81%
Støv (NS 3058/3059) samlet vægtet par�kelemission
0,63 g/kg
Brændsel
Træ
ovnen er egnet �l intermiterrende drif
t
Anvend kun godkendt brændsel
Følg fabrikantens brugervejledning
DOP-Scan-line 1000 -XXXX-2016
0,05%
DS/EN 13240, AEA, NS 3058/3059, Aus §15A
120 mm
350 mm
850 mm
Scan-Line 1000 brændeovn
Required tools and grease are not supplied.
1
BETJENINGS- OG
OPSTILLINGSVEJLEDNING
DANSK DESIGN . DANSK KVALITET . DANSK PRODUKTION
www.heta.dk
DK
GREEN 300
1
3
5
4
2
1) 5032-0079 Complete flue pipe
connector 1
2) 1520-0054 Handle 1
3) 0010-0408 Protection 1
4) 5020-0014 Cleaning brush 1
5) 0024-0085 Box for accessories 1
3
1
2
1) 0025-0222 Display 1
2) 0024-0108 Box for display 1
3) 0023-0241 Baffle plate 1
Ash pan
6
1. OPERATING INSTRUCTIONS
Before using
Inden pilleovnen tages i brug, skal du sikre dig,
at opstillingsbetingelserne er overholdt.
Se side 21.
Filling of wood pellets
Remember to close the pellet lid, otherwise the
lid sensor will be activated and the wood pellets
will not be fed through.
First firing
The stove paint is fully cured from the factory,
but a minor unpleasant odour could still arise.
Lighting the stove
1. Check that the burn pot is in place in the
frame. See page 13.
2. Roll out the room temperature sensor which
is located on the back of the stove. Make
sure that it does not come into contact with
cold or hot surfaces.
3. Connect the stove to the mains using the
supplied cable.
4. Set the desired settings using the display.
See page 7.
5. Feed the pellets through as mentioned
below.
6. Start the stove. See page 8.
Manual pellet feeding
Before starting your stove for the first time or if
it has run out of wood pellets, the pellet feeder
may be completely empty and therefore ignition
may fail. To avoid this, on the display you can
manually fill the pellet feeder before starting the
stove.
Follow these steps to enable pill feeding:
Press and then select .
Activate manual pill feed by sliding the button
to the right. When the bottom of the burn pot
is covered with wood pellets, the pellet feed is
deactivated again and the burn pot is emptied
of pellets to ensure that the ignition sequence is
performed correctly.
Wood pellets
Only quality pellets with a diameter of 6-8 mm
may be used as fuel. However, we recommend
6 mm for better dosing. We strongly advise
against using waste or liquid fuels!
Never open the stove door while
the stove is in operation. When
the oven is switched on, all surfaces and
glasses are extremely hot and should only
be handled using the appropriate protection.
1
2
3
Open the pellet lid.
Fill the pellet tank with wood pellets.
7
Display
Avoid water or other liquids coming
into contact with the electronics,
which may be destroyed and result
in technical failures or malfunction
and be dangerous to life.
Transparent protective film
It is recommended that you remove the protec-
tive film before using the Display to guarantee
the best performance of the sensitive (touch)
surface.
Main menu 1 Time and date Error code
On/Off
Menu structure
11:24 Man 14 Apr 2019
24°
21°C
Er.01
OFF
Status
By swiping down from the top
of the display, you can see the
combustion state and the cur-
rent combustion effect.
24°
22°C
12:18 Ven 14 Ott 2016 Er52
Produktkode
PA
OFF
Settings
Customization
Info Chrono
8
Menu overview
1
Swipe for at tænde
2
ON
Settings
Power Thermostats Manual Load
Slide to turn on.
Power
P3
5Calibrazione Ventilatore
Combustion
P2
P3
Auto
Combustion
9
Thermostats
Room 40
4
3
5
10
24
22
23
25
26
Room
Manual Load
Manual load
00:00
Manual load
Manual Load
10
Brightness
Minimum brightness
Standby display
Control panel address
Reboot control panel
Display Menu
5
6
Røggas temperatur Stue temperatur Luftstøm Ventilatorhastighed
Snegl Arbejdstid Tændinger Produktkode
Settings
Costumization
Settings
Time and Date
Language
Remote Control OFF
Calibration Auger 0
Calibration Fan 0
310°C
5.5 s
19°C
59 h
90%
74
1590 rpm
0
Info Menu
Exhaust temp. Room temp. Air Flux Fan speed
Auger Worktime Ignitions Product Code
System Menu Display Menu
Other manuals for SCAN-LINE GREEN 300
1
Table of contents
Other Heta Stove manuals
Heta
Heta Scan-Line 900 Series User manual
Heta
Heta Ambition Series User manual
Heta
Heta Classic Series User manual
Heta
Heta Vista User manual
Heta
Heta SCAN-LINE 40 User manual
Heta
Heta SCAN-LINE 550 User manual
Heta
Heta INSPIRE 40 User manual
Heta
Heta SCAN-LINE 80 User manual
Heta
Heta SCAN-LINE 10 User manual
Heta
Heta Prestige Series User manual
Heta
Heta SCAN-LINE 550 User manual
Heta
Heta Scan-Line User manual
Heta
Heta SCAN-LINE SOLID C User manual
Heta
Heta Scan-Line 70 User manual
Heta
Heta Scan-Line 800 Series User manual
Heta
Heta Panorama User manual
Heta
Heta Scan-line 8 User manual
Heta
Heta CLEAN BURN SL 500 Series User manual
Heta
Heta SCAN-LINE 40 User manual
Heta
Heta Ambition 5 User manual
Popular Stove manuals by other brands
Arada
Arada Cassette Stove installation guide
Parmco
Parmco FS 600 Installation and operating instructions
MCZ
MCZ SUITE AIR 10 M2 installation guide
HearthStone
HearthStone Stowe DV 8321 Owner's manual & installation guide
Cattara
Cattara FAMILY manual
Stanley
Stanley Argon F500 OVAL Installation and operating instructions
Avalon
Avalon B-VENT instructions
Nordpeis
Nordpeis Vega user manual
Exquisit
Exquisit EKC601-5 Instructions for use and installation
Stanley
Stanley Oisin Oil MK II Installation and operation instruction
Thermocet
Thermocet Brookfield S/CC Operating and installation instructions
HASE
HASE delhi operating instructions
Vermont Castings
Vermont Castings Intrepid 2 User instructions
Italiana Camini
Italiana Camini CLASSICA Installation, use and maintenance
Avalon
Avalon Vashon Avanti DVS FS manual
Spartherm
Spartherm ambiente a1 Installation and operating manual
Dimplex
Dimplex MCFSTV12AU manual
Warmlite
Warmlite WL46040 manual