Grundfos MAGNA1 D Operating manual
GRUNDFOS INSTRUCTIONS
MAGNA1
Safety instructions and other important information
2
English (US)
English (US) Safety instructions
Original safety instructions
CONTENTS Page
1. Symbols used in this document
1. Symbols used in this document 2
2. Type key 3
3. Pumped liquids 4
4. Installation 4
4.1 Changing the control box position 4
5. Electrical connection 4
6. Operation 5
7. Fault finding 5
8. Technical data 5
8.1 Ambient temperature 5
8.2 Maximum system pressure 5
8.3 Approvals 5
9. Further product information 5
10. Disposal 5
Warning
Prior to installation, read this
document and the Quick Guide.
Installation and operation must
comply with local regulations and
accepted codes of good practice.
Warning
The use of this product requires
experience with and knowledge of the
product.
Persons with reduced physical,
sensory or mental capabilities must
not use this product, unless they are
under supervision or have been
instructed in the use of the product by
a person responsible for their safety.
Children must not use or play with this
product.
Warning
If these safety instructions are not
observed, it may result in personal
injury.
Warning
If these instructions are not observed,
it may lead to electric shock with
consequent risk of serious personal
injury or death.
Warning
The surface of the product may be so
hot that it may cause burns or
personal injury.
Warning
Risk of dropping objects which may
cause personal injury.
Warning
Escaping vapor involves the risk of
personal injury.
Caution
If these safety instructions are not
observed, it may result in malfunction
or damage to the equipment.
Note
Notes or instructions that make the
job easier and ensure safe operation.
3
English (US)
2. Type key
Code Example MAGNA1 (D) 100 -120 (F) 360
Type range
MAGNA1
DSingle-head pump
Twin-head pump
Nominal diameter (DN) of suction and discharge ports [mm]
Maximum head [dm]
F
Pipe connection
Threaded
Flange
Port-to-port length [mm]
4
English (US)
3. Pumped liquids
The pump can be used for pumping water/glycol
mixtures up to 50 %.
4. Installation
4.1 Changing the control box position
5. Electrical connection
Carry out the electrical connection and
protection according to local regulations.
If rigid conduit is to be used, the hub must be
connected to the conduit system before it is
connected to the terminal box of the pump.
The protective earth (ground) symbol
identifies any terminal which is intended
for connection to an external conductor for
protection against electrical shock in case of a
fault, or the terminal of a protective earth
(ground) electrode.
Warning
Do not use the pump for flammable
liquids, such as diesel oil and
gasoline.
Warning
Observe local regulations setting
limits for manual lifting or handling.
Warning
Before dismantling the pump, drain
the system or close the isolating valve
on either side of the pump. The
pumped liquid may be scalding hot
and under high pressure.
Warning
When loosening the clamp, do not
drop the pump head.
Warning
Risk of escaping vapor.
Warning
Switch off the power supply before
making connections.
Warning
The pump must be connected to an
external mains switch with a minimum
contact gap of 0.12 inches (3 mm) in
all poles.
Grounding or neutralization must be
used for protection against indirect
contact.
If the pump is connected to an electric
installation where a Ground Fault
Circuit Interrupter (GFCI) is used as
an additional protection, this circuit
interrupter must trip when ground
fault currents with DC content
(pulsating DC) occur.
The ground fault circuit interrupter
must be marked with the first or both
of the symbols shown below:
Warning
It must be possible to lock the mains
switch in position 0. Type and
requirements as specified in EN
60204-1, 5.3.2.
5
English (US)
6. Operation
7. Fault finding
8. Technical data
8.1 Ambient temperature
+32 to +104 °F (0 to +40 °C).
8.2 Maximum system pressure
The maximum system pressure is indicated on
the nameplate:
175 psi (12 bar).
8.3 Approvals
Conforms to ANSI/UL Standard 778.
Certified to CAN/CSA Standard C22.2 No. 108.
9. Further product information
GRUNDFOS.COM/MANUAL-MAGNA1
10. Disposal
This product has been designed with a focus on
the disposal and recycling of materials.
The following average disposal values apply to
all variants of Grundfos MAGNA1 pumps:
• 85 % recycling
• 10 % incineration
• 5 % depositing.
This product or parts of it must be disposed of in
an environmentally sound way according to local
regulations.
Subject to alterations.
Warning
At high liquid temperatures, the pump
may be very hot. In that case only
touch the button.
The surface of the pump may be so
hot that it may cause burns or
personal injury.
Warning
Before dismantling the pump or
related parts, drain the system and
close the isolating valves on both
sides of the pump as the pumped
liquid may be scalding hot and under
high pressure.
Warning
If the power supply cable is damaged,
it must be replaced by the
manufacturer, the manufacturer’s
service partner or a similarly qualified
person.
6
Grundfos companies
GRUNDFOS Kansas City
17100 West 118th Terrace
Olathe, Kansas 66061
Phone: (913) 227-3400
Fax: (913) 227-3500
www.grundfos.us
GRUNDFOS Canada
2941 Brighton Road
Oakville, Ontario L6H 6C9 Canada
Phone: +1-905 829 9533
Telefax: +1-905 829 9512
www.grundfos.ca
GRUNDFOS México
Boulevard TLC No. 15
Parque Industrial Stiva Aeropuerto
C.P. 66600 Apodaca, N.L. México
Phone: 011-52-81-8144 4000
Fax: 011-52-81-8144 4010
www.grundfos.mx
L-MAG-TL-10
98385926 0813
ECM: 1119524
www.grundfos.com
The name Grundfos, the Grundfos logo, and be think innovate are registered trademarks
owned by Grundfos Holding A/S or Grundfos A/S, Denmark. All rights reserved worldwide. © Copyright Grundfos Holding A/S
Other manuals for MAGNA1 D
13
Table of contents
Other Grundfos Water Pump manuals
Grundfos
Grundfos JPC Series User manual
Grundfos
Grundfos Conlift1 LS User manual
Grundfos
Grundfos PUST04 User manual
Grundfos
Grundfos CRK Series User manual
Grundfos
Grundfos Conlift1 LS User manual
Grundfos
Grundfos CM Booster PS User manual
Grundfos
Grundfos Hydro EN User manual
Grundfos
Grundfos UPS2 User manual
Grundfos
Grundfos SB Series User manual
Grundfos
Grundfos MGE F Operating instructions
Grundfos
Grundfos DMX 221 Series User manual
Grundfos
Grundfos DMX 226 User manual
Grundfos
Grundfos SP Series User manual
Grundfos
Grundfos TPE User manual
Grundfos
Grundfos CR Series User manual
Grundfos
Grundfos Sololift2 CWC-3 User manual
Grundfos
Grundfos JP Operating instructions
Grundfos
Grundfos SRP User manual
Grundfos
Grundfos SCALA1 Operating manual
Grundfos
Grundfos UPM3 Parts list manual
Popular Water Pump manuals by other brands
Sykes AmeriPumps
Sykes AmeriPumps GP100M Operation and maintenance instructions
DUROMAX
DUROMAX XP WX Series user manual
BRINKMANN PUMPS
BRINKMANN PUMPS SBF550 operating instructions
Franklin Electric
Franklin Electric IPS Installation & operation manual
Xylem
Xylem e-1532 Series instruction manual
Milton Roy
Milton Roy PRIMEROYAL instruction manual