Fantech HV-150CAP User manual

Part No INST-HVCAP 7/07/2008

1 of 3

HV Stylvent Weather Cap

Instructions Installation

Contents:

Check that your HV-Weather Cap contains

• Weather Cap (1).

• Weather Cap Mounting Screws (3 for HV-150CAP and HV-230CAP), (4 for HV-300CAP).

• M4 Nuts and Washers (3 for HV-150CAP and HV-230CAP), (4 for HV-300CAP).

• White mounting tabs (3 for HV-150CAP and HV-230CAP), (4 for HV-300CAP).

Inspection:

Before installing check both your HV Stylvent fan and Weather Cap for any transit damage.

Installation:

• Cut a hole following the dimensions in Fig. A.

(mm) HV-150 HV-230 HV-300

∅D

Min 187 259 327

∅D

Max 190 262 330

• Preparing The HV-Fan:

1. Remove the cover (a) by unscrewing the retaining screw (b) found on the bottom of the fan. Then

press the tabs (c) and lift off the cover.

2. To remove the external grille (e) from the fan backing plate (f) unscrew the plastic fasteners (d). Note

the HV-150 and HV-230 have 3 fasteners whereas the HV-300 has 4.

Part No INST-HVCAP 7/07/2008

2 of 3

• Preparing The Weather Cap:

1. Remove the rubber moulded grommets (g) from the grille fastening screws (h). Keep the grommets as

they are required for installing the Weather Cap. Discard the external grille (e) with its screws (h)

which will now be replaced by the Weather Cap.

2. Put the

Weather Cap Mounting Screws

(p), into the holes within the collar section of the Weather Cap

from the inside so the screws point out toward you. Slide on the rubber grommets (g) with the flat side

up, then the white tabs (n), the washers (o) and hold them in place with the nuts (r) leave the nuts

loose for now.

• Installing The Weather Cap and Fan:

1. Make sure the rubber grommets and tabs are turned inward as shown (below).

2. From the outside put the cap over the hole in the window/panel. Make sure you mount the cap the

correct way up, the label located on the collar of the Weather Cap indicates the top of the cap.

o p

Data

Label

Part No INST-HVCAP 7/07/2008

3 of 3

3. From the inside rotate the rubber grommets (g) and white tabs (n) outward over the window or panel.

Tighten the nuts (r) so the cap is held firmly in place. Caution Do Not Over Tighten Nuts, a small

amount of movement in the rubber grommet is needed so the screws can be lined up when attaching

the fan.

4. Mount the fan backing plate (f) to the

Weather Cap Mounting Screws

(p) and tighten the fasteners (d).

Note the orientation of the fasteners will depend on the thickness of the installation.

- For Window or Panel 3-14mm Thick refer to (d) circled in Fig. B.

- For Wall Mounting 14-25mm Thick refer to (d) circled in Fig. C.

3. For wiring instructions see your HV-Fan instruction leaflet

4. Mount the internal cover (a) by slotting the rectangular openings (l) on top of the cover into the

receivers (m) of the fan mounting plate until the two tabs (c) are correctly positioned. Then replace the

locking screw (b)

HV Weather Caps Are Distributed By Fantech Pty Ltd.

Ph:(03)8545 2345 Fax:(03)8545 2333 e-mail [email protected]

Window Or Panel

n g

fig. B fig. C

c b

This manual suits for next models

Table of contents

Other Fantech Fan manuals

Fantech

Fantech PB Series Instruction manual

Fantech

Fantech SH704 User manual

Fantech

Fantech Fit 120H User manual

Fantech

Fantech VER200 User manual

Fantech

Fantech Ezifit EWE154 User manual

Fantech

Fantech RIL-125 User manual

Fantech

Fantech FIT 70E User manual

Fantech

Fantech PB110 Manual

Fantech

Fantech PB Series User manual

Fantech

Fantech RIL-150T Installation and operating instructions

Fantech

Fantech FRD Series User manual

Fantech

Fantech SER 1504 User manual

Fantech

Fantech VHR 2004 User manual

Fantech

Fantech SER200 User manual

Fantech

Fantech FADE User manual

Fantech

Fantech 2SHE0721 Series Instructions for use

Fantech

Fantech PBW Series Manual

Fantech

Fantech Ezifit Thru Roof ERV150 User manual

Fantech

Fantech MINITUBE Series Installation and operating instructions

Fantech

Fantech PB110L7 Manual

Fantech

Fantech RIL-150SW Installation and operating instructions

Fantech

Fantech Jetstream JCE150SJK User manual

Fantech

Fantech SER Series User manual

Fantech

Fantech Jetstream JCE202-3 User manual

Popular Fan manuals by other brands

ELTA FANS

ELTA FANS H03VV-F installation guide

Hunter

Hunter 20714 Owner's guide and installation manual

Emerson

Emerson CARRERA VERANDA CF542ORB00 owner's manual

Hunter

Hunter Caraway Owner's guide and installation manual

Panasonic

Panasonic FV-15NLFS1 Service manual

Kompernass

Kompernass KH 1150 operating instructions

VES

VES FALA100/12V/TR Original instructions

Vertiv

Vertiv Liebert DCD user manual

Westinghouse

Westinghouse GFP Series owner's manual

Venmar

Venmar KUBIX HRV PLUS Series user guide

Maico

Maico ECR 31 installation instructions

Sonnenkonig

Sonnenkonig Dinky instruction manual

S&P

S&P ECOWATT HXBR manual

Wider

Wider IMP03369BH instruction manual

Panasonic

Panasonic F-60DHN Operating and installation instructions

Hinkley

Hinkley HIGHLAND instruction manual

Broan

Broan 766BN installation guide

Premium

Premium PFS16022 Use manual