Danby DWM5500W User manual

Danby Products Ltd.

DWM5500W SWM5500W

SERVICE MANUAL

INDEX

CONTROL OF THE COLLECTOR ELECTRIC MOTORS

DRIVE ELECTRIC MOTOR

THERMOSTAT

PRESSURE SWITCH

POTENTIOMETER

PUMP

HEATER

SOLENOID VALVE

DOOR SWITCH

10.

CONTACTOR

11.

TIMER

12.

FLOW CHART

13.

PRODUCT INFORMATION SHEETS

14.

SERVICE EQUIPMENT

15.

TROUBLE SHOOTING

16.

PARTS LIST AND DIAGRAM

1. CONTROL OF THE COLLECTOR ELECTRIC MOTORS ON WM WITH EL.

REGULATION

When rotor of the electric motor comes into short circuit it is likely that the el.

regulation will get damaged. It is impossible to check short circuit with the multimeter

at the customer due to very low impedance.

To avoid new el. regulation to get damaged is our suggestion to check el. motor as

follows:

Check visual electronic regulation (burnt out components).

Check wiring harness

Connect new el. motor

If it does not rotate and wiring harness is O.K. , change el. regulation.

Before connecting old el. motor, check it as follows:

Visual: burnt out collector, damaged collector – change the el. motor

Adjust wash program to the intermediate spins or final spin on washing machine with

800 – 1000 rpm (with potentiometer or with switch reduce the spin to the minimum).

Intermediate spins perform in steps , it is low possibility of getting el. regulation

damaged due to short circuit of the el. motor rotor coil.

If the rotor coil is in short circuit, there will be sparkling on the collector. If there is no

sparkling, wait for the end of the spin and try again.

2. DRIVE ELECTRIC MOTOR

Tip: FHP U112 G55 USA - universal part No.: 607931

Nominal voltage: 220-240 V, 60 Hz

Nominal mains supply: tumbling phase: 230 W

spinning phase: 47 W

Max. number of revolutions: spin: 12900 rpm

tumbling: 650 rpm

Ohm resistance: Tachogenerator (1-2): 137 ohm

Rotor (3-4): 2.00 ohm

Stator (5-6): 1.36 ohm

Direction of spin rotation (observed in direction of the pulley):

Counter-clockwise: power supply 6 and 3, short circuited 4 and 5

3. THERMOSTAT - ADJUSTABLE

Typ: 55 13019.103 part number: 078624

alternative part numbers: 550914,

530407

Temperature range: 27.5 – 88 +/- 4 °C

Switching capacity: 16(4) A / 250 V

Switching difference: 6 +/- 2.5 °C

wiring diagram:

4. PRESSURE SWITCH - DOUBLE

Type: A2 – 681 part number: 609461

rated level (mm H2O):

contacts: 11-12 11-14 (heater protection)

80 +/-7.5 110 +/- 7.5

contacts: 21-22 21-24 21-26

95 +/-5 130 +/-5 300 +/- 30

wiring diagram:

PRESSURE SWITCH - DOUBLE

Type: A2 – 688 part number: 609462

rated level (mm H2O):

contacts: 11-12 11-14 11-16

120 +/-5 160 +/- 5 300 +/- 30

contacts: 21-22 21-24

150 +/-7.5 190 +/-7.5

wiring diagram:

5. POTENTIOMETER

Typ: PC 6G 22k log part number: 368306

Resistance range: 0-22 K+/- 10%

6. PUMP - SYNCHRONOUS

Typ: part number: 553645

Supply voltage: 208-240 V, 60 Hz

Power: 34 W

Capacity: 16 l/min at nominal voltage

Winding resistance: 95 +/- 7% 

7. HEATER

Typ: TUBULAR HEATER šifra: 657139

Voltage: 120 V

El. power: 1300 W

Ohmska upornost: 11 ohm

8. SOLENOID VALVE – SINGLE – WARM WATER

Type: ES 180/88 part number: 550957

Supply voltage: 220/240 V, 50/60 Hz

Coil resistance: 3700 +/-8% (at 20 °C)

Connection of inlet hose: ¾ "

Working pressure: 0.2 – 10 bar

Rated flow: 7 l/min +/-15%

Rated power: 8 VA

SOLENOID VALVE - DOUBLE

Type: ED 180/88 part number: 606715

alternative part numbers: 609396

Supply voltage: 220/240 V, 50/60 Hz

Coil resistance: 3700 +/-8% (at 20 °C)

Connection of inlet hose: ¾ "

Working pressure: 0.2 – 10 bar

Rated flow: 7 +/-10% l/min

Rated power: 8 VA

9. DOOR SWITCH WITH LOCKING DEVICE

Type: ROLD part number: 667490

supply voltage: 120/240 V, 60 Hz

closed: 16 (4) A

open: 0 (0) A

locking: min.2 – max.8 sec. at temperature 20°-35°C after machine

switching on

unlocking: min.35 – max.65 sec. at temperature 20°C after machine

switching off

wiring diagram:

10. CONTACTOR

Type: EBERLE 0419 01 1101 00 part number: 657141

wiring diagram:

Other manuals for DWM5500W

This manual suits for next models

Table of contents

Other Danby Washer manuals

Danby

Danby DWM12C1WDB User manual

Danby

Danby DWM055A1WDB-6 User manual

Danby

Danby Simplicity SWM5500W User manual

Danby

Danby DWM5500W User manual

Danby

Danby DWM99W User manual

Danby

Danby DWM060WDB Assembly instructions

Danby

Danby DWM028WDB-3 User manual

Danby

Danby DWM060WDB User manual

Danby

Danby DTT420 Operating and maintenance manual

Danby

Danby DWM5500W User manual

Danby

Danby DWM17WDB Assembly instructions

Danby

Danby DWM055WDB User manual

Danby

Danby DWM030WDB-6 User manual

Danby

Danby DWM055A1WDB-6 User manual

Danby

Danby DWM030WDB-6 User manual

Danby

Danby DWM045DB User manual

Danby

Danby DWM045WDB Assembly instructions

Danby

Danby DWM17WDB User manual

Danby

Danby DTT100A1WDB Assembly instructions

Popular Washer manuals by other brands

Tricity Bendix

Tricity Bendix AW 1000 W Operating & installation instructions

Panasonic

Panasonic NA-F60L5WRB operating instructions

GE WSLP1500 Dimensions and installation information

Electrolux

Electrolux EWF1284EDW Service manual

Bosch

Bosch WAN2829BSN User manual and installation instructions

LG TV2516DV3B owner's manual

LG TH2517DSAV owner's manual

VESTEL

VESTEL CMH-XL 7510 TE user manual

AEG

AEG 74335 User information

Johnson

Johnson JWF721A user manual

Beko

Beko WTE7604XLW0 owner's manual

Amica

Amica WA 14 Ex operating instructions

Daewoo

Daewoo DWD-F1222 instruction manual

Bosch

Bosch WAS28461AU instruction manual

Miele

Miele PW 6080 Vario manual

Finlux

Finlux FLX108CF220 user manual

Whirlpool

Whirlpool 3LBR5132AN0 Use and care guide

Beko

Beko WKB 51231 PTMA manual