Cornelius FCB V2 Specifications

8/931560000853

Hidden Security

Switch Message Display

FCB Operator Instructions

Applies to V2, V3 & V3+ Units

Syrup 1 or Syrup 2 Message (see back for freeze cylinder location)

If either freeze cylinder is out of syrup, a warning will “Beep” seven times. The message display will

indicate Syrup 1 or Syrup 2. This indicates the syrup supplying that freeze cylinder must be replaced.

Proceed as follows:

Tank System

A. Remove the empty syrup tank by disconnecting the syrup tube first, then the CO2tube.

B. Rinse the disconnects in warm water to remove any syrup residue.

C. Move a full tank into position and connect the CO2first, then the syrup tube. Proceed to step F.

Bag-in-Box System

D. Disconnect the syrup tube from the empty bag-in-box and remove the empty bag-in-box.

E. Install a full bag-in-box and connect the syrup tube. Proceed to step F.

FCB Control Panel

F. At the FCB panel, press and hold the Hidden Security Switch for 10 seconds. This unlocks the

panel and allows programming.

G. Press Off 1 or Off 2 depending on which cylinder is being replenished.

H. Press and hold the Fill 1 or Fill 2 until the Syrup 1 or Syrup 2 message goes out.

I. If the Syrup 1 or Syrup 2 message does not change to Fill 1, or Fill 2, repeat step H until it

does.

J. Press Autoblend 1 or Autoblend 2. The blend tank will fill automatically.

K. Slowly pull the relief valve ring on the faceplate to relieve the CO2pressure while the cylinder is

filling. When the cylinder is full, liquid will run from the tube.

L. Press Auto 1 or Auto 2 to start the freeze process. The freeze cylinder beaters and the refrigera-

tion system will start automatically. Do not start unless the freeze cylinders are FULL.

M. Press and hold the Hidden Security Switch for seven seconds. This will re-lock the panel so

unauthorized persons cannot disturb the settings. Test by pressing the Off 1 switch. Nothing

should happen.

See back for tank illustration and freeze cylinder location

560000853 2 8/93

Operators Instructions, continued

Gas Liq

Tank Illustration

ÄÄÄ

ÄÄÄ

ÄÄÄ

ÄÄÄ

ÄÄÄ

ÄÄÄ

Gray Top Black Top

Syrup

Cylinder 1

Cylinder 2

Freeze Cylinder Location

CO2

“CO2Out”

CO2cylinder is empty or the valve is closed. Seven warning “Beeps”will sound.

A. Restore the CO2supply.

B. The FCB will restart automatically.

“H2O Out”

The water to the FCB has been turned off or the pressure has dropped below minimum.

A. Restore the water supply.

B. The FCB will restart automatically.

Any other message –– Call your local service agent.

This manual suits for next models

1

Table of contents

Other Cornelius Beverage Dispenser manuals

Cornelius

Cornelius 3030 AK 6 User manual

Cornelius

Cornelius Visual Display Dispenser JS7-W25 User manual

Cornelius

Cornelius ED 300 BC User manual

Cornelius

Cornelius FCB VIPER User manual

Cornelius

Cornelius Quantum 45200003 User manual

Cornelius

Cornelius VANGUARD 245 User manual

Cornelius

Cornelius A8661 Setup guide

Cornelius

Cornelius Flavorfusion Ice Drink Dispenser with Flavor... User manual

Cornelius

Cornelius VIPER 3 FLAVOR User manual

Cornelius

Cornelius PRISM User manual

Cornelius

Cornelius Impulse Non-Carbonated Post-Mix Beverage... User manual

Cornelius

Cornelius ENDURO-175 User manual

Cornelius

Cornelius IntelliCarb Cold Beverage Dispenser Installation guide

Cornelius

Cornelius MillenniumII 4000 User manual

Cornelius

Cornelius ENDURO 250 User manual

Cornelius

Cornelius IDC 255 PROGATE DRIVE THRU UNIT User manual

Cornelius

Cornelius Quest Juice Dispenser User manual

Cornelius

Cornelius IDC 255 User manual

Cornelius

Cornelius Impulse Juice Dispenser 851000109 Setup guide

Cornelius

Cornelius A.B.S. Unit User manual

Cornelius

Cornelius TRIAD-150 User manual

Cornelius

Cornelius Quantum 45200001 Setup guide

Cornelius

Cornelius remcor DB275--BCP User manual

Cornelius

Cornelius ENDURO-150 6 VALVE User manual

Popular Beverage Dispenser manuals by other brands

PEGAS

PEGAS Evolution operating instructions

Ugolini

Ugolini MT micro Operator's manual

Bunn

Bunn SLCA-7 Installation & operating manual

Gekkeikan

Gekkeikan Sake Machine owner's manual

Olympia

Olympia DH709 Instructions for use

Marco

Marco ECOSMART PB10 instructions

Marvel

Marvel ML24BN Series Installation, operation and maintenance instructions

Cecilware

Cecilware 2K-GB-LD Catalog

Sure Vend

Sure Vend 673 Setup guide

Nostalgia Electrics

Nostalgia Electrics KEG7000SS instruction manual

Bunn

Bunn LCR-3 HV Installation & operating guide

Servend

Servend SV-200 manual 

EdgeStar

EdgeStar VBR440 owner's manual

CDS AUTOMATEN

CDS AUTOMATEN ML-16C2-C user manual

Siemens

Siemens GA 3000 OPERATING & SERVICE MANUAL

Selbach

Selbach Fruit Juice dispenser operating manual

Taylor

Taylor C302NP Operator's manual

Vinotemp

Vinotemp VT-WINEDISP2 owner's manual