Cornelius FCB V4 Specifications

FCB Operator’s Instructions

(Applies to V4 Units)

ÍÍÍÍ

(Forward)>

<(Backward)

Display

MOTOR

Side 1

Side 2

BLEND

ON/OFF SYRUP PRIME

OFF

ERROR

RESET

Manual Defrost Menu/Select

Cancel Defrost

*CONTROL PANEL SWITCH IDENTIFICATION

*THE CONTROL PANEL IS ACCESSIBLE BY

OPENING THE UNIT FRONT ACCESS DOOR

Syrup Out Side 1 or Syrup Out Side 2 Message (see back for freeze cylinder location)

If either freeze cylinder is out of syrup, a warning will “Beep” seven times. The message display will

indicate Syrup Out Side 1 or Syrup Out Side 2. This indicates the syrup supplying that freeze cylin-

der must be replaced.

Proceed as follows:

Bag-in-Box System

A. Disconnect the syrup tube from the empty bag-in-box and remove the empty bag-in-box.

B. Install a full bag-in-box and connect the syrup tube. Proceed to step C.

FCB Control Panel

C. At the FCB panel, press and hold any one of the buttons for 5 seconds. This unlocks the panel

and allows programming.

D. Press Off 1 or Off 2 depending on which cylinder is being replenished.

E. Press and hold the SYRUP PRIME 1 or SYRUP PRIME 2 until the Syrup Out Side 1 or

Syrup Out Side 2 message goes out.

F. If the Syrup OUT Side 1 or Syrup OUT Side 2 message does not go out, repeat step E.

until it does.

G. Slowly pull the relief valve ring on the faceplate to relieve the CO2pressure while the cylinder

is filling. When the cylinder is full, liquid will run from the tube.

H. Press ON 1 or ON 2 to start the freeze process. The freeze cylinder beaters and the refrigera-

tion system will start automatically. Do not start unless the freeze cylinders are FULL.

See back for Bag-in-Box illustration and freeze cylinder location

Revision Date: May 09, 2014 Revision: B ©

1994-2014, Cornelius Inc. Publication Number: 3711

Revision Date: May 09, 2014 Revision: B

FCB Operator’s Instructions Continued

BAG-IN-BOX ILLUSTRATION

CYLINDER 1

CYLINDER 2

FREEZE CYLINDER LOCATION

OFF

SYRUP OUTLET

TUBE

BAG VALVE

(CUT FROM EMPTY

BAG-IN-BOX CONTAINER)

INDICATOR LIGHTS (2)

*front access door

*THE CONTROL PANEL IS ACCESSIBLE BY

OPENING THE UNIT FRONT ACCESS DOOR

“CO2Out”

CO2cylinder is empty or the valve is closed. Seven warning “Beeps”will sound.

1. Restore the CO2supply.

2. The FCB will restart automatically.

“H2O Out”

The water to the FCB has been turned off or the pressure has dropped below minimum.

1. Restore the water supply.

2. The FCB will restart automatically.

“Front Access Door Indicator lights”

Two indicator lights are located on front of the Unit front access door. The indicator light on the left side monitors

conditions of the No.1 system and the indicator light on the right side monitors conditions on the No. 2 system.

A flashing red indicator light indicates a freeze cylinder is in the defrost mode. A flashing yellow indicator light

indicates “OUT OF SYRUP”, “OUT OF WATER”, “OUT OF CO2”,or an “ERROR” condition has occured.

Any other message –– Call your local service agent.

Table of contents

Other Cornelius Beverage Dispenser manuals

Cornelius

Cornelius ED Series Installation guide

Cornelius

Cornelius FCB VIPER User manual

Cornelius

Cornelius ENDURO-150 User manual

Cornelius

Cornelius 1522 User manual

Cornelius

Cornelius ED2XX 29677 User manual

Cornelius

Cornelius Agitator Motor 569000207 User manual

Cornelius

Cornelius 15 Gallon Single-Flavor Visual Display Dispenser... Installation guide

Cornelius

Cornelius VANTAGE User manual

Cornelius

Cornelius 2232MS Manual

Cornelius

Cornelius Remcor TJ200 User manual

Cornelius

Cornelius VANGUARD 245 User manual

Cornelius

Cornelius Cornelius VANTAGE POST-MIX DISPENSER User manual

Cornelius

Cornelius VIPER 4 FLAVOR User manual

Cornelius

Cornelius VIPER (E) 2 FLAVOR User manual

Cornelius

Cornelius IDC 2 Series User manual

Cornelius

Cornelius Drop-In Post-Mix Dispenser 2323 Universal User manual

Cornelius

Cornelius C10 User manual

Cornelius

Cornelius DF250 User manual

Cornelius

Cornelius Quantum 45200003 User manual

Cornelius

Cornelius TEA URN User manual

Cornelius

Cornelius IDC Pro Guide

Cornelius

Cornelius Profile 150 User manual

Cornelius

Cornelius Quest Juice Dispenser User manual

Cornelius

Cornelius remcor DB275--BCP User manual

Popular Beverage Dispenser manuals by other brands

PEGAS

PEGAS Evolution operating instructions

Ugolini

Ugolini MT micro Operator's manual

Bunn

Bunn SLCA-7 Installation & operating manual

Gekkeikan

Gekkeikan Sake Machine owner's manual

Olympia

Olympia DH709 Instructions for use

Marco

Marco ECOSMART PB10 instructions

Marvel

Marvel ML24BN Series Installation, operation and maintenance instructions

Cecilware

Cecilware 2K-GB-LD Catalog

Sure Vend

Sure Vend 673 Setup guide

Nostalgia Electrics

Nostalgia Electrics KEG7000SS instruction manual

Bunn

Bunn LCR-3 HV Installation & operating guide

Servend

Servend SV-200 manual 

EdgeStar

EdgeStar VBR440 owner's manual

CDS AUTOMATEN

CDS AUTOMATEN ML-16C2-C user manual

Siemens

Siemens GA 3000 OPERATING & SERVICE MANUAL

Selbach

Selbach Fruit Juice dispenser operating manual

Taylor

Taylor C302NP Operator's manual

Vinotemp

Vinotemp VT-WINEDISP2 owner's manual