Advantech MIO-6255 Installation and operation manual

MIO-6255 Startup Manual 1

MIO-6255 MIO/160 Module with 2 Cardbus

Startup Manual

The most flexible interface for Embedded

Applications

Today is an embedded world, but many standard embed-

ded single board computers cannot 100% meet application

specifications because they are not flexible enough to

expand and develop the system.

A system design short cut

MIO/160 (Module I/O 160) is an open pin definition inter-

face from Advantech. The MIO/160 interface integrates the

most popular data buses into a high-density 160-pin con-

nector, including, PCI, USB, DVO, SMBus, LPC, and

AC97. With MIO/160, board engineers can speed up sys-

tem project design and expand the system easily.

Before you begin installing your card, please make

sure that the following materials have been shipped:

If any of these items are missing or damaged, contact

your distributor or sales representative immediately.

• Chipset: Richo R5C486 Cardbus controller

• 2 Cardbus solt: Accepts type I/II/III PCMCIA Card.

When type III Card used in slot 2, the slot 1 will be occu-

pied.

• 16-bit Legacy Mode: YES(3E0/3E2 I/O port) support

• Data bus: 32-bit data bus (Compliant with PCI Bus

Specification 2.1)

• PCI Interface: 3.3V interface(5V tolerant)

Mechanical and Environmental

• Dimensions (L x W): 120mm x 85mm, 4.7” x 3.3”

• Operating Temperature: 0 ~ 60°C operation

• Operating Humidity: 10%~90% relative humity, non-

condensing

• Complies with PC Card 95/97/98, Card-32(32bit), PCM-

CIA V2.1/JEIDA4.2(16bit)

• Support 2 PCMCIA slot, accepts type I/II/III PCMCIA

Cards

• MIO/160 interface

Introduction Specifications

Packing list

• 1 MIO-6255

• 1 Start-up manual

• 1 Screw kit p/n: 9660250000

- copper stud x 6 pcs p/n: 1930000058

- screw x 6 pcs p/n: 1935030500

Note 1: Acrobat Reader is required to view any PDF

file. Acrobat Reader can be downloaded at:

http://www.adobe.com/products/acrobat/

readstep2.html(Acrobat is a trademark of

Adobe.)

For more information on this and other Advantech

products, please visit our website at:

http://www.advantech.com

http://www.advantech.com/eplatform

For technical support and service, please visit our

support website at:

http://www.advantech.com/support

This manual is for the MIO-6255 series Rev. A1.

Part No.2006625500 1st Edition

May. 2006

Features

MIO-6255 MIO/160 Module with 2 Cardbus IC

2 MIO-6255 Startup Manual

Connectors on the board link it to external devices, such as

hard disk drives, a keyboard or expansion bus connectors.

In addition, the board has a number of jumpers that allow

you to configure your system to suit your application.

The table below lists the function of each of the jumpers

and connectors.

Locating connector (component side)

Locating connector (solder side)

Jumpers & Connectors

Connectors

Label Function

CN1 MIO/160 bus

CN2A/CN2B PCMCIA slot1/slot2

CN1 MIO/160 bus

Part Number 1654000071

Description B/B CONN. 80*2P 180D(M) SMD 0.8mm QTE-

080-05-F-D-A

CN2A/CN2B PCMCIA slot1/slot2

Part Number 1654268101/1654268102

Description PCMCIA 68P 90D(M) SMD DUAL SLOTS

1473283-1AMP

Description PCMCIA 68P 180D(F) SMD DUAL SLOTS

1123215-1AMP

Board Layout

MIO-6255 Startup Manual 3

Mechanical Drawing (component side) Mechanical Drawing (solder side)

FCC This device complies with the requirements in part 15 of the FCC rules: Operation is subject to the fol-

lowing two conditions:

1.This device may not cause harmful interference, and

2. This device must accept any interference received, including interference that may cause undes-

ired operation

This equipment has been tested and found to comply with the limits for a Class A digital device, pur-

suant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against

harmful interference when the equipment is operated in a commercial environment. This equipment

generates, uses, and can radiate radio frequency energy and, if not installed and used in accordance

with the instruction manual, may cause harmful interference to radio communications. Operation of

this device in a residential area is likely to cause harmful interference in which case the user will be

required to correct the interference at his/her own expense. The user is advised that any equipment

changes or modifications not expressly approved by the party responsible for compliance would void

the compliance to FCC regulations and therefore, the user's authority to operate the equipment.

Caution!

Achtung!

There is a danger of a new battery exploding if it is incorrectly installed. Do not attempt to recharge,

force open, or heat the battery. Replace the battery only with the same or equivalent type recom-

mended by the manufacturer. Discard used batteries according to the manufacturer’s instructions.

This manual suits for next models

Other Advantech Control Unit manuals

Advantech

Advantech USB-4716 User manual

Advantech

Advantech MIC-75G20-10B1 Installation and operation manual

Advantech

Advantech USB-4750 User manual

Advantech

Advantech EPD-132 User manual

Advantech

Advantech APAX-5202P User manual

Advantech

Advantech EPD-130 User manual

Advantech

Advantech SOM-5893 User manual

Advantech

Advantech ADAM-2000 Series User manual

Advantech

Advantech IPMI-1000 Installation and operation manual

Advantech

Advantech AMAX-4800 Series User manual

Advantech

Advantech WISE-4610 Series Installation and operation manual

Advantech

Advantech Qseven SOM-3567 User manual

Advantech

Advantech USB-5801 Installation and operation manual

Advantech

Advantech ADAM-3017 Installation and operation manual

Advantech

Advantech RISC Module SOM-A2552 User manual

Advantech

Advantech EDG-4100 Series Quick start guide

Advantech

Advantech SOM-7569 User manual

Advantech

Advantech EH-8100 User manual

Advantech

Advantech PCM-3664 Installation and operation manual

Advantech

Advantech Adam 4000 Series User manual

Advantech

Advantech ROM-7510 User manual

Advantech

Advantech SOM-6898 User manual

Advantech

Advantech B+B SmartWorx IE-iMcV-2xLIM User manual

Advantech

Advantech ADAM-6217 User manual

Popular Control Unit manuals by other brands

Festo

Festo Compact Performance CP-FB6-E Brief description

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Quick installation guide

JS Automation

JS Automation MPC3034A user manual

JAUDT

JAUDT SW GII 6406 Series Translation of the original operating instructions

Spektrum

Spektrum Air Module System manual

BOC Edwards

BOC Edwards Q Series instruction manual

KHADAS

KHADAS BT Magic quick start

Etherma

Etherma eNEXHO-IL Assembly and operating instructions

PMFoundations

PMFoundations Attenuverter Assembly guide

GEA

GEA VARIVENT Operating instruction

Walther Systemtechnik

Walther Systemtechnik VMS-05 Assembly instructions

Altronix

Altronix LINQ8PD Installation and programming manual

Eaton

Eaton Powerware Series user guide

WAGO

WAGO 750-407/040-000 manual

Sony

Sony CCU-590 Operation manual

Graco

Graco 25D614 instructions

Task Force Tips

Task Force Tips YE-RF-900 Instructions for installation, safe operation and maintenance

Shini

Shini SPV-U Series manual