Wolf HL-95 Manual
Wolf Hazard Lamp HL-95
Operation and maintenance Instructions
EU Declaration of Conformity
T e Wolf Hazard Lamp HL-95 meets all relevant provisions of t e
2014/34/EU (ATEX Equipment) Directive, by virtue of t e issued EU
Type Examination Certificate, demonstrating compliance wit all
relevant armonised standards and essential ealt and safety
requirements.
T e Wolf Hazard Lamp is a self-contained warning lamp, wit an LED
lig t source and powered by a special air depolarised primary
battery. T e enclosure is moulded in ig impact plastic. T e lamp is
approved as Group II, category 1 equipment for use in zone 0, 1 or 2
potentially explosive gas, vapour or mist atmosp eres, w ere t e T4
temperature class permits.
Only use t e specified HL-3155X battery.
Do not open in t e EX area.
Static Hazard – clean only wit a damp clot .
Approval Codes/Certification:
II 1G Ex ia op is IIC T4 Ga
T
a
=-10
o
C to 40
o
C
Notified Body:
SGS FIMKO OY. P.O. Box 30 (Särkiniementie 3)
00211 HELSINKI. Finland
Notified body number: 0598
EU Type examination certificate:
BAS99ATEX1044X
Special Conditions of Use (X Condition)
T e metal label and grill can generate a electrostatic c arge under
certain extreme conditions. T e user s all ensure t e Hazardlamp is
not placed in a location w ere t e external conditions are conducive
to t e build up of an electrostatic c arge.
Harmonised standards applied:
EN IEC 60079-0: 2018, EN60079-11: 2012, EN60079-28: 2015
Ingress protection level: IP21, to EN60529:1992,
Caution – Polycarbonate lens, c eck suitable for atmosp ere in Ex
area.
T e HL-95 is compliant wit t e 2014/30/EU EMC Directive to t e
following armonized standards:- EN 61000-6-2:2005 and
EN 61000-6-3:2007+A1:2011.
Alex Jackson – Managing Director
Wolf Safety Lamp Company Ltd.
Use of Wolf Hazard Lamp HL-95
Users s ould consult EN60079/IEC60079, or national equivalent, for
advice on t e selection and maintenance of electrical apparatus for
use in potentially explosive atmosp eres.
A damaged Hazard Lamp s ould be wit drawn, inspected and
repaired in accordance wit t ese instructions, before being put
back into service.
T e Wolf Hazard Lamp must not be opened in t e azardous area.
No modifications are permitted to t is product.
C eck ambient temperature for intended use, t e battery
performance is reduced in temperatures below -5
o
C
To Fit Battery
Remove locking screw and separate t e lamp front from rear.
Fit battery into lamp front and attac connector, ensure t e
connector is firmly attac ed to bot terminals.
Re-assemble two alves of lamp and locking screw, ensure wires
are not trapped.
Operation
External switc provides output selection as follows:
on static – off – on flas ing.
Internal switc on t e LED circuit board allows selection of daylig t
‘cut-out mode’, automatically turning t e lamp off in daylig t,
extending t e battery life.
T e flas rate may increase if t e lamp is operated near radio
frequency emissions in t e range 100MHz to 115MHz.
Spare Parts
Description Order Code
Circuit assembly HL-13A (amber LED)
LED colours for pre 2018 models are still available on request
Lock screw HL-25
Lock Key HL-05
Battery HL-3155X
In t e event of circuit failure, only t e complete circuit assembly is
supplied.
T e Wolf Safety Lamp Co as a policy of continuous
product development. C anges in design detail may be
made wit out prior notice
WOLF SAFETY LAMP COMPANY
Saxon Road Works, S effield S8 0YA, England
Tel: +44 114 255 1051 Fax: +44 114 255 7988
E-mail: info@wolfsafety.com Website: www.wolfsafety.com
HL-15 Issue 9 DF528
Wolf Hazard Lamp HL-95
WOLF SAFETY LAMP COMPANY
Saxon Road Work , Sheffield S8 0YA
44
114
255
1051
44
114
255
7988
!"#
info@wolf afety.com
$%&
www.wolf afety.com
HL-15DF528
'()*+,"-$-./&012
HL-95 !2014"34"EU#$%
ATEX!&'()*+',-./0!123#4567829!:
23#429,;$#3:2&3<2(=2'
->8?!@!ABC;@'LED2:!DEF
2G2=B2:CH!<IJKLCM(!N)*DO.<>.!
2P32Q2R N-$S$129:*,TU(0V1V2>&,23!9
-;J22P,7=WJXYV-;U!&VE! (T4<
"(3',4!56,
HL-3155X
78*!+
,.9:-/;+'%
(
<
EX
7<
:=>'3?@7AB/#9(C%3B'D
*2,8*EF*&G
II 1 G Ex ia op i IIC T4 Ga
C
o
10-=
a
TZJ40
C
o
!0
SGS FIMKO OY.P.O. Box 30
(Särkiniementie 3) 00211 HELSINKI,
*3*,
[$HOAC
0598
[!&'K!2U)*+',-./
BAS99ATEX1044X
9EHI5J=,K
X
L
2($NR\F*C2$2OF2*'/];^_$!,2O;.S-*<!
, )8 ;` @ HV TU= S\ HV 0 ];^ , R= HO
<2O;.S2*'/AS;Z3R2U
[29:29,;$
EN IEC 60079-0: 2018, EN60079-11: 2012, EN60079-28: 2015
2'2[
P21
$3a9,EN60529:19921
*b29:*, 3#!;SN2R*#$2B(Nc9'AEX <
HL-95c!:2014"30"EU EMC[229,;$3a9,
EN 61000-6-2:2005
EN 61000-6-3:2007+A1:2011<
H=SdOVeL;
ةدودا ب فوو ر
4!5=
Wolf Hazard Lamp HL-95
$Z?);NU=Z3RE*EN60079/IEC60079V3'$
Df23!C>V,TU(-$2B!;.O-g.&2G,!/;(
< (
h@.a9,J(?',@0'0 #3$DC-R?
U<
7,TR0 Wolf Hazard Lamp<-;:Uci*,
($LV>;j!7=K<k*@Z3R#
>V_U*WJ1. .,TU=29:*32:'-;'2Nc9'
NDCV-;'#,2:-5
C
o
"(3#M
<3UNN&>g D,lQ=2j!AC
N&>g ,2:0SDHVNS\DD!AC
<TOJj!N,;:(O!D
<-F';`m(&HVNS\lQ=Bg0S;RV
[2#GK;,U
l!fDEFb]9?b_DEF
2JZ3R3G7=-LED>8,nDonG!
;R2i?Z3RR=.*>8,aB93DEFCL@1.*
<2:
p:*!;#/?NX;9!DEFA4?_2R;gC
100MHzZ?115MHz<
($3%
I&
M3N-(
2$ -
HL-13A%LEDNH35;&
l7!HVLEDDC#;:201803:*R-;,
lQ=
HL-25
lQ
HL-05
2:
HL-3155X
D:R2J,-1gADO!2$ -<
EO
Wolf Safety Lamp
"&3==
PIQ2R!%7S:6
.#6-(3?0*
Other Wolf Work Light manuals
Popular Work Light manuals by other brands
PowerSmith
PowerSmith PWLD080T Operator's manual
MaxLite
MaxLite 73683 installation instructions
Heitronic
Heitronic Trend 27867 Installation and operating instructions
Monzana
Monzana Gore MZCL10 manual
EINHELL
EINHELL TE-CL 18/2000 LiAC Original operating instructions
Bayco
Bayco NIGHTSTICK Dual-Light Xtreme Lumens... instruction manual