Whirlpool MAX 18/AW User manual

SERVICE Whirlpool Europe

Customer Services

Model MAX 18/AW

Version 8538 018 99261 Page

Introduction safety 2

Technical data 3

Spare part list 4

Exploded view 5

Wiring diagram 6 - 7

Service Manual

Microwave oven

MAX 18/AW

This documentation is only intended for qualiﬁed technicians who are aware of the respec-

tive safety regulations.

Date: 01.09.2003 (Mod. 01) Subject to modiﬁcation

Document-No.: 4812 714 14499

SERVICE

10.01.2003 / Page 2 MAX 18/AW Whirlpool Europe

Doc. No: 4812 714 14499 8538 018 99261 Customer Service

Introduction safety

INTRODUCTION

Before leaving the factory each oven is carefully checked.

It must, however, be installed and used correctly.

Despite all the steps taken to make the oven safe, the safety is dependent on the correct installation and the fact

the user understands how to use and maintain the oven.

The information in this section should be used as a reminder that the oven is safe and that anyone who uses it must

ﬁrst read the instructions for use in order to be able to use the oven correctly and obtain best results.

SAFETY

To avoid injury to yourself and damage to the appliance always work to the following rules when servicing an oven.

Always disconnect the plug from the mains before starting work.

If there is no plug switch off the electric supply at the control box.

When you have ﬁnished servicing an oven before you reconnect it to the mains, make sure that:

- all the internal connections are correct

- the wires are insulated and not touching the door or the cabinet or anything sharp

- all the earth connections are electrically and mechanically sound

- do not modify or anyway interfere with the safety devices built-in to the oven

- make sure that each replacement part you use conforms to the manufacturer´s speciﬁcations

Do not start a repair if you have any doubt as to your ability to complete it.

CAUTION - MICROWAVE RADIATION

PERSONNEL SHOULD NOT BE EXPOSED TO THE MICROWAVE ENERGY WHICH MAY RADIATE FROM THE MAGNETRON,

WAVEGUIDE OR ANTENNA IF THEY ARE IMPROPERLY USED OR CONNECTED. ALL INPUT

AND OUTPUT MICROWAVE CONNECTIONS, WAVEGUIDES, FLANGES AND GASKETS MUST BE SECURE.

NEVER OPERATE THE DEVICE WITHOUT A MICROWAVE ENERGY ABSORBING LOAD ATTACHED.

NEVER LOOK INTO AN OPEN WAVEGUIDE OR ANTENNA WHILE THE DEVICE IS ENERGIZED.

NEVER OPERATE AN OVEN WITH CABINET OFF WITHOUT MEASURING THE MICROWAVE LEAKAGE

AROUND MAGNETRON AND VISIBLE MICROWAVE CONNECTIONS (WELDING JOINTS).

Do not operate the oven if the following conditions exist:

- the door does not close ﬁrmly against the door support because of the door being warped or the hinges damaged.

- The door trims or seals are damaged.

- If there is any visible damage to the oven.

- if the door does not close properly.

Avoid operating the oven if known components in the interlock system, oven door or microwave

generating assembly are known defective. They must be replaced.

WARNING - HIGH VOLTAGE

IT IS POSSIBLE TO COME IN CONTACT WITH LETHAL HIGH VOLTAGE WHEN WORKING WITH

HV TRANSFORMER, HV CAPACITOR AND MAGNETRON. THEREFORE NEVER TRY TO MEASURE

THE HIGH VOLTAGE. ALWAYS TAKE UTMOST CARE WHEN PERFORMING ELECTRIC

MEASUREMENTS INSIDE THE OVEN.

SERVICE Whirlpool Europe MAX 18/AW 01.09.2003 (Mod. 01) / Page 3

Customer Service 8538 018 99261 Doc. No: 4812 714 14499

Technical data

Product dimensions

Height 356 mm

Width 392 mm

Depth 350 mm

Cavity dimensions

Height 149 mm

Width 290 mm

Depth 290 mm

Cavity volume 13 l

Turntable diameter 280 mm

Weight

Net 12 kg

Gross 13 kg

Electrical

Voltage 230 V

Frequency 50 Hz

Fuse 10 A

Current consumption 6 A

Power

Power consumption 1300 W

Output power MW 750 W

Grill 600 W

Maximum input power 1750 W

Timer

electronic 30 min.

5 power levels

Error codes

Certain fault conditions are indicated by an error code.

The following codes are implemented:

ERR 0 Convection temperature sensor fault.

Not connected or short circuit.

ERR 1 Short circuit in the MW relay.

ERR 6 Weight sensor calibration has not been performed.

ERR 7 Humidity sensor is defect or has not been connected.

ERR 8 Impossible to write to E2PROM.

ERR 9 Options have not been set.

ERR A No wheel detected on weight sensor.

ERR B No pulses from the weight sensor or <4267 Hz.

ERR C Fuzzy temperature sensor fault. Not 19-41 ˚C.

SERVICE

10.01.2003 / Page 4 MAX 18/AW Whirlpool Europe

Doc. No: 4812 714 14499 8538 018 99261 Customer Service

Spare part list

Model MAX 18/AW

Service No. 853801899261

Version 853801899261

Pos. No. 12NC Code Description

001 0 4812 440 10447 Cabinet outer WH

001 5 4812 462 79788 Plate, bottom

001 6 4812 462 79849 Frame distance piece right

001 7 4812 462 79851 Frame distance piece left

002 0 4812 325 58002 Frame top WH

002 1 4812 325 58003 Frame top plate AL

002 2 4812 325 58004 Frame heat shield top

005 0 4812 440 89022 Panel bottom

047 0 4812 492 48178 Hinge pin, top

100 0 4812 442 69289 Door complete Alu/White

117 0 4819 498 78366 Handle for crisp plate

130 0 4812 492 58039 Lever

130 1 4812 460 38114 Cam plate

130 2 4812 492 58041 Clutch

130 3 4812 492 58038 Pin

130 5 4812 492 68172 Spring, tension

245 0 4812 458 19141 Grid

246 0 4812 418 79782 Crisp plate AMW 001

255 0 4812 466 78407 Glass plate turntable

264 0 4812 539 28001 Crosspiece

264 1 4812 539 28002 Spider

404 0 4819 131 58019 Magnetron

406 0 4812 361 58156 Motor Turntable

406 1 4812 492 58037 Tube MW

412 0 4812 145 38032 Transformer HT

420 0 4812 121 58137 Capacitor 1.01µF

426 0 4819 218 38038 Diode HV

440 0 4812 361 18317 Motor blower

452 0 4812 259 28845 Heating element 115V

452 1 4812 259 28846 Heat shield

490 0 4812 321 18195 Cable, mains 3X1, 0 EU

500 0 4812 214 78952 Control board assembly

505 0 4812 256 98038 Bracket PCB holder

505 1 4812 256 98037 Holder multi

506 0 4812 270 18026 Switch holder

554 0 4812 282 08613 Thermostat Magnetron

554 1 4812 256 98036 Bracket Thermostat

561 0 4812 282 48271 Thermostat waveguide

564 0 4812 282 08625 Thermostat overheat

617 0 4812 280 68349 Relay

633 0 4812 271 38427 Microswitch door

651 0 4819 134 28051 Lamp

774 0 4812 462 28268 Mica plate

774 2 4812 442 69274 Heat shield waveguide

900 2 4812 491 48016 Pin for micaplate

910 0 4812 502 38354 Screw safety

993 0 4812 462 18208 Holder baby bottle

SERVICE Whirlpool Europe MAX 18/AW 10.01.2003 / Page 5

Customer Service 8538 018 99261 Doc. No: 4812 714 14499

Exploded view

SERVICE

10.01.2003 / Page 6 MAX 18/AW Whirlpool Europe

Doc. No: 4812 714 14499 8538 018 99261 Customer Service

Wiring diagram

OVEN IN OFF POSITION

WITH DOOR CLOSED

1010 Magnetron

1020 Thermostat Magnetron

1040 Secondary doorswitch

1050 Monitor doorswitch

1060 Primary doorswitch

1070 Motor fan

1080 Motor turntable

1120 Cavity lamp

1130 Thermostat cavity

1135 Thermostat waveguide

1800 Heating element grill

2000 HT capacitor

4030 Power board

4040 Control system

4120 Fuse T 10 A

4121 Fuse T 250 mA

5000 HT transformer

6000 HT diode

BL Blue

BLK Black

BR Brown

GY Grey

RD Red

WT White

YW Yellow

Y/G Yellow - green

SERVICE Whirlpool Europe MAX 18/AW 10.01.2003 / Page 7

Customer Service 8538 018 99261 Doc. No: 4812 714 14499

Wiring diagram

Table of contents

Other Whirlpool Microwave Oven manuals

Whirlpool

Whirlpool WML75011HN User manual

Whirlpool

Whirlpool YKHMS145J User manual

Whirlpool

Whirlpool MWN 440 User manual

Whirlpool

Whirlpool WMH75021H User manual

Whirlpool

Whirlpool JT 358 User manual

Whirlpool

Whirlpool WMH1162XVD - 1.6 cu. ft. Microwave-Range Hood... User manual

Whirlpool

Whirlpool MW8650XS User manual

Whirlpool

Whirlpool W10918338A User manual

Whirlpool

Whirlpool WMT50011KS User manual

Whirlpool

Whirlpool AMW 599 Operating and maintenance manual

Whirlpool

Whirlpool AMW 519 IX Operating and maintenance manual

Whirlpool

Whirlpool MT1066XB User manual

Whirlpool

Whirlpool WMC50522HV User manual

Whirlpool

Whirlpool MW-25BC User manual

Whirlpool

Whirlpool W10355490A User manual

Whirlpool

Whirlpool MW8200XP User manual

Whirlpool

Whirlpool W11108505B User manual

Whirlpool

Whirlpool MT 244/1/BLACK User manual

Whirlpool

Whirlpool MW8100XL User manual

Whirlpool

Whirlpool W11I MW161 UK User manual

Whirlpool

Whirlpool MT1120SL User manual

Whirlpool

Whirlpool YMH1170XSB1 User manual

Whirlpool

Whirlpool AMW 831 User manual

Whirlpool

Whirlpool AMW 503 Operating and maintenance manual

Popular Microwave Oven manuals by other brands

Daewoo

Daewoo KOG-574R0S Service manual

LG MH7040SS instruction manual

Sharp

Sharp R-895(AL)M Service manual

Dometic

Dometic DOTRM13W installation instructions

Sanyo

Sanyo EM-X680 instruction manual

Sharp

Sharp R-393M quick start guide

KitchenAid

KitchenAid KMCX4510 Use and care

Smeg

Smeg S45MCX1 Instructions for use

Russell Hobbs

Russell Hobbs RHM2044 user guide

Sunbeam

Sunbeam SMW759 owner's manual

Gallet

Gallet FMOE230S instruction manual

Bosch

Bosch CEG732X.1B User manual and installation instructions

Dometic

Dometic Roadmate 230 operating manual

Samsung

Samsung SJ0396W Owner's instructions

Sanyo

Sanyo EM-P494WS Supplement of service manual

Sharp

Sharp R-240 Operation manual

Electrolux

Electrolux EMS2840 user manual

Daewoo

Daewoo KOC-984T2S13 Service manual