Wessol SprayMate Shower MAX User manual
SHOWER MAX
4-Gallon 7.2V Battery Powered
Sprayer with Rolling Trolley
Model #: SMSAAF
OPERATION GUIDE
1
ATTENTION
Please read the following information carefully. Failure to follow instructions or improper
use could lead to explosive failure causing serious injuries.
After using sprayer with chemicals, it is important to spray with fresh water for 3-5 minutes to ensure residual
chemicals in the gun, wand, tank, pump, and hose are cleaned out. This will extend the life of your sprayer. Never leave
chemicals or solutions sitting in your sprayer after using.
Do not store your sprayer in extremely high temperatures. Heat can lead to the build-up of pressure within the sprayer,
resulting in a possible explosion. If there is pressure in the pump, do not try to remove it with tools. Do not try to make
modications to the sprayer. Always use SprayMate™ branded replacement parts from the manufacturer.
Never spray ammable, caustic, acidic, chlorine, or other corrosive solutions or heat, pressure, or gas producing
chemicals. Always read and follow chemical manufacturer’s instructions before use with this sprayer as some
chemicals may be hazardous when used with this sprayer.
WARNING
This product contains chemicals, including lead, known to the
state of California to cause birth defects and other reproductive
harm.
This product is designed to apply chemicals that may be
harmful and could cause serious personal injury if inhaled or
brought into contact with the user
NOTES:
1. The sprayer may have residual water in it due to quality
testing performed on it.
2. Some parts may be found inside the tank when rst
assembling the sprayer. Please make sure to remove the
parts before attempting to assemble or use the sprayer for
the rst time.
Copyright © WESSOL, LLC
2
Copyright © WESSOL, LLC 3
After long periods of time without use, the battery may have a low voltage and
will require extended charging.
Always wear protective clothing, respirator, gloves, eye protection, etc. when
using chemicals.
Never spray chemicals against the wind, towards humans, animals,
or food.
Do not operate sprayer in temperatures lower than 32ºF.
Never operate with strong acids, strong bases, or ammable liquids.
Never ll the sprayer with hot liquids (max temp. = 176ºF) or gasoline.
Do not dispose of lithium-ion battery with household waste; recycle where
facilities exist.
The sprayer is susceptible to water damage if left in wet conditions.
Always store it in a cool, dry place.
Always use SprayMate™ original replacement parts.
Do not leave the sprayer in reach of children or persons not qualied to handle it
in a proper fashion.
LET’S
GET
SPRAYING!
REGISTER YOUR SPRAYER!
To take advantage of the 1-year Limited Warranty from WESSOL,
LLC. Register your sprayer at the website below:
www.buyspraymate.com/register
Please read and follow this manual carefully to ensure that you get the most out
of your new sprayer. If you need assistance with the assembly or operation of
your sprayer, please don’t hesitate to contact WESSOL via the support
methods below:
www.buyspraymate.com
+1 803.339.2500
Copyright © WESSOL, LLC
4
TABLE OF CONTENTS
ABOUT
1.1 specications...............................................................................................page 6
1.2 what’s in the box..........................................................................................page 7
page 6-7
SET UP
2.1 rolling sprayer assembly...............................................................................page 8
2.2 backpack sprayer assembly..........................................................................page 9
2.3 spraying......................................................................................................page 10
2.4 aftercare.....................................................................................................page 11
page 8-11
TROUBLESHOOT page 12-15
3.1 common solutions......................................................................................page 12
3.2 replacement parts.......................................................................................page 13
3.3 warranty.....................................................................................................page 14
Copyright © WESSOL, LLC 5
WHAT IS YOUR SPRAYER
CAPABLE OF?
A SprayMate™ is a highly ecient sprayer that is
suitable for spraying many kinds of
water-soluble chemicals.
This includes fertilizers, pesticides, cleaning products, etc. Powered by a 7.2V
lithium-ion battery, this sprayer results in 2-3x more eciency than a manual
sprayer. This sprayer can be operated continuously for up to 2 hours and
spray more than 7 gallons per battery charge at a distance of 15 feet.
SprayMate™ Shower MAX Specifications
Model Number SMSAAF Pump Type Gear
Battery Type Lithium-ion Spray Time up to 2 hours
Battery Voltage 7.2V Pressure 45 psi
Battery Capacity 2.6Ah Spray Distance 15 feet
Battery Charging Time 2 hours Tank Capacity 4 gallons
Battery Cycle Life 500 cycles Flow Rate 0.17 gal/min
Battery Charger 7.2V/1Ah Pump Life 500 hours
Copyright © WESSOL, LLC
6
WHAT’S IN
THE BOX?
1. 7.2V Spray Gun & Short Nozzle 2. Trolley Holster 3. Backpack Holster
4. 4-Gallon Tank 5. Trolley Handle 6. Battery Charger
7. Coiled Hose 8. Screw, Nuts, and Bolts 9. Tank Cap and Hose
10. Backpack Straps 11. Intake Filter 12. 18-Inch Extension Wand
13. Trolley Handle Bar 14. Trolley Base
1
Copyright © WESSOL, LLC 7
Before you begin, open the tank lid and remove
any nuts and bolts (8) or screws that may be placed
inside the intake lter (11). Set aside.
Insert the trolley handle bar (13) into the trolley base
(14), making sure the end with two holes is going in
rst. Determine the height you would like for the
handle baf and secure the handle bar to the trolley
base with a nut and bolt.
Slide the trolley holster down the handle bar until
about half way. Tighten the screw into the holster
until it is snug against the handle bar. Make sure
the screw is tight to prevent the holster from
slipping. The screw is not designed to go through
the handle bar.
Attach the trolley handle (5) on top of the handle
bar by threading the remaining nut and bolt (8)
through the hole. Tighten the handle to the trolley
handle bar by rotating the lower knob attachment.
Place the sprayer tank (4) on top of the trolley base
(14). Secure it to the base by screwing the knob on
the back of the trolley into the sprayer tank.Tighten.
STEP 1a.
ASSEMBLING AS A
ROLLING SPRAYER
A)
B)
C)
D)
E)
Copyright © WESSOL, LLC
8
Before you begin, open the tank lid and remove
any nuts and bolts or screws (8) that may be placed
inside the intake lter. Keep in a safe place in case
you wish to convert to a rolling sprayer.
Taking the backpack strap (10), attach the metal
clip to the bottom loop on the sprayer tank. Repeat
for the other side.
Slide the top of the strap through the top look of the
sprayer tank. Thread the fabric through the buckle.
Repeat for the other side. Gently tug on the straps
to ensure they’re secure.
Place the backpack holster (3) over the tank outlet
hole and screw the cap back on.
STEP 1b.
ASSEMBLING AS A
BACKPACK SPRAYER
A)
B)
C)
D)
Copyright © WESSOL, LLC 9
Fully charge the battery prior to first operation.
In a separate container, prepare the solution you
want to spray according to the manufacturer’s
instructions. Open the tank cap and carefully pour
the solution through the intake lter. Securely
tighten the tank cap.
Taking the coiled hose (7), attach the end with the
ON/OFF switch to the spray gun (1). Clip the other
end on to the tank cap (9). It’s important to ensure
the hose is fastened tightly to the spray gun and
tank cap as a loose connection will prevent the the
pump from drawing water through the hose.
Determine which nozzle or attachment is
appropriate for your project. Pull back on the brass
collar of the quick-connect tting on the spray gun.
Insert the nozzle or attachment and then push the
tting back into its original position.
a) Short nozzle = adjustable conical nozzle ranging
from jet stream to mist
b) 18-Inch Extension wand = adjustable, ranging
from jet stream to mist
Making sure the ON/OFF switch is in the ON
position, disengage the handle lock (if necessary)
and squeeze the trigger on the spray gun to begin
spraying. When rst beginning to spray, it is normal
for the pump to take a few seconds to build up
pressure and draw liquid up from the tank and
through the hose.
STEP 2.
PREPARING TO SPRAY
A)
B)
C)
D)
Copyright © WESSOL, LLC
10
This manual suits for next models
1
Table of contents
Other Wessol Paint Sprayer manuals
Popular Paint Sprayer manuals by other brands
Bonide
Bonide 051 Operation and service instructions
zogics
zogics Z-DAS instruction manual
KISANKRAFT
KISANKRAFT KK-KBS-165 Operation manual
Matrix
Matrix SG 650 Translation of the original instructions
Anest Iwata
Anest Iwata SGA-3 Installation, use & maintenance instruction manual
paasche
paasche VV Instructions and parts list
