WaterLogic WL250 Operating instructions

WL250Manual Page68‐Revision:12‐12‐2018

HOTWATERTROUBLESHOOTINGINDEX



Hot Water Problems

1. HotWaterisnotHot85°C+/‐15°C(185°F+/‐5°F)



AlsoincludesrelatedinstructionsforResettingtheHotTankOverloadorHigh

LimitSafety



HotWaterisnotHot85+/‐15°C(185°+/‐5°F)



NOTE:TheWL250WaterTreatmentSystemdoesNOThaveSleeporPowerSavingModeand

thehotwatershouldbeaof85+/‐15°C(185°+/‐5°F)undernormaloperatingconditions.



TheHottemperaturesetpointis85°C+/‐15°C(185°F+/‐5°F)andiscontrolledbyathermostat

onthesideofthetank.



Thereisaresettableoverloadorhighlimitsafetyabovethethermostatonthesideofthetank

thatwilltriptopreventdamagetotheunitifthetankisdryheated(turnedonwithoutwaterin

it).



TheWL250WaterTreatmentdoesNOThaveExtraHotcapabilityandthemaximumhot

temperatureis87°C(189°F).



Ittypicallytakes10minutesforthe500Wtoheatthe1.6Literofroomtemperature(ambient)

watertothe85°C(185°F)setpoint.



PossibleReason Solution

Nopowertoheaterelements

CheckthattheRedHeaterandCompressor

switchison.



TurnRedHeaterandCompressorSwitchon.

I=ON

HotTankOverloadTripped



Overloadisasafetyfeatureto

ensurethetankdoesnot

overheat.

Overloadwill“click”whenpushed.Theoverloadis

automaticallyresetwhenpressed.



SeeResettingtheHotTankOverloadorHighLimitSafety

Instructionsthatareincludedfurtherbelowinthis

TroubleshootingSection

Thermostatoroverload

“open”onHotTank

TurnPoweroff.CheckOHM’sresistanceacrossterminalson

eachThermostatandOverloadseparately.



WL250Manual Page69‐Revision:12‐12‐2018

Goodcomponentswillindicateaclosedcircuitorzero

OHM’sonthemeter.



Replacecomponentsasnecessary.

HeatingCoilNotWorking

TurnPoweroff;Drainhottank;Usemulti‐metertocheck

heaterelementforapproximately26OHM’sresistance.



HotTankmustbeemptyifyouarecheckingforcontinuity.



ReplaceHotTankasnecessary.

Looseorimproperly

connectedwire(s)tothe

HeatingElement/HotTank.

Visuallyinspectwireleadsgongtothehottank;confirm

properconnectionstotheheatingelements.



Hottanklifeis3‐5years,dependingonusage.



*Typically,dealersswapouttheHotTankatsite,takeback

totheshoptorepair.



WL250Manual Page70‐Revision:12‐12‐2018

RESETTINGTHEHOTTANKOVERLOADORHIGHLIMITSAFETY



 

1.



RedHeaterandCompressorSwitchmustbeintheOFFposition



O=OFF



2. UnplugthePowerCordfromrearofWL250WaterTreatmentSystem.

3.

TowerModel:RemovetheLowerFrontPanelbyremovingthePhillipsHeadScrews

underneaththeLowerFrontPanel.



CounterTopModel:RemovetheSidePanelbyremovingPhillipsHeadScrewsfromSide

Panel.

4.



LocatetheprotectivemetalboxontherearoftheHotTank.



Asyoulookthroughthecondensercoilsontherearofthe

unit,youwillseetheHotTanklocatedontheright‐handside.



WL250Manual Page71‐Revision:12‐12‐2018

5.

ReachupbehindtheHotTankandtakeholdoftheProtective

MetalBoxcoveringtheThermostatandOverloadontheHot

Tank.



TherearenutsthatsecurethemetalboxtotheHotTank.

However,thenutsarelooseenoughtoallowyoutoremove

themetalbox.



Ifthenutsonthemetalboxaretootight,loosenthenuts

securingtheHotTanktotheupperbaseoftheunitandlower

thehottanksoyoucanremovethemetalbox.



Fordemonstrativepurposes,photosbelowhaveloweredthe

HotTankfromtheunit. 

6.

Presstheresetbutton



7.



Reattachthemetalboxbydepressingthetopflapofthe

MetalBoxsoitsnapsbackintoitsoriginalpositiononthe

HotTank. 

WL250Manual Page72‐Revision:12‐12‐2018

8. ReplacePanelonunitusingPhillipsheadscrews.

9. PluginthePowerCord.

10

MakesuretheHotandColdTanksarefilledwithwaterBEFOREturningontheRedHeaterand

CompressorSwitch.



Verifythecoolerisfullyoperationalbeforeinstallingitatthecustomers’site.



Other manuals for WL250

Table of contents

Other WaterLogic Water Dispenser manuals

WaterLogic

WaterLogic WL900 User manual

WaterLogic

WaterLogic WL2FW FIREWALL Series User manual

WaterLogic

WaterLogic WL250 Manual

WaterLogic

WaterLogic WL250 Operating instructions

WaterLogic

WaterLogic WL500 - Sparkling Operating instructions

WaterLogic

WaterLogic WL200 Operating instructions

WaterLogic

WaterLogic WL Cube Manual

WaterLogic

WaterLogic WL4 Firewall User manual

WaterLogic

WaterLogic WL2000IT User manual

WaterLogic

WaterLogic WL500 - Sparkling User manual

WaterLogic

WaterLogic WL3 Firewall User manual

WaterLogic

WaterLogic NIAGARA IB User manual

WaterLogic

WaterLogic WL380 Operating instructions

WaterLogic

WaterLogic WL400 Series Reference guide

WaterLogic

WaterLogic WL900 Operating instructions

WaterLogic

WaterLogic WL290 User manual

WaterLogic

WaterLogic WL500 - Sparkling Reference guide

WaterLogic

WaterLogic WL290 Operating instructions

WaterLogic

WaterLogic WL350 Reference guide

WaterLogic

WaterLogic WL250 Operating instructions

WaterLogic

WaterLogic ARAMARK User manual

WaterLogic

WaterLogic WL Cube Firewall User manual

WaterLogic

WaterLogic WL400 Series Manual

WaterLogic

WaterLogic WL400 Series User manual

Popular Water Dispenser manuals by other brands

Monarch Water

Monarch Water ULTIMATE MINI AQUA HE install guide

Haier

Haier HLM-109B instruction manual

abc

abc Fleck 5600SXT manual

GE GXOF18G Owner's manual and installation instructions

Kenmore

Kenmore 625.385560 UltraFilter 650 owner's manual

Innova

Innova CEV+ Installation, use and maintenance

Aries

Aries Hydra DI Operation & maintenance manual

GE GNCF02H owner's manual

ProFlo

ProFlo PFB Series Installation & operation manual

Hydrotech

Hydrotech 89DF HIM owner's manual

A.O. Smith

A.O. Smith FREZYA 300S user manual

Frakco

Frakco Travelsoft RV 2400HD Operation instructions

GE GXSF30V Owner's manual and installation instructions

Avanti

Avanti WD31EC instruction manual

Avanti

Avanti WD360 instruction manual

BRIO

BRIO CLCTTL520 Setup manual

3M HCD-1 operating instructions

Elkay

Elkay EFHFA8_2CJO Installation, care & use manual