VIAIR 450P-RVS User manual



Your tal Air Source

450P-RVS AUTOMATIC PORTABLE COMPRESSOR

EXTREME SERIES

 













IMPORTANT SAFETY INSTRUCTIONS:

CAUTION: To reduce risk of electrical shock or electrocution:

- Donotdisassemble.Donotattemptrepairsormodications.

Refertoqualiedserviceagenciesforallserviceandrepairs.

- Do not use this product in an area where it can fall or be pulled into water or other liquids.

- Do not reach for this product if it has fallen into liquid.

- Usethiscompressorwith12-voltDCsystemsonly.

- Thisproductshouldneverbeleftunattendedduringuse.

WARNING:Topreventinjury:

- Neverallowchildrentooperatethiscompressor.

Closesupervisionisnecessarywhenthiscompressorisbeingusednearchildren.

- ThiscompressorwillbecomeveryHOTduringandimmediatelyafteruse.

Donottouchanypartofthiscompressorwithbarehands,otherthantheON/OFFswitch

duringandimmediatelyafteruse.

- Donotusethisproductnearamesorexplosivematerialsorwhereaerosolproducts

arebeingused.

- Donotoperatethisproductwhereoxygenisbeingadministered.

- Donotpumpanythingotherthanatmosphericair.

- Neverusethisproductwhilesleepyordrowsy.

- Donotuseanytoolsorattachmentswithoutrstdeterminingmaximumairpressureforthat

tool or attachment.

- Neverpointanyairnozzleorairsprayertowardanotherpersonoranypartofthebody.

- ThisaircompressorisequippedwithanAutomaticResetThermalProtector,andcan

automaticallyrestartafterthethermalprotectorresets.Alwayscutopowersourcewhen

thermalprotectorbecomesactivated.

- Wearsafetyglassesorgoggleswhenoperatingthisproduct.

- Useonlyinwellventilatedareas.

- Afterusage,alwaysreleaseexcesspressurefromthecoilhosebyturningOn/OswitchtotheO

position,disconnecthosefromcompressor,withthetireinationgunstillconnectedtotheother

endofthecoilhose,pulltriggeronthetireinationguntoreleaseexcesspressure.

USER MANUAL

450P-RVS AUTOMATIC PORTABLE COMPRESSOR

OPERATING INSTRUCTIONS:

Pleasereadandfollowtheoperatinginstructionscarefullytoassurethatyouwillenjoythe

convenienceandbestuseoutofyouraircompressor.

1. AlwaysoperatethecompressorATORBELOWTHEMAXIMUMPRESSURERATINGofthe

compressor.RefertoSpecicationssectionofthismanual.

2. AlwaysOBSERVETHEMAXIMUMDUTYCYCLEoftheaircompressor.RefertoSpecications

sectionofthismanualfordetails.Operationsexceedingmaximumpressureratingsandorduty

cyclewillresultindamagetoaircompressor.

3. YouraircompressorisequippedwithanAUTOMATICTHERMALOVERLOADPROTECTOR.

Thisfeatureisdesignedtoprotecttheaircompressorfromover-heatingandcausingpermanent

damagetoyouraircompressor.Thethermaloverloadprotectorwillautomaticallycutopower

toaircompressorshouldinternaloperatingtemperatureoftheaircompressorriseabovesafe

levelsduringexcessiveuse.

4. Shouldyourcompressorshutosuddenlyafterextendeduse,donotattempttorestartair

compressor.TurnON/OFFswitchofaircompressortotheOFFposition.Theautomaticthermal

overloadprotectorwillautomaticallyresetwheninternaltemperatureoftheaircompressordrops

belowsafelevel.Afterallowingaircompressortocooloforabout30minutes,youcansafely

resumeuseoftheaircompressorbyturningontheaircompressor.

5. Foryourconvenience,andtoprotecttheaircompressorfromover-pressureoperationthatcan

causepermanentdamagetotheunit-thiscompressorisequippedwithbuilt-inpressureswitch

withafactorysetcut-onpressureof130PSI(±5%)andafactorysetcut-opressureof

155PSI(±5%).Duringinationoftirepressuresbetween130PSIto155PSI,ifyoustopination,

thecompressormaynotrestart.Thisiscompletelynormal,sinceinlinepressureisgreaterthan

cut-onpressureofthepressureswitchandlessthancut-opressureofthepressureswitch.

Torestartcompressor,deatetirepressuretobelow130PSI,reconnecttirechucktotirevalve

stemandresumetireination.

6. Pleasenotethatyoumayexperienceaslightdelayofthecompressor’smotorstartingwhenthe

ON/OFFswitchisturnedonwhilecompressorispressurized(whenthereispressureintheline

thatthecompressorisconnectedto).Thisisanormaldelayedreaction,notaCompressor

ON/OFFswitchmalfunction.

7. Itisstronglyrecommendedthatyoukeepthevehicle’senginerunningwhileusingtheair

compressortopreventdischargeofyourvehicle’sbattery.

8. ONLYOPERATETHEAIRCOMPRESSORINWELLVENTILATEDAREAS.

Compressorperformanceisenhancedwhenoperatingcompressorwithvehicleenginerunning.

IMPORTANT:Enginemustberunningwhileusingthiscompressor.

Beforeattachingaircompressorpowerclampstoyourvehicle’sbatteryterminals,checktomake

surethattheON/OFFswitchofyourcompressorisintheOFFposition.AttachthePositive(+)

batteryclamp(Red)tothePositiveterminalofthebatteryandtheNegative(-)batteryclamp(Black)

totheNegativeterminalofthebattery.Alwayskeepyourvehicle’senginerunningwhileoperating

compressortoavoiddrainingyourvehicle’sbattery.

CAUTION:YourPortableAirCompressorisMoistureandDustResistant,butNOTWATERORDUST

PROOF.Neverplacecompressorinsoftsandwhilerunningthecompressor.Vibrationfromthe

compressorwillcausethecompressortosettleintosoftsand,resultingincompressordrawingin

foreignparticles.Neverexposecompressortowaterwhilerunningthecompressor.

USER MANUAL

OPERATING INSTRUCTIONS (cont’d):

This air compressor comes with 1/4” quick connect stud. An extension coil hose and a tire

ination gun are also included with your compressor. Each end of the extension coil hose is

equipped with a 1/4” quick connect coupler. The tire ination gun comes with a 1/4” quick

connect stud, pressure gauge, rubber hose, bleeder valve and tire chuck. Attach one end of

the extension coil hose to the stud on your compressor and the other end to the stud on the

tire gun kit. The tire gun kit can be used for both airing up and airing down. Please familiarize

yourself with the following functions of this versatile air tool:

TIRE INFLATION:

1. Attachoneendoftheextensioncoilhosetothecompressorandtheotherendtothetiregunkit,

45-degreeangledchuckor90-degreetwist-onchuck–dependingonneed.

2. Turncompressorswitchonandholddownthetriggeronthetiregunkittobeginination.

3. Whendesiredpressureisreached,releasethetrigger.Ifnishedwithuse,turnpowerswitchon

compressoroposition.

NOTE:Toreleaseexcesspressure,turnocompressoranddisconnecthosefromcompressor.

Withthetireinationgunstillconnectedtotheotherendofthecoilhose,pulltriggeronthetire

inationguntoreleaseexcesspressure.

CAUTION:Toavoidoverination,neverexceedrecommendedpressureonarticlestobeinated.

Burstingcancauseseriousinjury.

NOTE:Youraircompressorisequippedwithapressureswitch(cutonat130PSI,cutoat

155PSI).Thisfeatureisdesignedtoprotecttheaircompressorfromover-pressurecausing

permanentdamagetoyouraircompressor.Thepressureswitchautomaticallyturnsothemotor

whentheinternalpressureoftheaircompressorreachesthefactoryset”cut-o”pressureof

155PSIandrestartswhentheinternalpressuredropsbelow130PSI.

TIRE DEFLATION:

1. Withtheinationoptionofyourchoicestillconnectedtothetireinationgun,pressthebleeder

valvebuttononthetiregunkittodecreasetirepressure,pressthebleedervalvebuttononthetire

gunkittodecreasetirepressure.

2. Pressthebleedervalvebuttononthetiregunkittodecreasetirepressure.

3. Whendesiredpressureisreached,releasethebleedervalvebuttontohaltdeation.

IMPORTANT:Makesurecompressorsitsuprightwhileoperatingcompressor.Donotoperate

compressorinanyotherposition.Avoidtuggingatcompressortomoveit.Instead,move

compressortothesamesideofvehicleastiresthatarebeingairedup.

AlwaysmakesurethePortableCompressor’spowercordisuncoiledandfullyextended

whenusingyouraircompressortoavoidoverheatingthepowercord.

INLINE PRESSURE GAUGE:

1. Thepressuregaugeontheinationgunprovidesconvenienttirepressuremonitoringwhenairing

upordown(notairowofthecompressor).Thiseliminatesswitchingbackandforthbetweena

tirechuckandatirepressuregauge.

2. Pleasenotethatduringinationanddeation,duetoairvelocity,pressuregaugecannotprovide

accuratepressurereadings.Releaseleveronthetireinationgunduringinationtocheck

tire air pressure.

NOTE:Toreleaseexcesspressure,turnocompressoranddisconnecthosefromcompressor.

Withthetireinationgunstillconnectedtotheotherendofthecoilhose,pulltriggeronthetire

inationguntoreleaseexcesspressure.

450P-RVS AUTOMATIC PORTABLE COMPRESSOR

USER MANUAL

SAFETY PRECAUTIONS:

1. Alwaysinatetirestomanufacturer’srecommendedtirepressures.Exerciseextremecaution

whendrivingwithaired-downtires.Reinatetiresbeforehigh-speedroadwaytravel.

2. Neverexceed20M.P.H.whendrivingwithpartiallyinatedtires.

3. Nevermakesharpturnswhiledrivingwithreducedtirepressure.

4. Re-inatetiresbeforehighspeedtravelingontoroadways.

5. Useheat-resistant,minimum200PSI-ratedworkingpressureextensionhose.

Donotuseaftermarkethoseswithlessthan200PSIworkingpressure.Someaftermarkethoses

maynotbesuitableforusewiththisaircompressorduetoheatandpressuretypicallygenerated

bythistypeofaircompressors.

CAUTION:Nevertouchtheaircompressororttingsconnectedtotheaircompressorotherthan

theON/OFFswitchwithbarehandsduringorimmediatelyafteruse.Theextensionhoseandttings

connectedextensionhosewillbecomeveryHOTduringandafteruse.Ifnecessary,wearheat

resistantglovestoremovehosefromthecompressorquickconnectstud.

MAINTENANCE & REPAIRS:

Youraircompressorisequippedwithpermanentlylubricated,maintenance-freemotor.

Nevertrytolubricatethecompressor.Regularlycleandustanddirtfromcompressorcoolingns

andmotorhousing.AllrepairsshouldbeperformedbyManufacturerorManufacturerauthorized

serviceagenciesonly.

450P-RVS AUTOMATIC PORTABLE COMPRESSOR

USER MANUAL

450P-RVS-AUTOMATIC ACCESSORIES:

45-Degree Extended Reach, Angled Chuck:

Open-endedairchuckallowsreachintoareasdiculttoreachbyhand.

ConnectstoTireInationGun.

90-Degree Twist-on Chuck:

Thisopen-endedairchuckcanbeattachedtoanyinationvalvewherethereislimitedclearance.

Primary Hose & Extension Hoses:

Dualhoses,withquickconnectcouplings.

Tire Ination Gun:

Normallyclosed-endedchuck,(untilleverisengaged)allairchucksattachtotheTireInationGun

withquickconnectcouplings.

INLET AIR FILTER INSTALLATION INSTRUCTION:

1. ChecktomakesureairlterelementisproperlyinstalledinyourInletAirFilterAssembly

2. Removethetemporaryprotectiveredplugfromcompressor’sairinletport.

3. Installinletairlterontocompressor’sairinletport.(ThreadtapeNotRecommended).

4. Handtighteninletairlter.

IMPORTANT:Foroptimalcompressorperformance,replacelterelementperiodically.

Cloggedlterwilldrasticallyreducecompressorowrateandperformance.

450P-RVS AUTOMATIC PORTABLE COMPRESSOR

USER MANUAL

TROUBLESHOOTING GUIDE:

Compressorwillnotrun 1. Nopower,orpowerswitch

inOFFposition

2. Blownfuse

3. Motoroverheats

1. Makesurecompressor

switchisON

2. Disconnect compressor

frompowersource,replace

fuse.(RefertoSpecications

section for correct

fuseamperage)

3. Letcompressorcoolofor

about30minutestoallow

thermaloverloadswitchtoreset.

Thermaloverload

protector cuts out

repeatedly

1.Lackofproperventilationor

ambienttemperatureistoohigh

2.Compressorvalvesfailed

1. Movecompressortowell

ventilatedarea,orareawith

lower ambient temperature

2. Serviceorreplacecompressor

Excessiveknocking

orrattling

1. Wornbearingoneccentricor

motor shaft

2. Cylinderorpistonringisworn

1. Serviceorreplacecompressor

Compressorairowlower

thannormal,orcannot

pumptohigherpressures

1.Wornpistonringorinletvalve 1. Serviceorreplacecompressor

PROBLEM: POSSIBLECAUSE(S) CORRECTIVEACTION

450P-RVS AUTOMATIC PORTABLE COMPRESSOR

USER MANUAL

15EDELMAN•IRVINE,CA92618

TEL:(949)585-0011•FAX:(949)585-0188

www.viaircorp.com

MODEL 450P-RVS AUTOMATIC SPECIFICATIONS:

PartNumber: 45057/450P-RVSAutomatic

MotorVoltage: 12-volt

MotorType: PermanentMagnetic

Max.WorkingPressure: 150PSI*

Max.DutyCycle: 100%(Continuous)

(Min.On/O@72ºF&100PSI)

ContinuousUse@72ºF&30PSI: Continuous

Max.CurrentConsumption: 23Amps

Fuse: 30Amps

InlinePressureGauge: 160PSI

Built-inPressureSwitch: 130PSIOn,155PSIO

Auto.ResetThermalProtection: Yes

450P-RVS AUTOMATIC PORTABLE COMPRESSOR

*Tolerance:±3%

LIMITED WARRANTY:

VIAIRCorporationwarrantsthisproduct,whenproperlyinstalledandundernormalconditionsofuse,tobefreefromdefectsin

workmanshipandmaterialsforaperiodofoneyearfromitsoriginaldateofpurchase.Toreceivewarrantyserviceorrepair,please

contactVIAIRCorporation.

Returnsshouldbemadewithinoneyearofthedateofpurchase,afteraReturnGoodsAuthorization(RGA)numberhasbeen

assignedbyVIAIRCorporation.ToobtainRGA,faxacopyofyourreceiptto(949)585-0188.Forcompletewarrantydetails,please

visit:www.viaircorp.com/warranty

PLEASE NOTE:

THISWARRANTYCOVERSPRODUCTDEFECTSONLY;ITDOESNOTCOVERINCIDENTALORCONSEQUENTIALDAMAGES

ASRESULTOFMISUSEORABUSE.

ThisManualisproprietarytoVIAIRCorporationandnoownershiprightsareherebytransferred.NopartoftheManualshallbe

used,reproduced,translated,converted,adapted,storedinaretrievalsystem,communicatedortransmittedbyanymeans,forany

commercialpurpose,includingwithoutlimitation,sale,resale,license,rentalorlease,withoutthepriorexpresswrittenconsentofVIAIR.

VIAIRdoesnotmakeanyrepresentations,warrantiesorguarantees,expressorimplied,astotheaccuracyorcompletenessofthe

Manual.UsersmustbeawarethatupdatesandamendmentswillbemadefromtimetotimetotheManual.Itistheuser’sresponsibility

todeterminewhethertherehavebeenanysuchupdatesoramendments.NeitherVIAIRnoranyofitsdirectors,ocers,employees

oragentsshallbeliableincontract,tortorinanyothermannerwhatsoevertoanypersonforanyloss,damage,injury,liability,costor

expenseofanynature,includingwithoutlimitationincidental,special,directorconsequentialdamagesarisingoutoforinconnection

withtheuseoftheManual.

*Donotexceedcompressor’smaxworkingpressuretopreventdamagetothecompressor.

R3-072921

This manual suits for next models

Table of contents

Popular Air Compressor manuals by other brands

Sparmax

Sparmax DC-25XR user manual

KAESER

KAESER M122 Service manual

GMC

GMC GAC1500 Original instructions

Briggs & Stratton

Briggs & Stratton Air Compressor Operator's manual

Fini

Fini F3GST2TK Operator's manual

Industrial Air

Industrial Air CP1580325 Operator's & parts manual

Campbell Hausfeld

Campbell Hausfeld RP3300 Easy setup guide

Ingersoll-Rand

Ingersoll-Rand UP6 20 HP Option manual

Hitachi

Hitachi EC99S Instruction manual and safety instructions

Parkside

Parkside PKO 270 A1 operating instructions

Sullair

Sullair 185 manual

Clas Ohlson

Clas Ohlson QIE-ZTH-15 manual

Ferm

Ferm CRM1046 Original instructions

BE AC153 Operation manual

RIDGID

RIDGID OF25150A Operator's manual

Johnson Controls

Johnson Controls QUANTUM LX Setup

Sears

Sears Craftsman 919.167463 owner's manual

Ring Automotive

Ring Automotive RAC700 instructions