Sunbeam 9104 User manual
DANGER
Owner’s Manual
Aluminum Fire Table DANGER
If you smell gas:
1. Shut off gas to the appliance.
3. If odor continues, keep
away from the appliance and
immediately call your gas
WARNING
Do not store or use gasoline
liquids in the vicinity of this or
any other appliance.
An LP-cylinder not connected
for use shall not be stored in
the vicinity of this or any other
appliance.
WARNING
For outdoor use only.
WARNING
Improper installation, adjustment, alteration, service or maintenance can cause injury or
property damage. Read the owner’s manual thoroughly before installing or servicing this
result causing property damage, personal injury or loss of life.
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space
such as a camper, tent, car or home.
CAUTION
Firebowl Pan and Flame Glass are wet!
Items #
9104, 9718
explosion, injury or death.
WARNING
• The installation of this unit must adhere to local codes or either the National Fuel Gas Code, ANS Z21.97-2017/CSA
2.41-2017 Standard for Outdoor Decorative Gas Appliances.
• THIS UNIT IS INTENDED FOR OUTDOOR USE ONLY! This product shall be used outdoors, in a ventilated space and
shall not be used in any enclosed area.
• Do not use any solid fuel or charcoal for this unit.
• LP GAS WARNING: Do not use any more than 1/4 in. depth Flame Glass above the burner holes. Doing so will
• If the propane gas tank is leaking gas, you may hear, see, or smell a hiss. Do the following:
department for help.
• Applying too much propane may result in gas pooling and will not burn. Allow fresh air into the unit so that the
remaining gas may escape.
• The maximum inlet supply pressure: maximum Gas supply 11 in. w.c. (2.74kPa)
• Use LP propane tanks with the following dimensions: diameter 12 in., height 18 in. - capacity 20 lbs.
• You must use a propane tank that has a collar to protect the gas valve.
• The tank system must be set up for vapor withdrawal.
• Discontinue use if any part of the propane tank is damaged. Rust and dents may be hazardous and should be
inspected by a gas supplier.
• Always ensure that Flame Glass is completely dry before use. Failure to do so may cause them to crack or break.
• Do not operate unit until all parts are fully assembled.
• Do not paint or color any part of this heating unit.
• Unit may be hot while in use, do not attempt to move it while in use.
• Never leave this heating unit unattended while in use.
• This unit is not intended for cooking.
• Keep a safe distance to avoid burning skin or clothing.
• Do not sit or rest hands or feet on this heating unit.
• Keep all electrical cords and fuel supply hose away from heated surfaces.
• Combustible material should not be within 72 in. of the top of the unit, or within 48 in. around the entire unit.
• Do not add water into the unit.
appliance and replace any part of the control system and any gas control that has been under water.
• Do not disconnect any part while unit is in use.
• Do not store a spare propane tank on or near this unit.
• If the heating unit is indoors, detach the propane tank and leave outdoors.
• Always remove protective cover before operating (if applicable).
• Do not set the protective cover over the unit until it is turned off and completely cooled down.
• Check for leaks after not using the unit for long periods of time.
• Children should never operate this unit. Children must be supervised while near this unit.
• Keep gas tank at least 5 feet away from unit when lit. (if external tank)
• The maximum gas supply pressure is 250 psi.
Safety Information
Page 2
Min. Clearance
48 in. (121.9 cm)
Min. Clearance
48 in. (121.9 cm)
Min. Clearance
48 in. (121.9 cm)
Min. Clearance
48 in. (121.9 cm)
cleaned regularly.
• Inspect all elements of this heating unit before each use. If there is damage, the burner must be replaced.
• Keep the hose out from any pathways to eliminate any accidental damage. (if external tank)
• Be aware of the hazards of high temperatures and stay away from the unit to avoid any burns or injury.
Department of Transportation or the National Standard of Canada CAN/CSA-B339, LP gas tanks, spheres and tubes for
Transportation of Dangerous Goods; and Commission.
connection.
• Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid burns
or clothing ignition.
• Young children should be carefully supervised when they are in the area of the appliance.
• Any guard or other protective device removed for servicing the appliance shall be replaced prior to operating the
appliance.
the control compartment, burners and circulating airways of the appliance are kept clean.
IF APPLICABLE:
• Allow heating item to cool completely before placing on lid.
• DO NOT use heating item while lid is installed. Always remove the lid while heating item is in use. Only use the
regulator and hose assembly provided with this unit. Replacement parts must be supplied directly by Jay Trends.
Inspect the burner before use of this unit. If the burner shows any kind of damage, do not operate the appliance.
For assistance with repair or replacement of the burner or any other parts, call Jay Trends at 1-877-387-3639.
NOTE: You must follow all steps to properly assemble this heating item. Make sure the gas valve is turned “OFF” before
assembling. Do NOT attempt to assemble without proper tools.
Safety Information
Combustible materials should not be within 72 in. of the top of
the unit, or within 48 in. around the entire unit.
1-877-387-3639 | Page 3
CAUTION
Firebowl Pan and Flame Glass are wet!
Package Contents
PART DESCRIPTION QUANTITY
A Lid 1
B Fire Table 1
C Protective Cover 1
D Flame Glass (32 lbs) 1 Box
E Pre-Assembled Feet 4
Page 4
A
C
D
E
B
Hardware Contents
PART DESCRIPTION QUANTITY
1 Burner 1
2 Firebowl Pan 1
3 Ignition Pin 1
4 Thermocouple 1
5 Corrugated Pipe 1
6 LPG Reducer 1
7 Valve with LPG Hose and Regulator 1
8 Control Knob 1
9 Pulse Ignition 1
10 Heat Resistant Panel 1
11 Ignition Screen 1
12 Control Panel 1
13 NG Reducer 1
14 AAA Batteries 1
1-877-387-3639 | Page 5
1 2
3
9 10
11 12 13 14
4 5 6
7 8
Please read and understand this entire manual before attempting to assemble, operate or install this appliance. If you
have any questions regarding the product, please call customer service 1-877-387-3639, 8 a.m. – 4 p.m., EST, Monday –
Friday. This appliance has been tested to and complies with the ANS Z21.97-2017/CSA 2.41-2017, Outdoor Decorative
Gas Appliances CGA CR 97-003 Outdoor Gas Fireplaces. The installation must conform to local codes or in the absence
of local codes, to the National Fuel Gas Code. ANSIZ223.1. This manual contains important information about the
is also located throughout this manual. Keep this manual for future reference and to educate new users of this appliance.
This manual should be read in conjunction with the labeling on the appliance. Safety precautions are essential when
any mechanical or propane fueled equipment is involved. These precautions are necessary when using, storing, and
servicing. Using this appliance with the respect and caution demanded will reduce the possibilities of personal injury or
property damage. The following symbols shown below are used extensively throughout this manual. Always heed these
precautions, as they are essential when using any mechanical or propane fueled equipment.
DANGER:
DANGER indicatesan imminently hazardous
situation which, if not avoided, will result in death
or seriousinjury.
DANGER:
Failure to complywiththe precautions and
in death, seriousbodily injury and propertyloss
asphyxiation, and/or carbon monoxide poisoning.
Only persons who can understand and follow the
DANGER:
FOR YOUR SAFETY:
If you smell gas:
1. Shut off gas to the appliance.
3. If odor continues, keep away from the appliance
department.
Solid fuels shall not be burned with this appliance.
CAUTION
Pan and Flame Glass are wet!
Page 6
Safety Information
Assembly
21
3 4
pit is in use.
glass (D) around burner and put lid (A)in place.
4. Install Battery to Igniter (9). Remove the rubber cap on
the electronic igniter (A) by unscrewing and slide battery
(B) into the battery slot. Make sure the positive side of
the battery faces outwards. Screw the electronic igniter
cap (A) over the battery tightly.
1.1. Leave adequate space around the Ignition Screen
for ventilation.
1.2. DO NOT COVER THE IGNITION SCREEN when placing the
flame glass into the firebowl. Always keep ignition screen visible.
Natural Gas Conversion
Natural gas conversion must be performed only by a natural gas provider or service company.
Refer to pages 11 - 13 for more information.
1-877-387-3639 | Page 7
A
A
A
A
B
1.1
1.2
Assembly
Standard 20 lb. tank
5 B
5 A
5. Connect Gas Tank
(A) Connect hose and regulator to cylinder.
(B) Turn the cylinder valve clockwise to close the gas supply on the gas
cylinder. Screw the regulator coupling clockwise by hand only. Make
sure it is fastened.
Storage of an appliance indoors is permissible only if the cylinder is disconnected and removed from the appliance. A
cylinder must be stored outdoors in a well-ventilated area out of reach of children. A disconnected cylinder must have
all dust caps tightly installed and must no be stored in a building, garage or any other enclosed area. The maximum inlet
gas supply pressure: 250 psi. The minimum inlet gas supply pressure: 5 psi.
operation at rating less than full input rating.
The pressure regulator and hose supplied with the appliance must be used. The installation
must conform with local codes or in the absence of local codes, with national fuel gas code,
ANS Z21.97-2017/CSA 2.41-2017, natural gas and propane Installation Code, CSA B1491.1, or
propane storage and handling code, B149.2.
A dented, rusted or damaged propane cylinder may be hazardous and should be checked by your
cylinder supplier. Never use a propane cylinder with a damaged valve connection.
LP gas cylinders of the U.S. Department of Transportation (DOT) or the standard for cylinders,
spheres and tubes for transportation of dangerous goods and commission, CAN/CSA-B339.
The cylinder must have a connection device compatible with the connection for the appliance.
The cylinder used must include a collar to protect the cylinder valve.
Never connect an unregulated propane cylinder to the appliance.
Page 8
Assembly
6A. Install Cylinder. Put the cylinderinto bottom Plate.
6 B
6 C
6 C. Close the door. Fire table assembly is now complete.
6 A
6 B. Secure the cylinder by tightening the screw in the
bottom plate.
1-877-387-3639 | Page 9
Assembly
Regulator/Cylinder Connection
Hose/Regulator Connection
7
7. Perform Leak Test
WARNING
Perform all tests outdoors.
NEVER leak test when smoking.
have beenleak tested and do not leak.
•Do not store a spare LP-gas cylinder under or nearthis
appliance.
•
• Place the dust cap on the cylinder valve outlet whenever the
cylinder is not in use. Only install the type of dust cap on the
cylinder valve that is provided with the cylinder valve. Other
type of caps or plugs may result in leakage of propane.
CAUTION
and Flame Glass are wet!
Page 10
(I) Make 2-3 oz. of leak test solution (one part liquid dishwashing
detergent and three parts water).
(III) Apply several drops of solution whe re hose attaches to regulator.
(IV) Apply several drops of solution whe re regulator connects to cylinde r.
(V) Turn cylinder valve ON.
If bubbles appear at any connection, there is a leak.
(I) Turn cylinder valve OFF.
(II) If leak is at hose/regulator connection: tighten connection and
perform another leak test. If bubbles continue appearing, the hose
should be returned to the place of pu rchase.
(III) If leak is at regulator/cylinder valve connection: disconnect,
reconnect, and perform another leak test. If you continue to see bubbles
after several attempts, cylinder valve is defective and should be returned
to cylinder place of pu rchase.
If NO bubbles appear at any connection, the connections are secure.
NOTE: Whenever gas connections are loosened or removed, you must
perform a complete leak test.
This manual suits for next models
1
Table of contents
Other Sunbeam Outdoor Fireplace manuals
