Star Lang LRB-24 User manual

WARNING: Improperinstallation,adjustment,

alteration, service or maintenance can cause

property damage, injury or death. Read

the installation, operating and maintenance

instructions thoroughly before installing or

servicing this equipment.

FOR YOUR SAFETY: Do not store or use

gasolineorotherﬂammablevaporsorliquids

in the vicinity of this or any other appliance.

WARNING: This appliance shall be installed

in accordance with current regulations and

used only in well-ventilated space. Refer to

instructions before installing and using this

appliance.

In addition, there should be posted, in a

prominent location, detailed instructions to

be followed in the event the operator smells

gas. Obtain the instructions from the local

gas supplier.

GAS RADIANT

CHARBROILER

LRB-24, LRB-36, LRB-48,

LRB-60, LRB-72

Installation and

Operation

Instructions

2M-W737 Rev. - 3/01/07

LRB-24

These symbols are intended to alert the user to the presence of

important operating and maintenance instructions in the manual

accompanying the appliance.

RETAIN THIS MANUAL FOR FUTURE REFERENCE

NOTICE

Using any part other than genuine Star factory supplied parts relieves the

manufacturer of all liability.

Star reserves the right to change speciﬁcations and product design without

notice. Such revisions do not entitle the buyer to corresponding changes,

improvements, additions or replacements for previously purchased

equipment.

Due to periodic changes in designs, methods, procedures, policies and

regulations, the speciﬁcations contained in this sheet are subject to change

without notice. While Star Manufacturing exercises good faith efforts to provide

information that is accurate, we are not responsible for errors or omissions

in information provided or conclusions reached as a result of using the

speciﬁcations. By using the information provided, the user assumes all risks in

connection with such use.

MAINTENANCE AND REPAIRS

Contact your local authorized service agent for service or required maintenance. Please record the model

number, serial number, voltage and purchase date in the area below and have it ready when you call to

ensure a faster service.

SAFETY SYMBOL

Model No.

Serial No.

Voltage

Purchase Date

Business 8:00 am to 4:30 p.m. Central Standard Time

Hours:

Telephone: (800) 807-9054 Local (314) 781-2777

Fax: (800) 396-2677 Local (314) 781-2714

E-mail [email protected]

[email protected]

W[email protected]

Website: www.star-mfg.com

The Star Service Help Desk

Authorized Service Agent

Reference the listing provided with the unit

for an updated listing go to:

Website: www.star-mfg.com

E-mail [email protected]

Telephone: (800) 807-9054 Local (314) 781-2777

Mailing Address: Star Manufacturing International Inc.

10 Sunnen Drive

St. Louis, MO 63143

U.S.A

SPECIFICATIONS

LRB-24 - Radiant

Type: Manual Control

4 Controls, 80,000 BTUH (20,000 BTUH Nat/LP per burner)

603 sq. in. (3,890 sq. cm) Grid Area

Approximate Weight: Installed - 174 Lb s (78.9 kg), shipping - 240 Lbs (108.9 kg)

Dimensions: 24" - Width, 30 5/8" - Depth, 18" - Height

(61 cm - Width, 77.8 cm - Depth, 45.7 cm - Height)

LRB-36 - Radiant

Type: Manual Control

6 Controls, 120,000 BTUH Total (20,000 BTUH Nat/LP per burner)

906 sq. in. (5,845 sq. cm) Grid Area

Approximate Weight: Installed - 240 Lbs (108.9 kg), shipping - 316 Lbs, (143.3 kg)

Dimensions: 36" - Width, 30 5/8" - Depth, 18" - Height

(91.4 cm - Width, 77.8 cm - Depth, 45.7 cm - Height)

LRB-48 - Radiant

Type: Manual Control

8 Controls, 160,000 BTUH Total (20,000 BTUH Nat/LP per burner)

1,209 sq. in. (7,800 sq. cm) Grid Area

Approximate Weight: Installed - 314 Lbs (142.4 kg), shipping - 398 Lbs, (180.5 kg)

Dimensions: 48" - Width, 30 5/8" - Depth, 18" - Height

(122 cm - Width, 77.8 cm - Depth, 45.7 cm - Height)

LRB-60 - Radiant

Type: Manual Control

10 Controls, 200,000 BTUH Total (20,000 BTUH Nat/LP per burner)

1,512 sq. in. (9,754 sq. cm) Grid Area

Approximate Weight: Installed - 386 Lbs (175.1 kg), shipping - 486 Lbs, (220.4 kg)

Dimensions: 60" - Width, 30 5/8" - Depth, 18" - Height

(152.4 cm - Width, 77.8 cm - Depth, 45.7 cm - Height)

LRB-72 - Radiant

Type: Manual Control

12 Controls, 240,000 BTUH Total (20,000 BTUH Nat/LP per burner)

1,815 sq. in. (11,710 sq. cm) Grid Area

Approximate Weight: Installed - 530 Lbs (240 kg), shipping - 665 Lbs, (301 kg)

Dimensions: 72" - Width, 30 5/8" - Depth, 18" - Height

(182.9 cm - Width, 77.8 cm - Depth, 45.7 cm - Height)

GENERAL INSTALLATION DATA

CAUTION

This equipment is designed and sold for commercial use only by personnel trained and

experienced in its operation and is not sold for consumer use in and around the home

nor for use directly by the general public in food service locations.

TheLangseriesgascharbroilerisequippedforthetypeofgasindicatedonthenameplate

mounted on the front panel. All units are shipped from the factory for use with natural

gas. The unit can easily be converted for use with propane gas: see propane gas.

-IMPORTANT-

Be sure to remove all paper protection and packing material from unit prior to

lighting.

INSTALL IN NON-COMBUSTIBLE LOCATIONS ONLY! Clearance from non-

combustibleconstructionmustbe3"minimumfrombackandsides. Forservicing,

6" is recommended from back of unit.

TheinstallationoftheAppliancemustconformtotheNATIONALFUELGAS

CODE "ANSI Z223.1 - LATEST EDITION" ANDALL LOCAL GAS COMPANY

RULES AND REGULATIONS.

IN CANADA INSTALLATION SHALL BE IN ACCORDANCE WITH THE

CURRENT CAN/CGA-B149.1 NATURAL GAS INSTALLATION CODE OR

CAN/CGA-B149.2 PROPANE INSTALLATION CODE AND LOCAL CODES

WHERE APPLICABLE. NOTICE

When this appliance is installed with casters, it must be installed with the casters supplied, a

connectorcomplyingwitheitherANSIZ21.69orCAN/CGA-6.16andaquick-disconnectdevice

complying with either ANSI Z21.41 or CAN1-6.9. It must also be installed with restraining

means to guard against transmission of strain to the connector, as speciﬁed in the appliance

manufacturer's instructions.

For your protection, we recommend a qualiﬁed installing agency install this appliance.

They should be familiar with gas installations and your local gas requirements. In any

case, your gas company should be called to approve the ﬁnal installation.

This appliance, its pressure regulator and its individual shutoff valve must be disconnected

from the gas supply piping system during any pressure testing of that system at test pressures

in excess of 1/2 PSIG. This appliance and its pressure regulator must be isolated from the gas

supply piping system by closing its individual manual shutoff valve during any pressure testing

of the gas supply piping system at test pressures equal to or less than 1/2 PSIG.

EXHAUST CANOPY

Open hearth broilers inherently create a good deal of heat and smoke and should be installed

under an efﬁcient exhaust hood with ﬂame proof ﬁlters.A vertical distance of not less than 48"

shallbeprovidedbetweenthetopoftheapplianceand ﬁltersoranyothercombustiblematerial.

Exhaust installation must conform to local codes.

AIR SUPPLY

Provisions for adequate air supply must be provided.

CAUTION

Air for combustion enters from the bottom of the unit. Do not obstruct this

area.

LEVELING UNIT

This charbroiler is supplied with 4 feet or ﬂoor stand

legs which must be screwed into the body. Unit must

be level. Level unit by adjusting the (4) feet which

have an adjustment of 1-3/4" for accurate and perfect

line-up with other units.

Caster Kits: Casters can be used with ﬂoor stand models or optional equipment stand. For installation, carefully

mark and cut off from the bottom of each leg using a straight cutting saw and de-burr the inside tube wall

prior to installing the caster. Cut leg should measure 19" tube length, not overall length. Casters add about

6-1/4" of height to the unit. Be sure to use approved strain relief means for protecting gas line connection.

If an appliance is equipped with casters and is gas connected with a quick connect coupling, all personnel

must be aware that there is a restraint on the appliance and if disconnected for service or cleaning it must be

reconnected as originally installed prior to use.

CAUTION

DO NOT INSTALL WITHOUTATTACHING FEET

OR SUPPLIED STAND LEGS AND SHELF - DO

NOT REMOVE FEET.

STIFFENING SUPPORTS ON LRB-48,

LRB-60 AND LRB-72 MODELS ONLY

SCREW LEGS INTO MOUNTING NUTS ON BOTTOM

GENERAL INSTALLATION DATA (continued)

PLACING RADIANTS - RCB SERIES

After the unit is unpacked and installed, place 1 radiant above each burner. Install each radiant

on 2 slots of the rear wall and on 1 pin of the front wall of the liner weld assembly. Refer to the

exploded view in this manual for orientation of the radiants.

PLACING LAVA ROCKS- CB SERIES

Open the lava rock bags and place rock evenly on the lower internal grates - not the top cooking

grates. Spread the lava rock evenly on the grates approximately 1 layer thick. Do not cover

the grates with more than two layers of lava rock. Do not put more than 5 pounds of rock per

burner section.

GAS PIPING

Gas piping shall be of such size and so installed as to provide a supply of gas sufﬁcient to meet

the full gas input of the appliance. If the appliance is to be connected to existing piping, it shall

becheckedto determine ifithas adequate capacity. Jointcompoundshall be usedsparinglyand

only on the male threads of the pipe joints. Such compounds shall be resistant to the action of

L.P. gases. WARNING:Any loose dirt or metal particles which are allowed to enter the gas lines

on this appliance will damage the valve and affect its operation. When installing this appliance,

all pipe and ﬁttings must be free from all internal loose dirt.

GAS PRESSURE REGULATOR

Aconvertible pressure regulator is provided with each charbroiler. It should be connected to the

inlet pipe at the rear of the unit. The gas supply is then connected to it. The supply pressure to

the regulator is not to exceed 1/2 PSIG. It is shipped set for 5" water column manifold pressure

for use with natural gas.

MANUAL SHUT OFF VALVE

A manual shut off valve should be installed upstream from the manifold and within six feet of

the charbroiler.

CONNECTING GAS SUPPLY LINE

The gas inlet of the charbroiler is sealed at the factory to prevent entry of dirt. Do not remove

this seal until the actual connection is made to the gas supply line.

PROPANE GAS - CONVERSION

This charbroiler is equipped with ﬁxed oriﬁce hoods and is shipped from the factory for use with

natural gas. To convert to propane gas, install the burner oriﬁce hoods, located in the water pan,

as follows:

1. Remove grates, radiants and burners.

2. Remove the burner oriﬁce hoods and install the oriﬁce hoods supplied.

3. Replace the burners, radiants, and grates.

4. Set manifold pressure to (10) inch water column. A1/8" pipe plug on the burner manifold can

be removed for attaching a pressure gauge. Remove the slotted, or hex-threaded plug from

the pressure regulator. Invert the plug and re-install. The letters "LP" should now be visible

on the plug. The regulator is now set for 10" (25.4 cm) water column. Attach the conversion

label, supplied with the unit, close to the nameplate.

CHECKING FOR GAS LEAKS

Check entire piping system for leaks. Soap and water solution or other material acceptable for

the purpose, shall be used in locating gas leakage.

CAUTION

Matches, candle ﬂame or other sources of ignition shall not be used for locating

gas leaks.

PILOT LIGHTING INSTRUCTIONS

The charbroiler is equipped with standing pilots, and should be lit immediately after the gas is

turned on.

1. Turn off main valve to unit.

2. Turn off all knobs and pilot valves and wait 5 minutes to clear gas.

3. The pilot lights on this broiler have been pre-set at the factory. Turn the adjustable screw

counterclockwise to open and clockwise to close.

4. Turn on main valve and light all pilots.

5. Adjust pilot light ﬂames as small as possible, usually about 1/2" high, but high enough to light

burner immediately when burner valve is turned on high.

6. Turn burner knobs to desired setting.

7. To turn burners off, turn knobs off.

BURNER IGNITION AND ADJUSTMENT

1. To ignite burners turn burner valve knob counter clockwise to "ON"position.

2. Slowly decrease openings of air shutters to give a soft blue ﬂame having luminous tips, then

slowly increase openings to a point where the yellow tips disappear and a hard blue ﬂame

is obtained.

GENERAL OPERATING INSTRUCTIONS

WATER PAN

The water pan is located at the bottom of the unit, and is easily removed from the front of the

unit. Water should be added to the water pan to just cover bottom and replaced as necessary.

The water pan helps prevent ﬂare ups and catches grease.

BURNER OPERATION

Eachburneriscontrolledbyanindividualhigh-low,on-offvalve.Avarietyofbroilingtemperatures

may be obtained by turning the burner valve knob to any position between on and off. It is

possiblethrough thisarrangement tohave ahighheatorsearingsection,whilehavinga lowheat

ﬁnishing or holding section. For the searing operation, turn the valve counter clockwise for the

section to a position of "ON" or close to it. For holding or ﬁnishing, turn the valves closer to the

"OFF" position on the dial. You select the heat pattern you like, and set the valves accordingly.

Be sure burners are staying fully lit when set in low positions.

LIGHTING

Whenbroilerisﬁrstlit,itwillsmokeforapproximately20-30minutesuntilthepreservation

oils and impurities are burned off.

BROILING

Turn valves on and pre-heat unit on "ON" before attempting to broil. You will have to

experimentwiththegratesettingsandthevalvesettingsforyourparticularfoodproducts.

Check water pans frequently and add a sufﬁcient amount of water when necessary. Hot

water vapors rising from the water pans and through the combustion chamber helps

reduce ﬂare ups. Exercise care when using your broiler.

TILTING THE GRATE

Raise or lower the grate to the next step by lifting the grate at the back of the charbroiler

where the grate rests. Use potholders or gloves to reposition.

CAUTION

CHARBROILERS ARE HOT! NEVER ATTEMPT TO CHANGE THE GRATE

POSITION WHILE FOOD PRODUCTS ARE COOKING. FLARE UPS CAN OCCUR

UNEXPECTEDLY. TURN OFF CHARBROILER, AND ALLOW THE CHARBROILER

TO COOL.

SHUTTING DOWN INSTRUCTIONS

Turn the burner valve knobs to the off position to turn burners off and close manual valve

gas shutoff.

CLEANING

Clean regularly. Remove grate section to sink for washing. Brush out carboned particles.

Remove and wash water pan. Wipe exterior surfaces with detergent and a cloth. A non-

abrasive cleaner can be used on caked areas.

Nameplate

SK2236 Rev. - 2/16/07

Model LRB-24

Gas Charbroiler

PARTS LIST February 28, 2007, Rev -

IMPORTANT: WHEN ORDERING, SPECIFY VOLTAGE OR TYPE GAS DESIRED PAGE

INCLUDE MODEL AND SERIAL NUMBER OF

Some items are included for illustrative purposes only and in certain instances may not be available.

Number

Per

Unit Description and Model Designation

Part

Number

Key

Number

MODEL

1 2F-Z4692 4/6/8/10/12 TOP GRATE (5-7/8 W x 25-1/4 L) ALL

2 2F-Z4693 4/6/8/10/12 RADIANT LRB-24 / LRB-36 / LRB-48 / LRB-60 / LRB-72

3 H5-Z4726 1 BURNER SUPPORT BRACKET LRB-24

3 H5-Z4727 1 BURNER SUPPORT BRACKET LRB-36

3 H5-Z4728 1 BURNER SUPPORT BRACKET LRB-48

3 H5-Z4729 1 BURNER SUPPORT BRACKET LRB-60

3 H5-Z7790 1 BURNER SUPPORT BRACKET LRB-72

4 H5-Z4747 1 REAR PANEL - 24 LRB-24

5 2J-Z4686 1 REGULATOR ALL

6 2K-Z4755 1 MANIFOLD PIPE LRB-24

6 2K-Z4756 1 MANIFOLD PIPE LRB-36

6 2K-Z4757 1 MANIFOLD PIPE LRB-48

6 2K-Z4758 1 MANIFOLD PIPE LRB-60

6 2K-Z7798 1 MANIFOLD PIPE LRB-72

8 2V-6671 4/6/8/10/12 PILOT VALVE ALL

9 2V-Z4736 4/6/8/10/12 PILOT TUBE ALL

10 2F-Z4685 4/6/8/10/12 BURNER LRB-24 / LRB-36 / LRB-48 / LRB-60 / LRB-72

11 2J-Y7216 4/6/8/10/12 HOOD BURNER ORIFICE #47 NAT. ALL

11 2J-Y7250 4/6/8/10/12 HOOD BURNER ORIFICE #55 LP ALL

12 2V-Y8832 4/6/8/10/12 GAS VALVE ALL

13 H5-CB0012 1 FRONT PANELASSEMBLY LRB-24

13 H5-CB0013 1 FRONT PANELASSEMBLY LRB-36

13 H5-CB0014 1 FRONT PANELASSEMBLY LRB-48

13 H5-CB0015 1 FRONT PANELASSEMBLY LRB-60

13 H5-CB0063 1 FRONT PANELASSEMBLY LRB-72

14 2M-W728 4/6/8/10/12 LABEL, ON/OFF ALL

15 2R-Z4997 4/6/8/10/12 KNOB ALL

16 H5-Z4743 1/2 PAN, WATER LRB-24 / LRB-48

16 H5-Z4744 1 PAN, WATER LRB-36

16 H5-Z4744 2 PAN, WATER LRB-72

16 H5-Z4746 2 PAN, WATER LRB-60

17 2A-Z4614 4 FOOT (5/8-11 STUD) ALL

18 H5-Z4856 1 PAN SUPPORT BRACKET LRB-48, LRB-60, LRB-72

-- E5-UM24SF 1 FLOOR STAND 24" (optional, not shown) LRB-24

-- E5-UM36SF 1 FLOOR STAND 36" (optional, not shown) LRB-36

-- E5-UM48SF 1 FLOOR STAND 48" (optional, not shown) LRB-48

-- E5-UM60SF 1 FLOOR STAND 60" (optional, not shown) LRB-60

-- E5-UM72SF 1 FLOOR STAND 72" (optional, not shown) LRB-72

LRB-24, LRB-36, LRB-48, LRB-60, LRB-72 Radiant Gas Charbroiler

Star Manufacturing International, Inc.

This manual suits for next models

Table of contents

Languages:

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide