Silvan Selecta TR25-2 User manual

Instruction Manual

MANTR25-2 REV C 06/12/19

20L UPRIGHT TROLLEY SPRAYER

TR25-2

VICTORIA (HEAD OFFICE)

Telephone: +61 (03) 9215 2700

Fax: +61 (03) 9215 2701

www.silvan.com.au

NEW ZEALAND

Hamilton, New Zealand

Telephone: +64 (07) 8496 033

Fax: +64 (07) 8496070

www.silvannz.co.nz

SILVAN AUSTRALIA PTY. LTD.

ABN 48 099 851 144

Silvan Warranty

Our goods come with guarantees that cannot be excluded under the Australian Consumer Law.

You are entitled to a replacement or refund for a major failure and for compensation for any other

reasonably foreseeable loss or damage. You are also entitled to have the goods repaired or

replaced if the goods fail to be of acceptable quality and the failure does not amount to a major

failure.

We warrant our goods to be free from defects in materials and workmanship for the warranty

period of 12 months from the date the product is delivered to the consumer.

Silvan warrants its authorised Dealer, who in turn warrants the original purchaser (consumer) of

each new Silvan product that it will repair or replace the product, or, pay the cost of repair or

replacement, as determined by Silvan without charge for labour or any defective or malfunctioning

parts in accordance with the warranty limitations below.

This Warranty is in addition to any other rights and remedies available to consumers under the law

This Warranty Covers

Only conditions resulting directly from defects in workmanship or material under normal use and

service.

Warranty Exclusions

The Warranty does not cover:

•Conditions resulting from misuse, use of incompatible chemicals, exceeding machine

specifications including overloading, impact damage, negligence, accidental damage or failure to

perform recommended maintenance services as specified in the Owner/Operator Manual

applicable to the product.

•Damage caused by continued use of a product after initial failure

•Any product which has been repaired by other than an authorised Silvan service outlet in a way

which, in the sole and absolute judgment of Silvan, adversely affect its performance or reliability.

•The replacement of maintenance items such as diaphragms, batteries, V belts and ground

engaging components, etc.

How To Claim Warranty

Return the goods to the place of purchase at your cost and within the warranty period along with

evidence of the purchase date. If the original supplier cannot be contacted, then contact Silvan as

below and we can direct you on how to proceed with your warranty claim.

How Your Claim Will Be Managed

The repair of a defective product qualifying under this warranty will be performed by any authorised

Silvan service outlet within a reasonable time following the delivery of the product, at the cost of

the owner, to the service outlet’s place of business. The product will be repaired or replaced

depending on the extent of the problem at the discretion of Silvan and the Silvan dealer.

Warranty

Warning! This sprayer is designed and manufactured solely for the purpose of applying agricultural

chemicals to plants and pests. Under no circumstances may it be used for any other

purposes.

Warning! Before using this sprayer all operators and users must have read and understood the

contents of this manual and any other manual supplied with the sprayer or associated

equipment.

Warning! Exercise extreme care when operating in hilly or uneven terrain to ensure proper stability.

Warning! Refer to the chemical manufacturer’s label for correct use and safe handling instructions

of chemicals before use. Make sure correct safety equipment and clothing are used in

accordance with the chemical manufacturer’s instructions.

Warning! Never allow inadequately trained personnel to attach or operate this sprayer.

Warning! Before carrying out maintenance work, wash the sprayer thoroughly to remove all toxic

chemicals that may contaminate the sprayer.

Warning! Overtightening plastic fittings can result in damage, leading to exposure to spray

chemicals or improper application.

Warning! Never leave the battery to charge unattended.

Warning! Do not charge damaged batteries.

Warning! Battery charges should not be used in wet environment.

Warning! Never charge battery for periods of time longer than 8 hours. Over charging the battery

can create an explosion and a fire hazard.

Safety Instructions

Before attempting to operate or install the sprayer carefully read and take note

of the following safety warnings.

Failure to comply with these warnings may result in serious injury or death.

GENERAL

TR25-2 is a self-contained compact portable sprayer with its own power supply. Whether you are a

commercial grower, or hobby farmer, you will find many uses for this unit. The tank, pump and spray

lance fittings are corrosion resistant and suitable for applying weedicides, herbicides, insecticides,

fungicides, miticides, organic and green formulations.

FRAME - Heavy duty construction frame (1) with removable handle (2) and extra wide wheels (3).

The TR25-2 also includes a protective pump cover (12).

PUMP (4) - TR25-2 features Viton Valves and Santoprene Diaphragms. It also features a 12V Aquatec

Smoothflo Pump DC, 7/min open flow or 8 Bar/120 psi max pressure with a maximum power of 9

amps.

HOSE - 6 meters of 10mm I.D. delivery hose.

Specifications

SPRAYGUN (5) - Standard Spray Gun Assembly (Spotjet Jolly Gun): 600mm long stainless-steel lance

with adjustable cone-jet nozzle that provides an adjustable conical spray pattern as well as a pencil

stream.

Optional Gunjet Spray Gun Assembly: comes in 3 separate parts; lance (part number 6671-18), brass

nozzle (part number: 5500-X8) and spray gun (AA31). This Gunjet spray gun has a lightweight, 18-

inch brass curved lance with an adjustable brass nozzle that provides half turn for wide angle which

gives a fine atomized cone spray to a straight stream distance spraying.

TANK - Made from impact resistant polyethylene, UV stabilized, translucent tank with calibration

20L capacity (6). Screw on lid with an anti-spill breather (7).

FILTRATION (8)- 50 Mesh suction line filter.

CONTROLS - On/off power switch (9). The pump features an electric pressure sensing switch will

stop the pump when pressure reaches 60psi and start the pump when pressure falls below 40psi.

TR25-2 features an adjustable pressure regulator with gauge (10) for selecting spray pressure.

BATTERY (11) - 12 Volt DC, 7 Amp hour, Sealed Lead Acid battery. One recharge should operate

three tank loads.

BATTERY CHARGER - 240V AC supply, 1.7 Amp battery charger.

DIMENSIONS

Depth:

~310mm

Width:

~510mm

Height:

~980mm

Weight (dry):

17kg

Nominal Capacity:

20L

Specifications

TR25-2 comes in completely assembled except for the handle. As seen below it is detached initially.

NOTE: some parts were hidden for the purpose of making this image clear.

SETUP AND TESTING

It is always recommended that you first test all spray equipment thoroughly with clean water. The

TR25-2 is supplied with a Spray Gun. It is recommended that the adjustable nozzle is used first and

can be changed later if required.

1. Be sure to wear safety equipment as recommended by the chemical manufacturer before

adding chemical to the sprayer

2. Check the filter is clean and undamaged (see Maintenance section)

3. Fill the tank with clean water

4. Ensure the 6-meter spray hose and spray lance connected

5. Check all pipes, hoses, hose clamps and connections for leaks or damage

6. Switch the pump ON

7. Adjust the pressure regulator to the off position “O”

8. Depress the spray lance trigger to flush air from the lines. The pump is self-priming and should

start spraying within 30 seconds

9. Check the hose connections for leaks, if any are found stop the pump and rectify the problem

before continuing

10. Twist the tip of the nozzle to the coarsest droplet size, the restriction of flow is minimized, and

pump pulsation will not occur

11. Slowly twist the tip of the nozzle from a course droplet size to a fine droplet to your preference.

12. Once the nozzle is set the sprayer is ready to be utilized for spraying of chemical

13. You can reduce the operating pressure by adjusting the pressure regulator from “0” to “11”

this will reduce the pressure. It will also mean the pump will not turn off when the gun is not

spraying. This will not cause any damage to the pump, but to conserve the battery the pump

can be turned off.

Installation

Operation

CHARGING THE BATTERY

TR25-2 utilizes a 12V DC sealed lead-acid (SLA) battery which requires approximately 4-6 hours of

charging from the supplied battery charger to fully charge the battery. TR25-2 is supplied with a

battery charger for SLA batteries. After the battery is recharged, It should complete 3 tank fills.

Always charge the battery after use. Do not leave the battery flat as it will damage the battery.

Warning! Never leave the battery to charge unattended.

Warning! Do not charge damaged batteries.

Warning! Never charge the battery for periods of time longer than 8 hours. Over charging the

battery can create an explosion and fire hazard.

CLEANING THE FILTER

To avoid chemical contamination, wear appropriate protective equipment including gloves

whenever maintenance is carried out. The filter should be cleaned when the tank is empty to avoid

chemical escaping when the filter is removed. This is best done at the end of each day or before

storage.

Turn off the pump and depress the trigger on the spray lance to dissipate any pressure, unscrew

the cap on the filter housing to remove the filter. Clean the filter with clean water and a bristle-

brush, do not use a wire brush or sharp object as this may damage the mesh. Once the filter is clean,

put it back into the filter housing and replace the cap.

Maintenance

Table of contents

Other Silvan Selecta Paint Sprayer manuals

Silvan Selecta

Silvan Selecta WP12-1 User manual

Silvan Selecta

Silvan Selecta Supaflo 3500 User manual

Silvan Selecta

Silvan Selecta LT30-S8 User manual

Silvan Selecta

Silvan Selecta Super 400L Series User manual

Silvan Selecta

Silvan Selecta 190545 User manual

Silvan Selecta

Silvan Selecta TGS User manual

Silvan Selecta

Silvan Selecta Rakpak Plus User manual

Silvan Selecta

Silvan Selecta RP70N-S7 User manual

Silvan Selecta

Silvan Selecta Oktopus 500L User manual

Silvan Selecta

Silvan Selecta DEC101213P User manual

Silvan Selecta

Silvan Selecta WP16-6 User manual

Silvan Selecta

Silvan Selecta TR12-2 User manual

Silvan Selecta

Silvan Selecta 190547 User manual

Silvan Selecta

Silvan Selecta TR25-S7 User manual

Silvan Selecta

Silvan Selecta REDLINE SPOTPAK Series User manual

Silvan Selecta

Silvan Selecta TR13-1 User manual

Silvan Selecta

Silvan Selecta K02A User manual

Silvan Selecta

Silvan Selecta WP16-6 User manual

Silvan Selecta

Silvan Selecta Spotpak 50L User manual

Silvan Selecta

Silvan Selecta RP50-P1 User manual

Silvan Selecta

Silvan Selecta Supaflo 2000L User manual

Silvan Selecta

Silvan Selecta SPOTPAK SP50-S7 User manual

Silvan Selecta

Silvan Selecta 200 litres User manual

Silvan Selecta

Silvan Selecta Utepak 100L User manual

Popular Paint Sprayer manuals by other brands

SNOWJOE

SNOWJOE Sunjoe 24V-GS-LTW-RM Operator's manual

Graco

Graco 246737 Repair and parts

Binks

Binks SV100 Service manual

Fimco

Fimco LG-4-3-1 owner's manual

AG SPRAY

AG SPRAY FS-ATV-25BL owner's manual

Nordson

Nordson MicroMax 2 manual

Bonide

Bonide 051 Operation and service instructions

zogics

zogics Z-DAS instruction manual

KISANKRAFT

KISANKRAFT KK-KBS-165 Operation manual

Matrix

Matrix SG 650 Translation of the original instructions

Anest Iwata

Anest Iwata SGA-3 Installation, use & maintenance instruction manual

paasche

paasche VV Instructions and parts list

Carlisle

Carlisle DeVilbiss JGA-510 Service manual

Gardena

Gardena 11120 Operator's manual

Conrad

Conrad Hobby Airbrush K3 operating instructions

wiwa

wiwa 14025 R/F operating manual

Graco

Graco EM 390 Instructions-parts list

DeVilbiss

DeVilbiss LUNA2i Operation manual