Rugged Interactive CardioWall Compact Quick guide
© Rugged Interactive 2019
CardioWall®
Compact
Installation and Instruction Manual
For OUTDOOR models from August 2019 onwards
Rugged Interactive
Unit 1 Callywith Court,
Callywith Gate Ind. Est.,
Bodmin
Cornwall
PL31 2RQ
+44 (0) 1726 981 123
www.rugged-interactive.co.uk
Issued 23/08/2019
Rugged Interactive
Unit 1 Callywith Court,
Callywith Gate Ind. Est.,
Bodmin, Cornwall
PL31 2RQ
+44 (0) 1726 981 123
www.rugged-interactive.co.uk
© Rugged Interactive 2019
Contents
Section 1 – Safety Guidelines
Section 2 – Installation
Section 3 – Pod Removal and Installation
Section 4 – How to Use
Section 5 – Programs Guide
Section 6 – Troubleshooting Guide
CardioWall Compact System Specifications
CardioWall Compact Installation Checklist
Rugged Interactive
Unit 1 Callywith Court,
Callywith Gate Ind. Est.,
Bodmin, Cornwall
PL31 2RQ
+44 (0) 1726 981 123
www.rugged-interactive.co.uk
Section 1 - 1
© Rugged Interactive 2019
Section 1 –Safety Guidelines
1.1 Installation Safety Guidelines
Before installing any Rugged Interactive product, please read the following:
Dos:
▪Ensure that a Site Survey form has been completed prior to installation.
▪Have ready suitable equipment, tools and/or man power.
▪Observe correct manual handling techniques whilst moving and installing the equipment.
▪If being installed onto a wall, the product MUST be mounted onto a wall of a construction capable of
supporting its weight and gameplay. If possible, avoid stud walls or unsupported portal infills. If in
doubt always contact a suitably qualified surveyor to check.
▪Visually check the product for any signs of damage, component failure and/or missing parts.
▪To prevent electric shock, keep all electric components away from contact with water.
▪Ensure to take anti-static precautions.
▪Wear appropriate clothing: do not wear loose clothing or jewellery.
▪Long hair should be tied back.
▪Tidy back loose cables that could become a tripping hazard.
▪Ensure that the playing area is clear.
▪Immediately inform Rugged Interactive for maintenance advice if you have concerns.
Don’ts:
▪Do not wear shoes with leather soles or high heels.
▪Do not use any tools that are not specifically recommended by the manufacturer.
▪Do not distract others while they are installing the product.
CardioWall Compact Installation and Instruction Manual: Section 1 – Safety Guidelines
Section 1 - 2
© Rugged Interactive 2019
1.2 In Play Safety Guidelines
Please ensure you read the following points before using the equipment:
Dos:
▪ Before beginning any exercise program, it is recommended that you consult with your doctor.
▪ Children under the age of 7 years should always be supervised by an adult (over 16 years) when
using the equipment and/or recommended accessories.
▪ Visually check the equipment before using it for any signs of damage, component failure or loose
cables that could become a tripping hazard. Report any concerns, e.g. loose holds or damaged
equipment, to a member of staff immediately.
▪ Ensure you familiarise yourself with any additional facility rules that may apply.
▪ Ensure that the play area in front of the equipment is clear before attempting to participate.
▪ Only participate if you are in good physical condition. Participate only within your capabilities /
recommended exercise level.
▪ Wear appropriate clothing.
▪ Remove all items from your pockets prior to participation.
▪ Long hair should be tied back.
▪ Before use, loosen up with warm up exercises and stretches.
▪ Only those participating are allowed in the activity area. If waiting to participate, stand back at a safe
distance from the equipment.
▪ Report any unusual or inappropriate behaviour to a member of staff immediately.
▪ If you get tired, leave the equipment / activity area and take a break.
▪ If you feel any pain, dizziness, nausea or any other abnormal symptoms, STOP YOUR WORKOUT
IMMEDIATELY. Consult your doctor immediately. Incorrect or excessive training may lead to
injuries.
Don’ts:
▪ Do not attempt to use any of the equipment without undertaking instruction / training carried out by
an appropriate instructor.
▪ Do not participate if you are unwell or have any pre-existing medical conditions including heart,
back, neck, bone and/or muscle conditions.
▪ Do NOT work to exhaustion.
▪ Do not participate if you are or maybe pregnant.
▪ Do not wear loose clothing or jewellery (including studs and watches). Clothing should not have any
hard or sharp points (such as buckles, studs, toggles or alike).
▪ Do not wear shoes with leather soles, high heels, sandals, boots or bare feet.
▪ No food, drink or chewing gum during participation.
CardioWall Compact Installation and Instruction Manual: Section 1 – Safety Guidelines
Section 1 - 3
© Rugged Interactive 2019
▪ No phones or cameras in the activity area.
▪ Do not leave clothing or personal belongings around the activity areas.
▪ Do not participate under the influence of alcohol and/or drugs.
▪ Do not distract others while they are using the equipment.
▪ Do not sit, lie, stand or rest on or under the activity equipment.
▪ Do not use any accessories that are not specifically recommended by the manufacturer. These
might cause injuries or cause the equipment to fail.
NOTE: This activity can be great fun, but it can also be dangerous. There is a risk of serious injury if care is
not taken when using the equipment. Use of this equipment is physically demanding: this is a high-impact,
full body activity which requires intense focus, awareness of your body’s strengths and limitations,
awareness of the environment around you and extreme caution.
Rugged Interactive
Unit 1, Callywith Court
Callywith Gate Ind. Est.
Bodmin, Cornwall, UK
PL31 2RQ
+44 (0) 1726 981 123
www.rugged-interactive.co.uk
hello@rugged-interactive.co.uk
© Rugged Interactive 2019
Section 2 – Installation
Read this manual before installing the CardioWall Compact units.
Installation Guidelines:
• Complete the Site Survey form prior to delivery and/or installation: https://goo.gl/Rs3n5u
• Please send a completed Installation Checklist after any installation to Rugged Interactive.
• A typical installation should take 2 people about 2 hours.
• No obstructions or protrusions in the installation area: e.g. skirting boards, pipes, cables and wiring
conduits.
• Avoid trapped and/or pinched cables.
• Use good practice when running data cables to and from products, external pods and sensors. Support
long cables at least every 50 cm and provide adequate strain relief for connection points.
• Power supply to be within 1000 mm of each CardioWall. CardioWall should be connected to the mains
power supply by a qualied operative.
• To prevent electric shock, keep all electric components away from contact with water.
• IMPORTANT: Take anti-static precautions.
• The units must be mounted to a at/level construction capable of supporting its weight and gameplay.
(Uneven walls and surfaces make alignment and tting very difcult.)
• The wall area for installation will need to exceed the width and height of the CardioWall (refer to Sys-
tem Specications) plus an additional 10 cm of clear space around each edge. If two CardioWalls are
being positioned side-by-side, leave a gap of 150 cm - 300 cm.
• Typical suitable construction would be block built, portal frame with structural inlls or brick built.
• Alternatively, mount onto 18 mm plywood (12 mm minimum) mechanically mounted to a steel frame-
work (50 mm box minimum). Preferably, the plywood should be painted prior to installation.
• Adequate holes will need to be cut during installation to provide clearance for cable access to rear if
required.
• Do not x to plasterboard faced partition. Avoid stud walls or unsupported portal inlls.
Structure:
Section 2 –1
Fixings:
• The manufacturer will supply xings.
© Rugged Interactive 2019
CardioWall Compact Installation and Instruction Manual: Section 2 – Installation
Section 2 –2
• 3 m of ‘mini’ box trunking to secure the power cable.
(CardioWalls are supplied, unless otherwise requested, with a power adaptor cable that extends 1000
mm from the base of the CardioWall.)
• Cleaning cloth and gentle cleaning spray.
• Mount to a desirable level, depending on primary user group.
• Recommended height for CardioWall Compact: 300 - 780 mm above ground level.
• Keep out of direct sunlight; bright will reduce visibility
• Area clear in front of the CardioWall: 200 cm minimum.
• Instruction / training carried out by an appropriate instructor to all new users.
• A waiting / spectating area positioned nearby is advised.
• A Rugged Interactive leaderboard to go with each unit is highly recommended.
Suggested Extras:
IF YOU ARE IN ANY DOUBT, CALL RUGGED INTERACTIVE DIRECTLY ON +44 (0) 1726 833 882.
• Use hex-headed screws of 50-70 mm length (2”) x M10 for a plywood structure.
• Use Rawl Plugs (plastic wall plugs) if mounted to a solid block or brick wall.
• 10 x 35 ‘penny’ washers to spread the load at each bolt head are recommended.
• All xings must be tight and secure.
• A spirit level – to check oor and CardioWall are level.
• An industrial vacuum cleaner, a dustpan and brush.
• Set of drills: An SDS impact drill, a cordless drill – with torque adjuster to avoid over-tightening of
screws.
• A set of No.2 pozi bits.
• A socket set.
Possible Equipment:
Installation Heights:
Other Recommendations:
CardioWall Compact Installation and Instruction Manual: Section 2 – Installation
Section 2 –3
CardioWall Compact Installation
2 people required: one to hold the main body in
place; one to ensure it is level.
See Installation Heights (Section 1)
01
2 people required: one to hold the main body in
place; one to clearly mark holes x 4
02
Drill holes and insert mountings x 4.
03
X X
X X
© Rugged Interactive 2019
CardioWall Compact Installation and Instruction Manual: Section 2 – Installation
Section 2 –4
CardioWall Compact Installation (cont.)
04
05
Position appropriate xings by hand in all corners
and tighten with a tool x 4, checking level
Position xing covers and push
in to place with a hammer x 4.
© Rugged Interactive 2019
06
Attach suitable plug to lead with 5A fuse.
To be performed by a qualied operative.
Rugged Interactive
1 Callywith Court,
Callywith Gate Ind. Est.,
Bodmin, Cornwall
PL31 2RQ
+44 (0) 1726 981 123
www.rugged-interactive.co.uk
hello@rugged-interactive.co.uk#
Section 3 - 1
©Rugged Interactive 2019
Section 3 – Pod LED Replacement
3.1 Removing the Pod LEDs
Read this manual before
removing or installing any pods.
Pod LED boards are secured
behind the full front plate.
Remove this and then access
the Pod LED boards.
Retain all screws & washers.
NOTE:
To remove the CAT5
cables, release the clip
on the connector
CAREFULLY.
1. Remove the front panel 2. Remove mounting screws
3. Remove CAT5 Cable
4. Replace Pod LED board and test.
5. Replace in moulding and
remount front panel
Table of contents
Other Rugged Interactive Sport & Outdoor manuals
Rugged Interactive
Rugged Interactive DodgeAttack User manual
Rugged Interactive
Rugged Interactive TrailBlazer Traverse HEX Quick guide
Rugged Interactive
Rugged Interactive CardioWall Outdoor Portrait User manual
Rugged Interactive
Rugged Interactive CardioWall User manual
Rugged Interactive
Rugged Interactive WallRider User manual
Rugged Interactive
Rugged Interactive TrailBlazer Traverse Quick guide
Rugged Interactive
Rugged Interactive SkyPods User manual
Rugged Interactive
Rugged Interactive SkyClimb User manual
Rugged Interactive
Rugged Interactive High-9 Quick guide
Rugged Interactive
Rugged Interactive BattleBaskets User manual
