Raymarine ST5000+ User guide
Distributed by
Any reference to Raytheon or
RTN in this manual should be
interpreted as Raymarine.
The names Raytheon and RTN
are owned by the
Raytheon Company.
ST5000 Plus
SailPilot
Owner’s
Handbook
Document number: 81136-4
Date: May2001
136_3cov.p65 14/06/99, 10:161
136_3cov.p65 14/06/99, 10:162
Preface i
Rudder Reference Unit
ST5000 Plus
Control Head
Boat's Electrical
Distribution Panel
SailPilot
Fluxgate Compass SeaTalk Instruments
D3559-1
136_3pre.p65 14/06/99, 10:161
ii ST5000 Plus SailPilot Owner’s Handbook
Raymarine,aspartofitscommitmenttocontinuousimprovementandupdating,reserves the
right to make changes, without prior notice, to the equipment, equipment specifications, and the
instructions contained within this handbook.
To the best of our knowledge, the information contained within this handbook was correct
asitwenttopress.
Agreatdealofcarehasbeentakentoensurethatthishandbook is as accurate as possible. However,
liabilitycannot be accepted forinaccuraciesor omissions.
Autohelmand SeaTalk are registeredtrademarksof Raymarine Ltd.
WindTrim,AutoTack, AutoTrim, Auto Seastate, Autoadapt and Auto Dockside are trademarks of
Raymarine Ltd.
Copyright © Raymarine Ltd 2001.
136_3pre.p65 14/06/99, 10:162
Preface iii
Contents
Preface....................................................................................ix
How this handbook is organised ......................................ix
Warranty........................................................................... ix
Safety information............................................................. x
EMC conformance ............................................................ x
Chapter 1: Introduction ......................................................... 1
1.1 Overview ..................................................................... 1
1.2 Extended systems ........................................................ 2
1.3 Specification ............................................................... 2
Chapter 2: Basic Operation ................................................... 3
2.1 Key functions ..............................................................3
2.2 Display layout ............................................................. 4
2.3 Using Auto mode ........................................................ 5
Engaging the Autopilot (Auto) .................................... 5
Disengaging the autopilot (Standby) to return to hand
steering ........................................................................ 5
Changing course in Auto mode ................................... 6
Dodging obstacles in Auto mode ................................6
Returning to the previous locked heading ................... 7
Automatic tack (AutoTack) ......................................... 7
AutoTack to starboard ........................................... 8
AutoTack to port.................................................... 8
Off course alarm .......................................................... 8
Operating hints ............................................................ 9
Making major course changes ............................... 9
Course changes under autopilot control ................ 9
Gusty conditions .................................................. 10
2.4 Display and keypad illumination .............................. 10
2.5 Data pages................................................................. 11
136_3pre.p65 14/06/99, 10:163
iv ST5000 Plus SailPilot Owner’s Handbook
Chapter 3: Advanced Operation ......................................... 13
3.1 Operation in Track mode .......................................... 13
Initiating Track mode ................................................ 13
Automatic acquisition .......................................... 14
Manual acquisition .............................................. 15
Cross track error ........................................................ 16
Tidal stream compensation........................................ 16
Waypoint arrival and advance ................................... 17
Arrival.................................................................. 17
Skipping a waypoint – SeaTalk navigators only .. 18
Advance ............................................................... 18
Dodges....................................................................... 18
Initiating a dodge manoeuvre .............................. 18
Cancelling a dodge manoeuvre............................ 18
Safety......................................................................... 18
Position confirmation at the start of a passage .... 19
Verifying computed positions .............................. 19
Plot frequency...................................................... 19
Setting waypoints................................................. 19
General ................................................................ 19
3.2 Operation in Vane mode (WindTrim) ....................... 19
Selecting Vane mode ................................................. 20
Adjusting the locked wind angle ............................... 20
Returning to the previous apparent wind angle ......... 21
Dodges....................................................................... 21
Wind shift alarm ........................................................ 21
Using AutoTack in Vane mode.................................. 22
Operating hints .......................................................... 23
3.3 Adjusting autopilot performance .............................. 23
Changing the response level (AutoSeastate) .............23
Changing the rudder gain .......................................... 24
136_3pre.p65 14/06/99, 10:164
Preface v
3.4 Alarms....................................................................... 24
SeaTalk failure ..................................................... 24
Off course ............................................................ 24
Wind shift ............................................................ 25
Large cross track error ......................................... 25
Drive stopped....................................................... 25
Data not received ................................................. 25
Waypoint advance................................................ 26
Low battery .......................................................... 26
Watch alarm ......................................................... 26
Shallow alarm ...................................................... 27
Man overboard (MOB)........................................ 27
Chapter 4: Customising the ST5000 Plus ........................... 29
4.1 User setup ................................................................. 29
Compass deviation correction ................................... 31
Deviation display....................................................... 31
Heading alignment .................................................... 31
Heading mode ........................................................... 31
Bar selection .............................................................. 31
Data pages ................................................................. 32
4.2 Dealer setup .............................................................. 34
Calibration lock ......................................................... 36
Pilot type ................................................................... 36
Rudder gain ............................................................... 37
Response ................................................................... 37
Turn limit................................................................... 37
Align rudder (Rudder Offset) .................................... 37
Rudder limit............................................................... 37
Off Course alarm ....................................................... 38
AutoTack angle ......................................................... 38
AutoTrim ................................................................... 38
136_3pre.p65 14/06/99, 10:165
vi ST5000 Plus SailPilot Owner’s Handbook
Drive type .................................................................. 39
Variation .................................................................... 39
AutoAdapt ................................................................. 39
Latitude ..................................................................... 40
Rudder damping ........................................................ 40
Cruise speed .............................................................. 40
Chapter 5: Installation ........................................................ 41
5.1 Planning the installation............................................ 41
EMC installation guidelines ...................................... 41
Suppression Ferrites ................................................. 42
Connections to other equipment .......................... 42
Cabling ...................................................................... 42
5.2 Control head.............................................................. 43
Siting ......................................................................... 43
Mounting procedure .................................................. 43
Surface mounting ................................................. 44
Flush mounting .................................................... 45
Cable connectors ....................................................... 46
Power supply connection........................................... 46
Connection to the SeaTalk bus .................................. 47
SeaTalk Cables .................................................... 47
Cable Types ......................................................... 48
Typical SeaTalk Cabling......................................48
5.3 Fluxgate compass...................................................... 48
Mounting location for steel-hulled vessels................ 49
Installing the fluxgate compass ................................. 50
Cabling ...................................................................... 51
5.4 Rudder reference transducer ..................................... 51
Mounting position ..................................................... 51
Control dimensions.................................................... 52
Installing the rudder reference transducer ................. 52
Cabling ...................................................................... 53
136_3pre.p65 14/06/99, 10:166
Preface vii
5.5 SailPilot linear drive installation............................... 54
Mounting the drive unit ............................................. 55
Drive unit cabling ...................................................... 56
5.6 NMEA interface........................................................ 57
Cabling ...................................................................... 57
NMEA data transmission to other equipment ........... 57
Data formats .............................................................. 58
Transmission of NMEA data on SeaTalk ............ 58
Chapter 6: Post Installation Procedures ........................... 59
6.1 Functional test ........................................................... 59
Switch on ................................................................... 59
Operating sense ......................................................... 60
Navigation interface (GPS, Decca, Loran)................ 60
Wind transducer interface ......................................... 61
SeaTalk interface ....................................................... 61
6.2 Dockside procedure .................................................. 62
6.3 Initial sea trial ........................................................... 62
EMC conformance .................................................... 62
Overview ................................................................... 62
Automatic compass deviation correction .................. 63
Further heading alignment adjustment ...................... 67
Checking autopilot operation .................................... 67
Checking the rudder gain .......................................... 67
Chapter 7: Maintenance ...................................................... 71
General ...................................................................... 71
Servicing and Safety.................................................. 71
Advice ....................................................................... 71
Chapter 8: Fault Finding ...................................................... 73
Index ...................................................................................... 75
136_3pre.p65 14/06/99, 10:167
Other manuals for ST5000+
2
This manual suits for next models
1
Table of contents
Other Raymarine Marine Equipment manuals
Raymarine
Raymarine ST70 Instrument User manual
Raymarine
Raymarine SeaNet-Alarm User manual
Raymarine
Raymarine ST60 Tridata User manual
Raymarine
Raymarine Viewable Marine Displays User manual
Raymarine
Raymarine ST60+ SPEED INSTRUMENT User manual
Raymarine
Raymarine SmartPilot ST6001 User manual
Raymarine
Raymarine SmartPilot SPX-10 User manual
Raymarine
Raymarine ST60 Tridata User guide
Raymarine
Raymarine SmartPilot X5 User manual
Raymarine
Raymarine A series User manual
Raymarine
Raymarine RayPilot 650 Professional System Quick start guide
Raymarine
Raymarine ST60 Tridata User guide
Raymarine
Raymarine P70 User manual
Raymarine
Raymarine ST7001+ User manual
Raymarine
Raymarine AXIOM Assembly instructions
Raymarine
Raymarine FLUXGATE COMPASS User manual
Raymarine
Raymarine Maxiview ST80 User guide
Raymarine
Raymarine Evolution EV-1 User manual
Raymarine
Raymarine hsb2 PLUS Series User guide
Raymarine
Raymarine ST40 Speed User guide
Popular Marine Equipment manuals by other brands
GUIDANCE MARINE
GUIDANCE MARINE 20- Series Installer's guide
olympia electronics
olympia electronics ΒS-531/1/MAR quick start guide
Sonic
Sonic 2024 Operation manual
Quicksilver
Quicksilver 88688A25 Installation, operation and maintenance instructions
Furuno
Furuno Navtex NX-700-A Operator's manual
olympia electronics
olympia electronics ΒS-532/WP quick start guide