Powerware 5115 User manual

5115

USER’S GUIDE

Tower UPS

500–1400 VA

www.powerware.com

Class B EMC Statements

FCC Part 15

NOTE This equipment has been tested and found to comply with the limits for a Class B digital device,

pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against

harmful interference in a residential installation. This equipment generates, uses and can radiate radio

frequency energy and, if not installed and used in accordance with the instructions, may cause harmful

interference to radio communications. However, there is no guarantee that interference will not occur in

a particular installation. If this equipment does cause harmful interference to radio or television

reception, which can be determined by turning the equipment off and on, the user is encouraged to try to

correct the interference by one or more of the following measures:

쑺Reorient or relocate the receiving antenna.

쑺Increase the separation between the equipment and the receiver.

쑺Connect the equipment into an outlet on a circuit different from that to which the receiver is

connected.

쑺Consult the dealer or an experienced radio/TV technician for help.

ICES-003

This Class B Interference Causing Equipment meets all requirements of the Canadian Interference

Causing Equipment Regulations ICES-003.

Cet appareil numérique de la classe B respecte toutes les exigences du Reglement sur le matériel

brouilleur du Canada.

Powerware and ABM are registered trademarks of Powerware Corporation.

document may be reproduced in any way without the express written approval of Powerware

Corporation.

Requesting a Declaration of Conformity

Units that are labeled with a CE mark comply with the following harmonized standards and EU

directives:

쑺Harmonized Standards: EN 50091-1-1 and EN 50091-2; IEC 60950 Third Edition

쑺EU Directives: 73/23/EEC, Council Directive on equipment designed for use within certain voltage

limits

93/68/EEC, Amending Directive 73/23/EEC

89/336/EEC, Council Directive relating to electromagnetic compatibility

92/31/EEC, Amending Directive 89/336/EEC relating to EMC

The EC Declaration of Conformity is available upon request for products with a CE mark. For copies of

the EC Declaration of Conformity, contact:

Powerware Corporation

Koskelontie 13

FIN-02920 Espoo

Finland

Phone: +358-9-452 661

Fax: +358-9-452 665 68

Special Symbols

The following are examples of symbols used on the UPS to alert you to important

information:

Risk of Electric Shock

Do Not Open Cover

CAUTION

CAUTION To reduce the risk of electric shock,

Do not remove cover (or back)

No user-serviceable parts inside

Refer servicing to the factory

RISK OF ELECTRIC SHOCK - Indicates that a risk of electric shock is present and the

associated warning should be observed.

CAUTION: REFER TO OPERATOR’S MANUAL - Refer to your operator’s manual

for additional information, such as important operating and maintenance instructions.

SAFETY EARTHING TERMINAL - Indicates the primary safety ground.

LOAD ON/OFF - Press the button with this symbol to energize the output receptacles

(µindicator illuminates) or to de-energize the output receptacles (µindicator is

off).

RJ-45 RECEPTACLE - For 230V units only: this receptacle provides network interface

connections. Do not plug telephone or telecommunications equipment into this

receptacle.

This symbol indicates that you should not discard the UPS or the UPS batteries in the

trash. The UPS may contain sealed, lead-acid batteries. Batteries must be recycled.

Powerware®5115 Tower UPS (500–1400 VA) User’s Guide S05146640 Rev C www.powerware.com

Table of Contents

1 Powerware 5115 – One of the Best! 1...........................

2 Safety Warnings 3............................................

3 Installation 17.................................................

Inspecting the Equipment 17.................................................

Installing the UPS 17........................................................

UPS Rear Panels 19.........................................................

4Operation 23..................................................

Turning the UPS On 23......................................................

Starting the UPS on Battery 23.............................................

Turning the UPS Off 23.....................................................

Standby Mode 24..........................................................

UPS Front Panel 24.........................................................

Initiating the Self-Test 24....................................................

5 Additional UPS Features 25.....................................

Voltage Configuration 25....................................................

Communication Options 26..................................................

USB Port 26.............................................................

DB-9 Communication Port 27..............................................

Network Transient Protector 28..............................................

6 UPS Maintenance 29...........................................

UPS and Battery Care 29....................................................

Storing the UPS and Batteries 29...........................................

Replacing Batteries 30......................................................

Testing New Batteries 33....................................................

Recycling the Used Battery 34................................................

Table of Contents

ii Powerware®5115 Tower UPS (500–1400 VA) User’s Guide S05146640 Rev C www.powerware.com

7 Specifications 35..............................................

8 Troubleshooting 39............................................

Audible Alarms and UPS Conditions 39........................................

Silencing an Audible Alarm 39.............................................

Site Wiring Fault (120V Models Only) 40.....................................

Service and Support 43.....................................................

9 Two-Year Limited Warranty 44..................................

10 Extended Ten-Year Pro-Rated Limited Warranty 46...............

Powerware®5115 Tower UPS (500–1400 VA) User’s Guide S05146640 Rev C www.powerware.com

Chapter 1 Powerware 5115 – One of the Best!

The Powerware®5115 uninterruptible power system (UPS) protects your

sensitive electronic equipment from basic power problems such as power

failures, power sags, power surges, brownouts, and line noise.

Power outages can occur when you least expect it and power quality can

be erratic. These power problems have the potential to corrupt critical

data, destroy unsaved work sessions, and damage hardware — causing

hours of lost productivity and expensive repairs.

With the Powerware 5115, you can safely eliminate the effects of power

disturbances and guard the integrity of your equipment. The Powerware

5115’s flexibility to handle an array of network devices makes it the

perfect choice to protect your LANs, servers, workstations, and other

electrical equipment.

Figure 1. The Powerware 5115 UPS

Powerware 5115 – One of the Best!

2Powerware®5115 Tower UPS (500–1400 VA) User’s Guide S05146640 Rev C www.powerware.com

Providing outstanding performance and reliability, the Powerware 5115’s

unique benefits include the following:

쑺Advanced Battery Management (ABM®) technology doubles battery

service life, optimizes recharge time, and provides a warning before

the end of useful battery life.

쑺Buck and Boost voltage regulation ensures consistent voltage to your

load by correcting voltage fluctuations.

쑺Hot-swappable batteries simplify maintenance by allowing you to

replace batteries safely without powering down the critical load.

쑺Start-on-battery capability allows you to power up the UPS even if

utility power is not available.

쑺Advanced power management with the Powerware Software Suite CD

for graceful shutdowns and power monitoring.

쑺Two standard communication options with a USB port and DB-9 serial

port.

쑺Network Transient Protector guards your network communications

equipment from surges. Low voltage models can also protect

modems, fax machines, or other telecommunications equipment.

쑺The Powerware 5115 is backed by worldwide agency approvals.

Powerware®5115 Tower UPS (500–1400 VA) User’s Guide S05146640 Rev C www.powerware.com

Chapter 2 Safety Warnings

Read the following precautions before you install the UPS.

IMPORTANT SAFETY INSTRUCTIONS

SAVE THESE INSTRUCTIONS

This manual contains important instructions that you should follow during

installation and maintenance of the UPS and batteries. Please read all

instructions before operating the equipment and save this manual for future

reference.

DANGER

This UPS contains LETHAL VOLTAGES. All repairs and service should be

performed by AUTHORIZED SERVICE PERSONNEL ONLY.ThereareNO USER

SERVICEABLE PARTS inside the UPS.

WARNING

쑺This UPS contains its own energy source (batteries). The output receptacles

may carry live voltage even when the UPS is not connected to an AC supply.

쑺For 220–240V models, the output receptacles may remain electrically live. If

the input power source in your application is wired line-to-neutral (as in

most European applications), the voltage to the output receptacles is 0V.

With line-to-line input wiring, the voltage to the output receptacles is

110–120V (measured from line-to-ground or line-to-neutral, depending on

the UPS wiring).

쑺Do not remove or unplug the input cord when the UPS is turned on. This

removes the safety ground from the UPS and the equipment connected to

the UPS.

쑺To reduce the risk of fire or electric shock, install this UPS in a temperature

and humidity controlled, indoor environment, free of conductive

contaminants. Ambient temperature must not exceed 40GC (104GF). Do not

operate near water or excessive humidity (95% max).

쑺To comply with international standards and wiring regulations, the total

equipment connected to the output of this UPS must not have an earth

leakage current greater than 1.5 milliamperes.

Safety Warnings

4Powerware®5115 Tower UPS (500–1400 VA) User’s Guide S05146640 Rev C www.powerware.com

CAUTION

쑺The wall outlet must be within 2 meters of the equipment and accessible to

the operator.

쑺Batteries can present a risk of electrical shock or burn from high

short-circuit current. The following precautions should be observed:

1) Remove watches, rings, or other metal objects; 2) Use tools with insulated

handles; 3) Do not lay tools or metal parts on top of batteries; 4) Disconnect

charging source prior to connecting or disconnecting battery terminals.

쑺Proper disposal of batteries is required. Refer to your local codes for

disposal requirements.

쑺Never dispose of batteries in a fire. Batteries may explode when exposed to

flame.

쑺Never open or mutilate batteries. Released electrolyte is harmful to the skin

and eyes, and may be extremely toxic.

쑺Replace batteries with the same number and type of batteries as originally

installed in the UPS.

Other manuals for 5115

Table of contents

Other Powerware UPS manuals

Powerware

Powerware 9335 User manual

Powerware

Powerware 5125 9910 P18 User manual

Powerware

Powerware 9355 User manual

Powerware

Powerware 300 VA User manual

Powerware

Powerware 9305 HS Series Operating manual

Powerware

Powerware 9910 p Series User manual

Powerware

Powerware 9305 Operating manual

Powerware

Powerware 5115 User manual

Powerware

Powerware 5140 User manual

Powerware

Powerware 3110 User manual

Powerware

Powerware Uninterruptible Power Supply User manual

Powerware

Powerware 9315 User manual

Powerware

Powerware PW5110 User manual

Powerware

Powerware 9170+ User manual

Powerware

Powerware 9390 User manual

Powerware

Powerware Plus 80 Instruction Manual

Powerware

Powerware 9305 Operating manual

Powerware

Powerware 9315 User manual

Powerware

Powerware 5125 User manual

Powerware

Powerware 9125 PowerPass User manual

Powerware

Powerware 5105 User manual

Powerware

Powerware 5140 User manual

Powerware

Powerware 5125 User manual

Powerware

Powerware UPS 1000 - 2200 User manual

Popular UPS manuals by other brands

Pylontech

Pylontech Victron & Pylontech US5000 manual

Tecnoware

Tecnoware EVO DSP PLUS MM 6.8 user manual

Mecer

Mecer ME-1000-WTU user manual

Mustek

Mustek PowerMust 530(B) Plus Startup manual

Emerson

Emerson Liebert NXL series Operation and maintenance manual

MAKELSAN

MAKELSAN BOXER SERIES user manual

Block

Block PC-0524-400-0 manual

CyberPower

CyberPower CP585LCD user manual

Eaton

Eaton 3S Advanced user's guide

CyberPower

CyberPower Office Tower Series UPS 1000 user manual

CyberPower

CyberPower BM100 quick start guide

Best Power

Best Power 610 quick start guide

Best Power

Best Power Unity/I UT3K user manual

Mustek

Mustek PowerMust 400 Offline user manual

Xantrex

Xantrex Trace 512 UR-UPS owner's manual

Forza

Forza SL-1501UL user manual

LEGRAND

LEGRAND keor 310081 quick start guide

ABB

ABB Conceptpower DPA 500 operating manual