Pentair SHURFLO User manual

WATER PURFICATION 911-585 REV. E 1

SHURFLO® LO-FLO 105 SERIES RV PUMPS

INSTALLATION MANUAL

SHURFLO Lo-Flo 105 Series RV pumps are rugged, lightweight, compact and provide the ability to self-prime and run dry.

Standard features include a pressure demand switch, built in 3/8” hose barb ports, ﬂexible mounting feet, splash proof motor,

and thermal protector. All with the security that comes with a UL Recognized Component.

INSTALLATION

SHURFLO Lo-Flo 105 Series RV pumps are self-priming and can be located up to 2.5

feet above the water level. Horizontal and vertical prime vary depending on the ﬂuid

viscosity and pump conﬁguration. The pump can be at the same level or below the

tank.

❚ The pump should be located in an area that is dry and properly ventilated to pre-

vent heat build-up.

❚ Use 50-mesh strainer minimum at the inlet side of the pump. Use ﬂexible hose on

inlet.

❚ The pump can be mounted in any position. However, if mounting the pump verti-

cally the pump head should be in the down position so that in the event of a leak,

ﬂuid will not enter the motor.

❚ 12 Volt pump must be provided with a 5-amp fuse.

❚ Recommended wire size is 16 gauge (1.3 mm) or larger wire as determined by volt-

age drop. Negative (-) must be connected to a known ground. Ground wire must be

the same (gauge/mm) as the positive.

TROUBLESHOOTING

PUMP WILL NOT START

√ For correct voltage (+10%) and

electrical connections

√ Fuse or breaker

√ Pressure switch operation and

correct voltage at switch

√ Rectiﬁer or motor for open or

grounded circuit

√ For locked drive assembly

PUMP WILL NOT PRIME

(No Discharge/Motor Runs)

√ Strainer for debris

√ Inlet/Outlet tube severely restricted

(kinked)

√ Inlet /Outlet valves for debris or

swelling

PUMP WILL NOT SHUT-OFF

√ Output line closed and no leaks

√ For air trapped in outlet line or

pump head

√ For correct voltage to pump

√ Debris in pump Inlet/Outlet valves

√ For loose drive assembly or pump

head screws

√ Pressure switch operation/adjust-

ment

LEAKS FROM PUMP HEAD OR SWITCH

√ For loose screws at switch or pump

head

√ Switch diaphragm ruptured or

pinched

√ For punctured diaphragm if ﬂuid is

present at drain holes

To Faucet

City Water

Check Valve

Alternate Plumbing

for City Water Entry

From Pump

“T” Fitting

RED(+)

PUM P

SWITCH

BLACK(-)

FUSE BATTERY

50 Mesh Strainer Required if using SHURFLO P/N 170-06X-00

A 1/2” to 3/8” Barb splicer is required.

Water Tank

Plumbing Systems can vary.

Consult SHURFLO for detailed

information.

WATER PURIFICATION

3545 HARBOR GATEWAY SOUTH, SUITE 103, COSTA MESA, CA 92626, (800) 854-3218 WWW.SHURFLO.COM

All Pentair trademarks and logos are owned by Pentair, Inc. All other brand or product names are trademarks or registered marks of their respective owners.

Because we are continuously improving our products and services, Pentair reserves the right to change speciﬁcations without prior notice.

Pentair is an equal opportunity employer.

PRODUCT SPECIFICATIONS

Model Number: 105 Series

Pump Design: Positive Displacement Pump

Motor: Placement Magnet, 11-262-00

Voltage: 12 VDC

Pressure Switch: Factory Set: 30 PSI Shut-off, Turn-on 25+/- 5 PSI

Liquid Temperature: 100° Max F [43° C]

Prime: Self Priming up to 2.5 ft. vertical

Ports: 3/8" Barb

Net Weight: 1.27 lbs.

Duty Cycle: Intermittnet

Max Amps: 105-003, 2.5 Amps @ 30 PSI

MATERIALS OF CONSTRUCTION

Motor Housing: Nylon

Plastic: Polypropylene

Valves: EPDM

Diaphragm: Santoprene

Fasteners: Zinc Plated /

Stainess Steel

#10 Screw Mounting Hole

3/8” Hose Barb Port

Pressure Switch

18 AWG Red Positive

18 AWG Black Negative

5.01.70”1.55”3.94”

2.45”

1.87”

2.25”

3.20”

6.82”

FLOW: GPM [LPM]

0.30

[1.14]

0.65

[2.46]

1.00

[3.79]

[2.1]

[1.4]

[0.7]

PRESSURE: PSI [BAR]

Table of contents

Other Pentair Water Pump manuals

Pentair

Pentair 1800 Series Operating instructions

Pentair

Pentair Sta-Rite DMC Series User manual

Pentair

Pentair HYPRO 9260 Series User guide

Pentair

Pentair Hydromatic P33A1 Manual

Pentair

Pentair PARTS20 FPHP25 User manual

Pentair

Pentair HYPRO 9300 Series Use and care manual

Pentair

Pentair JUNG PUMPEN SIMER 5 User manual

Pentair

Pentair Peristaltic pump User manual

Pentair

Pentair Multinox VE+ Series User manual

Pentair

Pentair S50HTPC1 Guide

Pentair

Pentair Hydromatic HPG200V Troubleshooting guide

Pentair

Pentair Berkeley LTHH Series User manual

Pentair

Pentair Jung Pumpen COMPLI 300 E User manual

Pentair

Pentair Myers 4VL Manual

Pentair

Pentair Myers 3VX Series Manual

Pentair

Pentair AURORA INTELLIBOOST 7710 Manual

Pentair

Pentair Berkeley SSHM-2 User manual

Pentair

Pentair Myers SHA Series Manual

Pentair

Pentair Hydromatic HCU Series User manual

Pentair

Pentair HYPRO 9700 Series User manual

Pentair

Pentair STA-RITE SE370 User manual

Pentair

Pentair Fairbanks nijhuis 2800 Installation and operating instructions

Pentair

Pentair NOCCHI SSH User manual

Pentair

Pentair US User manual

Popular Water Pump manuals by other brands

Neptun

Neptun NPHW 5500 operating instructions

Sensidyne

Sensidyne Gilian BDX-II Operation & service manual

Draper

Draper 47808 instructions

Trolla

Trolla 12820 manual

Sunfab

Sunfab SVH Series installation guide

WilTec

WilTec 50740 Operation manual

Fieldmann

Fieldmann FVC 5015 EK user manual

Everbilt

Everbilt EFSUB5-122HD Use and care guide

Graco

Graco Husky 3300e manual

esotec

esotec 101018 operating manual

moyno

moyno 2000 CC Service manual

Becker

Becker BASIC VASF 2.80/1-0.AC230 operating instructions

Sykes AmeriPumps

Sykes AmeriPumps GP100M Operation and maintenance instructions

DUROMAX

DUROMAX XP WX Series user manual

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 operating instructions

Franklin Electric

Franklin Electric IPS Installation & operation manual

Xylem

Xylem e-1532 Series instruction manual

Milton Roy

Milton Roy PRIMEROYAL instruction manual