Panasonic NV-DS77 User manual

ORDERNO. VMD9807038C2

Digital VideoCamera/Recorder

NV-DS77

Q1-MECHANISM

EG/B

SPECIFICATIONS

Unauthorizedcopying and distribution isaviolation oflaw.

1. INTRODUCTION

Note 1:

These movie camera uses AC AdaptorVW-AD7E/B/A.

This Service Manual forAC Adaptoris separate volume.

OrdernumberforVW-AD7E/B/A VMD9807039C8

Note 2:

This service manual does not containthe following information because of the impossibilityof

servicing atcomponent level.

1. Schematicdiagramand C.B.A. layoutofVTRMainC.B.A.

2. Parts list for individual parts ofVTRMainC.B.A.

3. Explodedviewand parts list for individual parts ofMechanism.

Whena partreplacement is requiredforrepairing VTR MainC.B.A. and/ormechanismblock,

replace the assemblyparts (VTR MainC.B.A. and/orMechanismunit).

The following circuits are containedinVTR MainC.B.A.

1. Process Circuit

2. VideoCircuit(1,2)

3. Control Circuit

4. DriveCircuit

5. MainConnection Circuit

6. Digital I/FCircuit

2. CAUTIONFORACCORD (VJA0940 TYPE)

2.1. Information for Your Safety

IMPORTANT

Yourattention is drawnto the factthatrecording of pre-recordedtapes ordiscs orother

publishedorbroadcastmaterial mayinfringe copyright laws.

WARNING

Toreduce therisk offireor shock hazard, do notexpose this

equipmenttorainor moisture.

CAUTION

Toreduce therisk offireor shock hazard and annoying

interference, use therecommendedaccessories only.

FOR YOUR SAFETY

DONOTREMOVE THEOUTER COVER

Toprevent electric shock, do not remove the cover. Nouserserviceable parts inside. Refer

servicing to qualifiedservice personnel.

2.2. Caution for ACMainsLead

Foryoursafety, please readthe following textcarefully.

This appliance is suppliedwith a mouldedthree-pinmains plug foryoursafetyand

convenience.

A5-ampere fuse is fittedinthis plug.

Shouldthe fuse needto be replacedplease ensure thatthe replacement fuse has a rating of 5

amperes and itis approvedbyASTAorBSI to BS1362

Check forthe ASRAmark orthe BSI mark on the bodyof the fuse.

Ifthe plug contains a removable fuse coveryou mustensure thatitis refittedwhenthe fuse is

replaced.

Ifyou lose the fuse cover, the plug mustnot be useduntil a replacement coveris obtained.

Areplacement fuse covercanbe purchasedfrom yourlocal Panasonic Dealer.

Ifthe fittedmouldedplug is unsuitable forthe socketoutletinyourhome thenthe fuse should

be removedand the plug cut off and disposedof safety.

There is a dangerof severe electrical shock ifthe cut off plug is insertedinto any13-ampere

socket.

Ifa newplug is to be fittedplease observe the wiring code as shownbelow.

Ifinanydoubt, please consulta qualifiedelectrician.

2.2.1. IMPORTANT

The wires inthis mains leadare colouredinaccordance with the following code:

Blue Neutral

Brown Live

As the colours of the wires inthe mains leadof this appliance maynot correspond with the

colouredmarkings identifying the terminals inyourplug, proceedas follows:

The wire whichis colouredBLUEmustbe connectedto the terminal inthe plug whichis

markedwith the letterN orcolouredBLACK.

The wire whichis colouredBROWN mustbe connectedto the terminal inthe plug whichis

markedwith the letterLorcolouredRED.

Underno circumstances shouldeitherof these wires be connectedto the earth terminal of the

three pinplug, markedwith the letterEorthe Earth Symbol.

2.2.2. Beforeuse

remove the ConnectorCoveras follows.

2.2.3. Howtoreplace theFuse

1. RemovetheFuse Coverwithascrewdriver.

2. Replace thefuse and attachtheFuse cover.

3. SERVICE INFORMATION

3.1. Service Extension Cables

No. PartNo. Pin PartName Connection Q'ty

Remarks

1VFK1443 18 FlatCable FP2201 (VTR Main)-Mecha. Cap. 1

2VFK1443 18 FlatCable FP2203 (VTR Main)-Mecha. Flex. 1

3VFK1440 10 FlatCable FP2202 (VTR Main)-Mecha. Cyl. 1

4VFK1284 24 FlatCable FP3201 (VTR Main)-HeadAmp 1

5VFK1441 8 FlatCable FP2204 (VTR Main)-Mecha. Flex. 1

6VFK1452 17 FlatCable FP4001 (VTR Main)-FP4801 (Mic Unit) 1

7VFK1453 40 FlatCable PP202 (Camera)-PS202 (CDS/AGC) 1

8VFK1442 21 FlatCable FP701 (Camera)-Lens Flex. 1

9VFK1437 110 FlatCable PS3004 (VTR Main)-PP702 (Camera) 1

10 VFK1443 18 FlatCable FP6002 (VTR Main)-Top Operation Unit 1

11 VFK1440 10 FlatCable FP1002 (Power)-S/SPowerFlex. 1

12 VFK1443 18 FlatCable FP603 (Camera)-EVF 1

13 VFK1438 80 FlatCable PP1001 (VTR Main)-PS1001 (Power) 1

14 VFK1439 30 FlatCable PP710 (Camera)-PS1002 (Power) 1

15 VFK1439 30 FlatCable PP3002 (VTR Main)-PS3002 (Multi Jack) 1

3.1.1. PinArrangementfor Extension Cable

3.2. Service Position

Fig.T1

3.3. Preparation for Electrical Adjustment

Remove Screwand EVR Coverwhichis locatedon the Side Case Unitas follows.

<Fig.E1>

Thenconnectthe following cables as showninFig. E2.

PartNo. PartName Q'ty Remarks

VFA0272 232C (M3)I/FCable 1

VFK1308E Measuring Board 1

VFK1309 EVR Connector

Board 1

VFK1317 30 PinFlatCable 2

VJA0941 DC Output Cable 1 ForAC

Adapter

VFK1164TAR3A

Setup Ring ( 30.5

mm) 1 For

Collimator

<Fig.E2>

<Fig.E3>

3.4. Service Mode

Whenundesirable conditions occurred, the errorcode is displayedon the EVForLCD Monitor.

Also, the Camera LED is flashedaccording to the errorcode as follows.

DISPLAY CONDITION POWER OFF TIMING/ POWER LED FLASHING

TIMING

F01 T-Reel Lock After1 minute flashing the LED

F02 S-Reel Lock After1 minute flashing the LED

F03 Unloading Lock After1 minute flashing the LED

F04 Loading Lock After1 minute flashing the LED

F05 CylinderLock After1 minute flashing the LED

F31 Data Transmission Error Not turning OFF

F51 Focus MotorLock Not turning OFF / PowerLED is flashedat1 Hztiming

F52 Zoom MotorLock Not turning OFF / PowerLED is flashedat1 Hztiming

U10 DewDetection After18 seconds flashing the LED / PowerLED is flashed

timing

U11 HeadClogging Not turning OFF

3.5. Howtoreplace theLithium Battery

(Procedure)

1. RemovetheS/S PowerFlex. C.B.A. from GripCase Unit. (Referto

DisassemblyProcedures)

2. UnsoldertheLithium Battery"VL1220/1FC"and thenreplace the

newone. (See Fig. B1)

<Fig.B1>

Note:

The lithium batteryis a critical component (Type No.:VL1220/1FC ManufacturedbyPanasonic.)

/ Itmustneverbe subjectedto excessive heatordischarge. / Itmusttherefore onlybe fittedin

equipment designedspecificallyforits use. / Replacement batteries mustbe of the same type

and manufacture. / Theymustbe fittedinthe same mannerand location as the original battery,

with the correctpolaritycontacts observed. / Donot attempt to re-charge the oldbatteryorre-

use itforanyotherpurpose. / Itshouldbe disposedof inwaste products destinedforburial

ratherthanincineration.

4. GENERALDESCRIPTIONS

5. ADJUSTMENTPROCEDURES

5.1. DISASSEMBLE FLOWCHART

This flowchartindicates the disassemblysteps the cabinetparts, C.B.A. and MechanismUnitin

orderto access to items to be serviced. Whenreinstalling, performthe steps inthe reverse

order.

<Fig.F1>

5.2. DISASSEMBLY PROCEDURES

Flow-chartDisassemblyprocedure

No. Item/ Part Fig. Removal (Screw&

Other)

(1) Front Case

Unit Fig.1 Remove the DVCover

and GripBelt. / 1-

Screw(A)/ 1-Screw(B)

2-Screws (C)/ 2-

Screws (D)/ Unlock-----

Locking Tab

(2) Mic Unit Fig.2 3-Screws (E)/

DisconnectFP4801.

(3) Side Case

Unit Fig.3 1-Screw(F) / 7-Screws

(G) / 2-Screws (H)/ 1-

Screw(I)/ 1-Screw(J)

/ 2-Screws (K)/

DisconnectFP601/

FP602/P4201. /

Remove the Side Case

Unitwith LCD Unit.

(4) Top Case Unit Fig.3 DisconnectFP6002/

FP603. / Remove the

Top Case Unit.

(5) LCD Unit Fig.4-1 Openthe LCD Panel

as Fig. 4-1. / 2 Screws

(L)

Fig.4-2 Remove the LCD Unit

from Side Case Unit. /

3-Screws (M)/ 2-

Screws (N)/ 1-Screw

(O)

Fig.4-3 1-Screw(P)/ 1-Screw

(Q)

(6) Lens Unit Fig.5 2-Screws (R)/

DisconnectPP202/

FP701. / Remove the

Lens Unit.

(7) BatteryCase

Unit Fig.5 2-Screws (S)/ 1-Screw

(T)/ 1-Screw(U)/

DisconnectFP1002/

PS1001/PS1002. /

Remove the Battery

Case Unit.

Table of contents

Other Panasonic Camcorder manuals

Panasonic

Panasonic AG-DVX100B User manual

Panasonic

Panasonic HM-TA1 User manual

Panasonic

Panasonic NV-DX1EN User manual

Panasonic

Panasonic Palmcorder PV-GS90P User manual

Panasonic

Panasonic Palmcorder MultiCam PV-DV702 User manual

Panasonic

Panasonic KX-TGA914EX User manual

Panasonic

Panasonic NV-GS300 User manual

Panasonic

Panasonic NVMS5 User manual

Panasonic

Panasonic Palmcorder MultiCam PV-L453 User manual

Panasonic

Panasonic NV-GS400GC User manual

Panasonic

Panasonic TM 300 User manual

Panasonic

Panasonic AK-UC3000GS User manual

Panasonic

Panasonic NVM40 User manual

Panasonic

Panasonic HX-DC3 User manual

Panasonic

Panasonic VDR VDR-D220 Quick start guide

Panasonic

Panasonic SDR-SW20P User manual

Panasonic

Panasonic HDC-SD5BNDL User manual

Panasonic

Panasonic HVX200A - Camcorder - 1080p User manual

Panasonic

Panasonic AG-AC130A Series User manual

Panasonic

Panasonic HM-TA1V User manual

Panasonic

Panasonic NV-GS25GN User manual

Panasonic

Panasonic AJ-HPX3000MC User manual

Panasonic

Panasonic AJ-D910WB User manual

Panasonic

Panasonic Palmcorder PV-A396 User manual

Popular Camcorder manuals by other brands

Toshiba

Toshiba CAMILEO Z100 user guide

Canon

Canon RC 260 instructions

Sony

Sony Handycam DCR-DVD7E operating guide

Brinno

Brinno TimeLapse TLC200 user manual

JVC

JVC GR-SXM68AC Schematic diagram

Insignia

Insignia NS-DCC5HB09 - Camcorder - 720p user guide

MYDLINK

MYDLINK DCS-6100LH Quick installation guide

Sony

Sony video Hi8 Handycam CCD-TR555 operating instructions

SECURECOM

SECURECOM V-5014B installation guide

Sharper Image

Sharper Image U-VIDEO instruction manual

JVC

JVC AA-V15EG instruction manual

Canon

Canon LEGRIA HV40 instruction manual

Sony

Sony Handycam DCR-VX2000 Service manual

RCA

RCA CC616 user guide

ATIK Cameras

ATIK Cameras Horizon manual

Sony

Sony Handycam HDR-CX580V owner's manual

Sharp

Sharp ViewcamZ VL-Z8H Operation manual

Philips

Philips M620/21 operating instructions