Motocaddy SE User manual
EN
REGISTERONLINE
www.motocaddy.com/warranty
Visit www.motocaddy.com/instructions for other Motocaddy instructions including translations
SE Electric Trolley
Instruction Manual
ORIGINAL VERSION
Page 2
Locating your Serial Number
The serial number for your Motocaddy trolley is located on the underside of the battery tray.
This number is required when registering your warranty online and should be kept handy for future use.
The same number should also be on the box received with your trolley. If you need to return your trolley for any reason, please
retain the packaging. A proof of purchase must also be kept in case your trolley requires servicing during its warranty period.
Please keep a record of your trolley serial number here for future reference
LOCATING YOUR SERIAL NUMBER
Page 3
10
3
EQUIPMENT OVERVIEW
Equipment Overview
1. Power & Battery Indicators
2. On/Off & Speed Control Button
3. USB Port (underneath handle)
4. QUIKFOLD Upper Release Button
5. Upper Bag Support
6. QUIKFOLD Lower Release Button
7. Battery
8. Battery Cable/Connector
9. Battery Tray
10. Motor (underneath battery tray)
11. EASILOCK®Lower Bag Support
12. Front Wheel
13. Front Wheel Alignment Adjusters
14. Rear Wheels
15. Rear Wheel Release Button
13
14
6
51
7
9
11
15
4
8
12
2
14
Page 4
SAFE USE OF YOUR TROLLEY
Safety cut-out
This Motocaddy trolley is tted with a timed safety cut-out feature. Once started, the trolley will automatically cut power to the
motor after ten minutes to reduce the risk of damage to the trolley. Pressing the 'On/Off' button will restart the trolley.
Safe use of your Trolley
Motocaddy trolleys are designed for the transportation of golf bags and clubs contained within. Using the trolley for any other
purpose may cause damage to the trolley and cause harm to the user.
• Do not attempt to transport any other equipment;
• The trolley is not designed for the transportation of people;
• The maximum rated load suitable for this trolley is 20kg;
• Do not use the trolley to assist you when walking up hills;
• Submerging the trolley in water (e.g. a lake) will cause damage to the trolley;
• Do not operate the trolley whilst under the influence of drugs or alcohol;
• All batteries must be disconnected from the trolley before folding, storage and transportation;
• This trolley can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental
capabilities if they have been given supervision or instruction concerning use of the trolley in a safe way and understand
the hazards involved. Children shall not play with the trolley. Cleaning and user maintenance shall not be made by children
without supervision;
Page 5
TROLLEY CARE
Caring for your Trolley
Although your Motocaddy trolley has been weatherproofed, please follow these simple guidelines to help protect your trolley:
• Do not store your trolley outside;
• Try to minimise exposure to rain as much as possible with an umbrella during heavy rainfall;
• Wipe excess water from the trolley prior to storage;
• Never use a pressure washer to clean your trolley. To prevent water damage, wipe down with a damp cloth;
• Avoid using high pressure air hoses near moving components;
This Motocaddy trolley is designed to require very little maintenance. We do however recommend checking your trolley before
each use to ensure:
• There is no build up of excess mud and dirt;
• The rear wheels are securely tted and turn freely;
• The rear wheel axles are greased and well lubricated;
• The front wheel nut is on tightly and quick release lever is clamped down;
• The front wheel is not clogged up and turns freely;
• The QUIKFOLD track is kept clean and well lubricated;
Only original Motocaddy parts should be used when repairing your trolley.
If you experience an issue with your trolley, please contact our Technical Support team for further assistance.
Page 6
IMPORTANT BATTERY SAFETY & CARE
Important Battery Safety & Care Information
• Always recharge as soon as possible after nishing your round, regardless of the number of holes played - ideally within
12 hours. Leaving batteries uncharged for extended periods may reduce capacity and could pose a signicant safety risk
which could result in re when the battery is charged. Batteries should always be fully charged prior to storing for long periods;
• Never leave batteries charging for longer than necessary - disconnect once the green LED light indicates the battery is fully charged;
• Ensure that only Motocaddy 12.8V Lithium batteries are charged with Motocaddy 12.8V Lithium battery chargers
(Part number LICH128BLKBL) and the charger is always connected to an earthed socket outlet;
• Batteries must be stored and charged on a dry, non-carpeted surface at a temperature ranging between 10°C and 30°C -
charging outside these temperatures may reduce capacity;
• The battery and charger must only be opened and maintained by authorised personnel. Unauthorised opening increases the
risk of safety issues and will invalidate your warranty;
• Take care not to drop the battery as this may cause damage to the internal cells which could affect battery performance and safety;
• Regularly check the battery for visible signs of damage. Do not charge or use the battery if any damage is suspected - contact our
Technical Support team immediately for advice;
• Use a damp cloth to clean off any dirt, but try to avoid getting the battery too wet (i.e. do not submerge, avoid deep puddles &
do not clean your trolley with the battery in the tray);
• WARNING: For the purposes of recharging the battery, only use the charger provided with this trolley;
Page 7
IMPORTANT BATTERY SAFETY & CARE
We are dedicated to protecting the environment and encourage the recycling of Motocaddy products.
Exhausted and damaged batteries should be safely disposed of through a local recycling point (where available).
Alternatively, please contact our Customer Support team for further information regarding safe and responsible disposal.
• The battery supplied with this trolley contains battery cells that are non-replaceable;
• Only Lithium battery model S-ULTRA 274wh or Lead-acid battery model 12V 21Ah can be used with this trolley;
• Exhausted batteries are to be removed from the trolley and safely disposed of;
• If the trolley is to be stored unused for a long period, the battery should be removed;
• The battery supply terminals must not to be short-circuited;
IMPORTANT - As with any electrical device, it is not recommended to leave batteries charging overnight or for prolonged
periods without supervision. Motocaddy Lithium batteries can be fully-charged from empty in less than 5 hours, so wait for
the charger light to turn green, switch off at the wall and unplug the battery ready for your next round.
WARNING - If any of the charger LED lights flash RED and/or GREEN consecutively when connected to the battery, this
indicates there is likely to be a fault with the battery or charger. It is important that you disconnect the charger immediately
and contact our support team for further assistance. Do not attempt to use the battery or charger as this could pose a signicant
safety risk which could result in re.
Page 8
CHARGING YOUR LITHIUM BATTERY
Charging your Lithium Battery
The Lithium battery can be left on the trolley or removed for charging. It can be charged while the trolley is folded or unfolded.
Batteries must be disconnected from the trolley before folding/storage/transportation to avoid damage to the battery and/or trolley.
1. Plug the Motocaddy 12.8V Lithium battery charger into an earthed mains power socket
2. The charger will display a red LED to indicate that it is ready to charge
3. Attach the battery cable to the charger matching the black and blue connectors
4. During the charging cycle, four green LEDs will illuminate in sequence until the battery is fully charged:
1 LED = 20% 2 LEDs = 50% 3 LEDs = 80% 4 LEDs = 100%
5. Once fully-charged, all four green LEDs will illuminate without flashing
6. The charging process will take 3 to 5 hours depending on the depth of discharge. This may take longer for the rst few charges
7. Once charging is complete, disconnect the charger from the mains power supply and battery
WARNING - If any of the charger LED lights flash RED and/or GREEN consecutively when connected to the battery, this
indicates there is likely to be a fault with the battery or charger. It is important that you disconnect the charger immediately
and contact our support team for further assistance. Do not attempt to use the battery or charger as this could pose a signicant
safety risk which could result in re.
Page 9
BATTERY HIBERNATION / BATTERY MANAGEMENT SYSTEM
Recommendations for hibernation of Lithium Batteries during winter months
If for any reason your Lithium battery is not going to be used for lengthy periods, e.g. 3-months over the winter, the battery should
be stored fully charged. Before the battery is used again, recharge it (top it up) prior to use. The battery must not be left for longer
than 2-months without charging as this could invalidate your warranty.
We recognise that extended absences are not always planned in advance, however when it is likely that you will not be using your
battery for a period of time it is good practice to follow these steps to extend the life of your Lithium battery. Always recharge as
soon as possible after nishing your round, regardless of the number of holes played - ideally within 12 hours. Leaving batteries
uncharged for extended periods may reduce capacity and could pose a signicant safety risk which could result in re when the
battery is charged. Batteries should always be fully charged prior to storing for long periods. Please ensure that the charger is
ALWAYS disconnected from the battery after charging.
Battery Management System (BMS)
Motocaddy Lithium batteries are tted with a comprehensive battery management system (BMS) to protect the battery from
excessive abuse, high currents, deep discharge and overcharge. When the battery is delivered there may be no output as the BMS
is designed to maximize safety whilst shipping. Please ensure that the battery is fully charged prior to connecting it to your trolley
as this will activate the BMS and effectively ‘switch-on’ the battery. From time to time, at deep discharge or long term storage the
BMS may switch-off the battery. A full battery charge will rectify this problem.
Motocaddy golf trolleys are designed to work with the BMS system installed in the Lithium batteries and the battery meter is
also synchronised to work in conjunction with the battery. If for any reason the voltage on the battery falls below the low battery
warning on the trolley, then the BMS may disable the battery to protect it. Again if this occurs please recharge fully. Please be
aware that Lithium batteries tend to ‘drop off’ quickly at the end of the cycle so it is not advisable to attempt to play excessive
holes as the BMS will activate for protection purposes.
Page 10
Attaching the Wheels
There is a left and a right wheel and it is important that you don’t put them on the wrong
way round, otherwise the trolley will not move.
There is an ‘L’ and ‘R’ on the inside of the wheel on the central hub. Left and Right sides
are determined when stood behind the trolley at the handle.
To attach the rear wheels, follow these simple steps:
1. Push and hold the quick release button in towards the centre of the wheel
2. Slide the wheel onto the trolley axle as far as it will go (onto the inner groove)
3. Once in position, release the button and pull the wheel outwards slightly to lock
4. An audible ‘click’ will conrm the wheel is in the correct position
Once correctly attached onto the inner groove, the wheels will rotate freely forwards,
but not backwards.
The outer groove can be used as a “free-wheel” option if you run out of battery power.
Simply slide the wheel onto the outer groove and pull the wheel outwards slightly to lock.
Once connected, the wheel will spin freely without resistance in both directions.
ATTACHING THE WHEELS
Left Right
Table of contents
Other Motocaddy Outdoor Cart manuals
