MasterChef S482 User manual

S482 Barbecue

Assembly Manual

85-3024-4 (G43215) Propane

85-3025-2 (G43216) Natural Gas

1 YEAR LIMITED WARRANTY

READ AND SAVE MANUAL FOR FUTURE REFERENCE.

If pre-assembled, leave this manual with unit for

consumer’s future reference.

For product inquiries, parts, warranty and

troubleshooting support, please call 1-877-707-5463.

Manual Revision #: 01112010 PD

DANGER

1. If you smell Gas:

a. Shut o gas to the appliance

b. Extinguish any open ame

c. Open lid

d. If odor continues, keep away from

the appliance and immediately

call your gas supplier or your

re department

2. Do not store or use gasoline or other

ammable vapours and liquids in the

vicinity of this or any other appliance.

3. An LP cylinder not connected for use shall

not be stored in the vicinity of this or any

other appliance.

4. Requires two people to complete the

assembly process.

5. Beware of sharp edges.

WARNING

Failure to follow all of the Manufacturer’s

instructions could result in hazardous res,

explosions, property damage, or serious

personal injury or even death.

Follow all leak check procedures carefully

prior to operation of barbecue, even if grill

was dealer assembled. Do not try to light

this barbecue without reading the Lighting

Instructions section of this manual.

THIS MANUAL MUST REMAIN WITH THE PRODUCT AT ALL TIMES

CAUTION

Read and follow all safety statements,

assembly instructions, and use and care

directions before attempting to assemble

and cook.

CAUTION

Sharp edges. Wear gloves when assembling

your grill.

THIS BARBECUE IS FOR OUTDOOR USE ONLY

CONTACT CALL CENTRE IF ANY PARTS ARE MISSING

1-877-707-5463

INSTALLER OR ASSEMBLER/CONSUMER

This manual should be kept with the BBQ at

all times.

HEAVY ARTICLE NEEDS 2 TO LIFT

TOOLS NEEDED FOR ASSEMBLY

• #2 Phillips screwdriver (long and short)

• ¼” Slotted screwdriver (long and short)

• Adjustable wrench

• Pliers

Before assembling the barbecue, read these

instructions carefully.

Assemble the barbecue on a at, clean surface.

Grill is heavy. You should have at least two people

assemble the barbecue together.

Notes: Do not fully tighten all the nuts during

this initial stage.

Caution:

Sheet metal can cause injury. Wear gloves when installing the grill.

HARDWARE PACK

1/4”-20UNCX13mm screw

X 12

1/4” x 20UNC 38 mm Screw

X 4

#8X3/8” Self Tapping Screw

X 12

Wheel Spacer

X 2

¼” - 20UNC Nut

X 12

Ø7 Flat Washer

X 8

Hitch Pin

X 1 Washer (Wheel)

X 1

1 2 3

4 5 6

KEY # DESCRIPTION PART NUMBER QUANTITY

1 1/4”-20UNCX13mm screw 20120-13013-036 12

2 1/4”-20UNCX38mm screw 20120-13038-036 4

3 1/4”-20UNC nut 31220-13000-036 12

4 #8X3/8” self tapping screw 24200-42008-136 12

5 Ø7 ber washer G431-0018-9000 8

6 wheel spacer G650-0012-9091 2

7 hitch pin G306-0005-9088 1

8 washer(wheel) G650-0013-9091 1

To ORDER non-warranty replacement parts or accessories, or to register your warranty,

please visit us on the web at

www.masterchefbbqs.com

PARTS LIST PROPANE FOR 8530244 G43215 EXPLODED DIAGRAM PROPANE FOR 8530244 G43215

KEY # QUANTITY DESCRIPTION PART NO.

AA 1 Top lid assembly G432-B000-01

AB 1 Thermometer and bezel G432-R200-01

AC 1 Logo Plate G451-0001-01

AD 2 Lid handle brackets G432-0030-01

AE 1 Top lid handle G432-0029-01

AF 2 Lid bumpers- back G303-0038-01

AG 2 Lid bumbers-Front G430-00B8-01

AH 2 Screws for Lid G430-0024-02

BA 1 Burner box assembly G432-1900-A1

BB 4 Burners G432-B500-01

BC 1 Electrode set, main burners G501-0010-01

BD 3 Burner brace assembly G432-0078-01

BE 4 Flame tamers G430-0005-01

BF 3 Cooking Grates G432-4300-01

BG 1 Warming Rack G432-0001-01

CA 1 Control Panel G432-0071-01

CB 1 Manifold assembly G432-Q200-01

CC 1 Regulator G402-0069-01

CD 4 Bezel, control knob G430-0027-01

CE 4 Control knob G432-0058-01

CF1 1 Electronic ignition assembly G430-0008-01

CF2 1 Electronic ignition button G501-0072-A1

CG 1 Grease cup hook G305-0043-01

CH 1 Grease cup G430-0033-02

CI 1 Heat shield G432-Q101-01

DA 1 Cart side panel, right G430-2300-01

DB 1 Cart side panel, left G432-B700-01

DC 1 Bottom shelf G432-1300-01

DD 1 Front panel G432-0033-01

DE 2 End caps G430-0023-01

DF 2 Wheel G432-0034-01

DG 2 Wheel cap G432-0073-01

DH 1 Wheel axle G650-0011-01

DI 1 Match holder G401-0079-01

DJ 1 Tank exclusion G432-5302-01

EA 1 Side shelf table (right) G432-3600-01

EB 1 Side shelf fascia(right) G432-0064-01

EC 1 Side shelf table (left) G432-A200-01

ED 1 Side shelf fascia (left) G432-0072-01

F1 1 Hardware pack G432-B015-01

F2 1 Assembly instructions G432-M015-01

F3 1 Safe use and care manual G207-M015-02

HARDWARE

PACK

ASSEMBLY

MANUAL

SAFETY

AND CARE

MANUAL

F2 F3

CF2

CF1

4 5

PARTS LIST NATURAL GAS FOR 8530252 G43216 EXPLODED DIAGRAM NATURAL GAS FOR 8530252 G43216

KEY # QUANTITY DESCRIPTION PART NO.

AA 1 Top lid assembly G432-B000-01

AB 1 Thermometer and bezel G432-R200-01

AC 1 Logo Plate G451-0001-01

AD 2 Lid handle brackets G432-0030-01

AE 1 Top lid handle G432-0029-01

AF 2 Lid bumpers- back G303-0038-01

AG 2 Lid bumbers-Front G430-00B8-01

AH 2 Screws for Lid G430-0024-02

BA 1 Burner box assembly G432-1900-A1

BB 4 Burners G432-B600-01

BC 1 Electrode set, main burners G501-0010-01

BD 3 Burner brace assembly G432-0078-01

BE 4 Flame tamers G430-0005-01

BF 3 Cooking Grates G432-4300-01

BG 1 Warming Rack G432-0001-01

CA 1 Control Panel G432-0071-01

CB 1 Manifold assembly G432-Q700-01

CC 1 Natural Gas Hose G501-0099-01

CD 4 Bezel, control knob G430-0027-01

CE 4 Control knob G432-0058-01

CF1 1 Electronic ignition assembly G430-0008-01

CF2 1 Electronic ignition button G501-0072-A1

CG 1 Grease cup hook G305-0043-01

CH 1 Grease cup G430-0033-02

CI 1 Heat Shield G432-Q101-01

DA 1 Cart side panel, right G430-2300-01

DB 1 Cart side panel, left G432-B700-01

DC 1 Bottom shelf G432-4400-01

DD 1 Front panel G432-0033-01

DE 2 End caps G430-0023-01

DF 2 Wheel G432-0034-01

DG 2 Wheel cap G432-0073-01

DH 1 Wheel axle G650-0011-01

DI 1 Match holder G401-0079-01

EA 1 Side shelf table (right) G432-3600-01

EB 1 Side shelf fascia (right) G432-0064-01

EC 1 Side shelf table (left) G432-A200-01

ED 1 Side shelf fascia (left) G432-0072-01

F1 1 Hardware pack G432-B015-01

F2 1 Assembly instructions G432-M015-01

F3 1 Safe use and care manual G207-M015-02

CF2 CG

CF1

HARDWARE

PACK

ASSEMBLY

MANUAL

SAFETY

AND CARE

MANUAL

F2 F3

6 7

Note: Turn Cart assembly upside down.

a. Place wheel (DF) and wheel spacer (#6) onto

wheel axle (DH). “Cone” side of wheel should

be against cart side panel, gure B.

b. Insert wheel axle assembly (DH) through

wheel axle hole in the front and rear, of the left

cart side panel (DB), as shown.

c. To complete wheel assembly, position the

wheel spacer (#6), wheel (DF), wheel washer

(#8) and hitch pin (#7), onto wheel axle (DH),

as shown.

PROPANE MODEL ONLY

Note: You will need two people for this step.

Assemble the tank exclusion (DJ) to the left and

right cart side panels (DB, DA), as shown.

Note: The left cart side panel (DB) will have

large holes on the end of the legs for

assembling the wheel axle (DH).

Assemble the front panel (DD) to the left and

right cart side panels (DB, DA), as shown.

Ensure that the slots on the tank exclusion (DJ)

align with the slots on the front panel (DD).

NATURAL GAS MODEL WILL NOT

HAVE TANK EXCLUSION DJ,

SHOWN IN IMAGE.

1 3

ASSEMBLY INSTRUCTIONS ASSEMBLY INSTRUCTIONS

876

YOU WILL NEED:

X 2

X 6

X 1

d. Insert wheel cap (DG) into wheel (DF).

e. Insert end caps (DE) into cart side panel,

right (DA).

Front View

Close Up

Back View

Left Side View

Note: The bottom shelf (DC) propane tank hole

should be on the left side, closest to the Left

cart side panel (DB).

Assemble the bottom shelf (DC) to the rear, left

and right cart side panels (DB, DA), as shown.

YOU WILL NEED:

2 3

X 4 X 4

8 9

5Note: TWO PEOPLE required for this step.

Ensure that the regulator hose (CC) (Propane

models only) is hanging outside of cart.

Position the lid and burner box assembly (A&B),

onto the cart assembly (C), and assemble.

YOU WILL NEED:

ASSEMBLY INSTRUCTIONS ASSEMBLY INSTRUCTIONS

6RIGHT SIDE SHELF ASSEMBLY

a. Insert the right side shelf assembly hooks (EA

& EB) into the support brackets located on the

right side of the burner box assembly (B).

b. Ax the right side shelf table (EA) to the

burner box assembly (B).

d. Ax the right side shelf fascia (EB) to the

control panel (CA).

Securely tighten all hardware.

X 4

YOU WILL NEED:

X 4

YOU WILL NEED:

X 3

A B

CCC

10 11

ASSEMBLY INSTRUCTIONS

7LEFT SIDE SHELF ASSEMBLY

a. Insert the left side shelf assembly hooks (EC

and ED) into the support brackets located on

the left side of the burner box assembly (BA).

b. Ax the left side shelf table (EC) to the burner

box assembly (BA).

Securely tighten all hardware.

c. Ax the left side shelf fascia (ED) to the

control panel (CA).

ASSEMBLY INSTRUCTIONS

YOU WILL NEED:

X 3

YOU WILL NEED FIGURE B:

YOU WILL NEED FIGURE A:

X 4

Place the ame tamers (BE) into the burner box.

Place the cooking grates (BF) into the burner box.

12 13

ASSEMBLY INSTRUCTIONS

To assemble the warming rack (BG), insert the

stationary wire into the holes on the sides of

the lid. Insert warming rack pivot legs into the

holes on the inside of the burner box assembly,

as shown.

ASSEMBLY INSTRUCTIONS

Stationary Wire

Pivot Legs

Hang the grease cup hook (CG) from the bottom

of the burner box (BA), and place grease cup (CH)

into position.

PROPANE MODEL SHOWN

CAUTION

Failure to assemble grease cup hook and grease

cup will cause hot grease to drip from the

bottom of the BBQ burner box, with the risk of

re, property damage, or personal injury.

PROPANE MODEL SHOWN

ATTENTION: LP Cylinder is sold separately.

Use only LP tanks that are equipped with an

OPD (Over ll protection device). Fill and Leak

check before attaching to the BBQ hose and

regulator. See Safe Use and Care Manual, leak

test procedure for more information

CAUTION

Cylinder valve must face to the front of cart

once the tank is attached.

Failure to install cylinder correctly may allow

gas hose to be damaged in operation, resulting

in re.

WARNING

Always keep LP cylinder in upright position

during use, transport and storage.

WARNING

When assembling regulator onto LP cylinder,

ensure that the regulator is assembled below

the support bar, as shown.

NATURAL GAS MODELS ONLY

Attach the natural gas hose (CC) to the

manifold (CB), as shown.

ATTENTION: In order to complete installation

of your natural gas BBQ a 1/2” or 3/8” adapter

may be required to connect your BBQ’s natural

gas hose to your home gas supply. Contact your

natural gas supplier to purchase the necessary

part.

ASSEMBLY INSTRUCTIONS

14 Electronic ignition battery not included.

Unscrew the electronic ignition button (CF2) and

insert one AA battery into the electronic ignition

battery compartment (CF1), with the positive

end facing outward.

CF1

CF2

Other manuals for S482

Table of contents

Other MasterChef Grill manuals

MasterChef

MasterChef GRILL TURISMO User manual

MasterChef

MasterChef G32008 User manual

MasterChef

MasterChef T405 Quick guide

MasterChef

MasterChef TF2201804-MC User manual

MasterChef

MasterChef T440 User manual

MasterChef

MasterChef S482 User manual

MasterChef

MasterChef G36402 User manual

MasterChef

MasterChef GRILL TURISMO P40101 User manual

MasterChef

MasterChef S480 User manual

MasterChef

MasterChef S380 User manual

MasterChef

MasterChef E480 User manual

MasterChef

MasterChef 76 cm (30?) Quick guide

MasterChef

MasterChef T420 User manual

MasterChef

MasterChef RSH013929 User manual

MasterChef

MasterChef S480 User manual

MasterChef

MasterChef 085-3602-8 User manual

MasterChef

MasterChef RSH-014257 User manual

MasterChef

MasterChef S280 User manual

MasterChef

MasterChef G32008 User manual

MasterChef

MasterChef G49201 User manual

MasterChef

MasterChef Grill Turismo G75001 User manual

MasterChef

MasterChef 085-2202-6 User manual

MasterChef

MasterChef S420 User manual

MasterChef

MasterChef s380 User manual

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide