Masterbuilt MB20042219 User manual

EXTRA LARGE CHARCOAL GRILL

Manual Code: 9804190134 | 200130-SPS

Master it. Masterbuilt.

Manual applies to the following model number(s)

These numbers are located on the rating label of the unit.

Mfg. Date - Serial NumberYour model number

MB20042219

IMPORTANT, RETAIN FOR FUTURE REFERENCE: READ CAREFULLY

IMPORTANT

FOR OUTDOOR USE ONLY. NOT FOR COMMERCIAL USE.

CARBON MONOXIDE HAZARD

WARNINGS AND IMPORTANT SAFEGUARDS

WARNING

Failure to follow these instructions could result in ﬁre, explosion or burn

hazard which could cause property damage, personal injury, or death.

READ ALL INSTRUCTIONS

• Always use grill in accordance with all applicable local, state, and federal ﬁre codes.

• Before each use check all nuts, screws, and bolts to make sure they are tight and secure.

• Never operate grill under overhead construction such as roof coverings, carports, awnings, or overhangs.

• Grill is for OUTDOOR HOUSEHOLD USE ONLY.

• Never use inside enclosed areas such as patios, garages, buildings, or tents.

• Never use inside or on recreational vehicles or boats.

• Maintain a minimum distance of 3 m from overhead construction, walls, rails or other structures.

• Keep a minimum 3 m clearance of all combustible materials such as wood, dry plants, grass, brush, paper,

or canvas.

• Never use grill for anything other than its intended use. This grill is NOT for commercial use.

• Accessory attachments not supplied by Masterbuilt Manufacturing, LLC are NOT recommended and may

cause injury.

• Use of alcohol, prescription, or non-prescription drugs may impair user’s ability to properly assemble or

safely operate grill.

• Keep a ﬁre extinguisher accessible at all times while operating grill.

• When cooking with oil or grease, have a type BC or ABC ﬁre extinguisher readily available.

• In the event of an oil or grease ﬁre do not attempt to extinguish with water. Immediately call the ﬁre

department. A type BC or ABC ﬁre extinguisher may, in some circumstances, contain the ﬁre.

• Use grill on a level, non-combustible, stable surface such as dirt, concrete, brick, or rock. An asphalt

surface (blacktop) may not be acceptable for this purpose.

• Grill MUST be on the ground. Do not place grill on tables or counters. Do NOT move grill across uneven

surfaces.

• This manual contains important information necessary for the proper assembly and safe use of the

appliance.

• Read and follow all warnings and instructions before assembling and using the appliance.

• Keep this manual for future reference.

• WARNING! Do not use spirit or petrol for lighting or re-lighting! Use only ﬁrelighters complying to

EN 1860-3!

• Burning wood chips, wood chunks, wood pellets, charcoal and propane gives off carbon monoxide,

which has no odour and can cause death.

• DO NOT burn wood chips, wood chunks, wood pellets, charcoal or propane inside homes, vehicles,

tents, garages or any enclosed areas.

• USE ONLY OUTDOORS where it is well ventilated.

• Do not use the barbecue in a conﬁned and/or habitable space e.g. houses, tents, caravans, motor

homes, boats. Danger of carbon monoxide poisoning fatality.

WARNINGS AND IMPORTANT SAFEGUARDS

• Do not use grill on wooden or ﬂammable surfaces.

• Keep grill clear and free from combustible materials such as gasoline and other ﬂammable vapours and

liquids.

• Do not leave grill unattended.

• Keep children and pets away from grill at all times. Do NOT allow children to use grill. Close supervision is

necessary when children or pets are in the area where grill is being used.

• Do NOT allow anyone to conduct activities around grill during or following its use until it has cooled.

• Never use glass, plastic, or ceramic cookware in grill. Never place empty cookware in grill while in use.

• Never move grill when in use. Allow grill to cool completely (below 45°C) before moving or storing.

• Do not store grill with hot ashes or charcoal inside grill. Store only when ﬁre is completely out and all

surfaces are cold.

• Never use grill as a heater (READ CARBON MONOXIDE HAZARD).

• The grill is HOT while in use and will remain HOT for a period of time afterwards and during cooling

process. Use CAUTION. Wear protective gloves/mitts.

• Be careful when removing food from grill. All surfaces are HOT and may cause burns. Use protective

gloves/mitts or long, sturdy, cooking tools for protection from hot surfaces or splatter from cooking liquids.

• DO NOT bump or impact the grill to prevent personal harm, damage to grill, or spillage/splashing of hot

cooking liquid.

• Do not touch HOT surfaces

• Grill is hot during use. To avoid burns, keep face and body away from door(s) and vents. Steam and hot air

are expelled during use.

• Air dampers are HOT while the grill is in use and during cooling; wear protective gloves when adjusting.

• Grill has an open ﬂame. Keep hands, hair, and face away from ﬂame and burning charcoal. Do NOT lean over

grill when lighting. Be careful of loose hair and clothing during operation as they could catch ﬁre.

• DO NOT obstruct ﬂow of combustion and ventilation.

• Do not cover cooking racks with metal foil. This will trap heat and may cause damage to the grill.

• Never leave HOT coals or ashes unattended.

• Fuel should be kept red hot for at least 30 minutes prior to use.

• Do not cook before the fuel has a coating of ash.

• Do not remove ash can while ashes and charcoal are HOT.

• Use protective gloves when handling this grill or working with ﬁre. Use protective gloves or long, sturdy

ﬁreplace tools when adding charcoal.

• Use only charcoal as fuel. Do not use any other fuel source.

• Use only charcoal lighting ﬂuid. Never use gasoline, alcohol or other highly volatile ﬂuids to ignite charcoal.

These ﬂuids can explode causing injury or death.

• Never overﬁll charcoal grate. This can cause serious injury as well as damage to the grill.

• Never add additional lighter ﬂuid once charcoal has ignited. Follow directions on lighter ﬂuid container.

• Dispose of cold ashes by placing them in aluminum foil, soaking with water, and discarding in a non-

combustible container.

SAVE THESE INSTRUCTIONS

Structural Proximity and Safe Usage Recommendations

REMINDER: Maintain a

minimum distance of

3m from rear and

sides to walls, rails or

other combustible

construction. This

clearance provides

adequate space for

proper combustion, air

circulation and

venting.

3m3m3m

Packing Contents

IMPORTANT: Remove all packing contents before assembly.

It is important that you remove all paper,

packing foam and cardboard from the grill

before assembly.

Located on the lid/ﬁrebox assembly is a

support bar used for shipping purposes only.

This bar must be removed so that you may

successfully assemble your grill. The location

of this bar is shown here. The bar is no longer

needed.

Remove support bar

DO NOT RETURN TO RETAILER for assembly assistance, missing or damaged parts. Please

contact MASTERBUILT Customer Service at +44 20 8036 3201 or service.uk@masterbuilt.com in

the U.K and +0031 4 7799920, +49 2151 4474509, or service.eur[email protected] in Europe.

Please have the model number and serial number available. These numbers are located on the

silver rating label on the grill.

STOP

•BEFORE ASSEMBLY READ ALL INSTRUCTIONS CAREFULLY.

• Assemble on a clean ﬂat surface.

• Tools needed: 20.32 cm long Phillips head screwdriver, pliers or adjustable wrench

• Approximate assembly time: 45 minutes

• Actual product may differ from picture shown.

• It is possible that some assembly steps have been completed in the factory.

Qty Description Qty Description

A2 M5x15 Screw I1 M6x21 Shoulder Screw

B4 M5 Self-Locking Nut J2 #10 Lock Washer

C1 M4 Self-Locking Nut K72 M6x15 Phillips/Slotted-Head Screw

D1M4x10 Flat-Head Screw L2 M10 Nut

E2 Door Hinge Pin M2 M4 Nut

F12 M5x10 Flat-Head Screw N2 M4x10 Screw

G4 M5x6 Shoulder Screw O8 M6X15 Shoulder Screw

H6 M6 KEPS Nut P2 M6x10 Screw

Hardware List

F G

ABCDE

Parts List

Actual product may differ

from picture shown.

10 11

38 39

Item #

Qty Description

Item #

Qty Description

1 2 Smoke Stack Cap 23 1 Right Front Leg #2

2 2 Smoke Stack 24 1 Firebox Left Lower Panel

3 1 Temperature Gauge 25 1 Firebox Right Lower Panel

4 2 Lid Handle Stand-Off 26 1 Cart Bottom Shelf

5 1 Lid Handle 27 1 Door Stopper

6 2 Side Shelf 28 1 Door Magnet

7 1 Slotted Adjustment Panel 29 2 Charcoal Door Locking Latch

8 1 Charcoal Tray Linkage Assembly 30 2 Charcoal Door Handle Washer

9 1 Charcoal Tray Linkage Knob 31 2 Charcoal Door Handle

10 2 Caster Wheels 32 1 Charcoal Door

11 2 Locking Caster Wheels 33 2 Charcoal Door Hinge

12 3 Cooking Grate 34 1 Ash Tray

13 1 Cooking Grate Rear Frame 35 1 Cart Front Panel

14 1 Cooking Grate Left Side Frame 36 2 Air Damper

15 1 Cooking Grate Right Side Frame 37 1 Cart Rear Panel

16 1

Cooking Grate Front Frame with Handle

38 4 Door Handle Stand-Off

17 1 Charcoal Tray Lift Assembly 39 2 Door Handle

18 1 Charcoal Tray 40 1 Cabinet Top Panel

19 1 Lid and Firebox Assembly 41 1 Cabinet Left Door

20 1 Left Rear Leg #3 42 1 Cabinet Right Door

21 1 Left Front Leg #2 43 1 Cabinet Rear Panel

22 1 Right Rear Leg #1 44 2 Cabinet Panel

20 22

21 23

Assembly

P P

K K

Note: Do not fully tighten screws until step 15 is complete.

Assembly

Note: Do not fully tighten screws

until step 15 is complete.

Note: Do not fully tighten screws

until step 15 is complete.

Assembly

20 22

21 20

22 23

Repeat on right side

Note: Do not fully tighten screws until step 15 is complete.

Note: Do not fully tighten screws

until step 15 is complete.

Assembly

26 26

40 40

41 41

Note: Do not fully tighten screws until step 15 is complete.

Table of contents

Other Masterbuilt Grill manuals

Masterbuilt

Masterbuilt CGP24G1D User manual

Masterbuilt

Masterbuilt EGP Guide

Masterbuilt

Masterbuilt MB20030619 User manual

Masterbuilt

Masterbuilt Outdoor LP Gas Double Cooker MDCL User manual

Masterbuilt

Masterbuilt 20040712 Guide

Masterbuilt

Masterbuilt MB20042119 User manual

Masterbuilt

Masterbuilt 20070210 SMOKEHOUSE Guide

Masterbuilt

Masterbuilt 070312 Guide

Masterbuilt

Masterbuilt CGT18G1A User manual

Masterbuilt

Masterbuilt 20070409 Guide

Masterbuilt

Masterbuilt GRAVITY GRIDDLE MB20043622 User manual

Masterbuilt

Masterbuilt 20040117 Guide

Masterbuilt

Masterbuilt 20042011 Guide

Masterbuilt

Masterbuilt SSSMPG User manual

Masterbuilt

Masterbuilt 7BCM Guide

Masterbuilt

Masterbuilt SQPGD User manual

Masterbuilt

Masterbuilt 20075315 Guide

Masterbuilt

Masterbuilt sportsman elite 20051313 Guide

Masterbuilt

Masterbuilt AutoIgnite 545 Series User manual

Masterbuilt

Masterbuilt 20051311 User manual

Masterbuilt

Masterbuilt MB20040919 User manual

Masterbuilt

Masterbuilt 20042011 Guide

Masterbuilt

Masterbuilt 20072712 Guide

Masterbuilt

Masterbuilt GMDES Quick reference guide

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide