Majestic RUBY30IN User manual

Majestic • CKRUBY30, CKRUBY35 Contemporary Kit Instructions • 2542-939 Rev. B • 2/19

TOOLS

Screw gun equipped with 1/4 in. socket or

1/4 in. wrench

3/8 in. wrench

Instructions for optional glass kit, stone kit or log set if

applicable.

Leave this manual with party responsible for use

and operation.

CKRUBY30, CKRUBY35

Models: RUBY30IN, RUBY30IL, RUBY35IN, RUBY35IL

Installation Instructions

CAUTION! Do not install damaged components.

DANGER

HOT GLASS WILL

CAUSE BURNS.

DO NOT TOUCH GLASS

UNTIL COOLED.

NEVER ALLOW CHILDREN

TO TOUCH GLASS.

A barrier designed to reduce the risk of

burns from the hot viewing glass is provided

with this appliance and shall be installed for

the protection of children and other at-risk

individuals.

Preparation

CAUTION! Risk of Burns! The replace should be

turned off and cooled before contemporary kit is installed.

• Shut off gas supply and disconnect electrical power.

• Remove decorative front, glass assembly, glass seal

plate, lava rock, embers, logs and refractory, if previ-

ously installed.

CAUTION! Risk of Cuts, Abrasions or Flying Debris.

Wear protective gloves and safety glasses during instal-

lation. Sheet metal edges are sharp.

WARNING! Choking Hazard! Keep media out of reach

of children.

Note: If an optional LINER kit will be used with the CK-

RUBY30/35, the LINER kit instructions will be needed

during installation of the CKRUBY30/35 kit.

Note: The CKRUBY30/35 is not compatible with ber

refractory.

WARNING! Risk of Injury! This kit must be installed by

a qualied service technician.

Models

(U.S. or Canada)

Maximum

Input

BTU/h

Minimum

Input

BTU/h

Orice

Size

(DMS)

Shutter

Setting

CKRUBY30

(NG) (0-2000 FT) 28,000 19,600 38 1/2 in.

CKRUBY30

(Propane) (0-2000 FT) 23,000 16,100 .058

in.

Full

Open

CKRUBY35

(NG) (0-2000 FT) 30,000 21,000 37 3/8 in.

CKRUBY35

(Propane) (0-2000 FT) 28,000 19,600 1.55

Full

Open

BTU Specications

2Majestic • CKRUBY30, CKRUBY35 Contemporary Kit Instructions • 2542-939 Rev. B • 2/19

Installation Instructions

1. Remove base refractory.

2. Remove the screws that attach the base pan to the

burner and lift the base pan out of the appliance.

3. Remove the burner bracket screw. Slide burner to the left

and lift out of the appliance. Be careful not to damage the

pilot sense rod.

4. Remove the exhaust bafe and replace with contem-

porary exhaust bafe. See Figure 2.

5. Remove the orice using a 3/8 in. wrench and replace

with correct orice for gas type. See BTU specication

table on page 1.

6. Adjust the air shutter and install contemporary burner

assembly. See BTU specication table on page 1.

7. Install contemporary base pan assembly.

Note: Install insulation board behind false back for

CKRUBY35 kit.

8. Install false back. See Figure 2.

Figure 1. Contemporary Kit Metal Components

KIT COMPONENTS (Shown in Figure 1)

(1) Basepan Assembly

(1) Burner Assembly

(1) False Back

(1) Exhaust Bafe

(1) Bag Onyx Glass Media

(1) Bag Diamond Glass Media

(1) Bag 1/2 inch screws (25 screws per bag)

(1) Conversion Plate

(1) Stone Placement Jig

(1) Propane Orice - .058", 1.55 mm

(1) NG Orice - 38, 37

(2) Insulation Board (CKRUBY35 Only)

9. If installing the glass refractory kit, refer to the installa-

tion instructions that came with the kit and install now.

10. If installing logs, refer to the instructions with the kit

and install now.

11. Install glass media. When using multiple media col-

ors, mix them prior to installation. For optimal per-

formance and ame appearance, ensure it is spread

evenly. See Figure 3.

Figure 2. Screw Location

EXHAUST

BAFFLE

STONE

PLACEMENT

JIG FALSE BACK

ROCK STOP

JIG

PILOT

HOOD

BURNER

ASSEMBLY

BASE PAN

ASSEMBLY

EXHAUST BAFFLE

SCREWS

FALSE BACK SCREWS

ADDITIONAL COMPONENT - 35 in. ONLY

INSULATION

BOARD

Models Media

Quanity (Bag)

CKRUBY30 (NG) 1-1/4

CKRUBY30 (Propane) less than 1-1/4

CKRUBY35 (NG) 1-1/2

CKRUBY35 (Propane) less than 1-1/2

Media Chart

CAUTION: Place only one thin layer of media over the

burner and base pan when using Propane gas. Excess

media on burner and base pan may cause sooting. One

thin layer of media may require less media than indicated

in the above media chart.

Majestic • CKRUBY30, CKRUBY35 Contemporary Kit Instructions • 2542-939 Rev. B • 2/19

Figure 4. Stone Jig in Place

WARNING

Risk of Asphyxiation or Fumes.

• Place media according to instructions.

• Do NOT place media in area between glass and

rebox.

• Do NOT place media in a position that they may

fall into area between glass and rebox.

• Do NOT use any media other than the media

supplied with this replace.

Fireplace will not function properly.

Gas leak may occur.

WARNING

Delayed Ignition Risk

• Place media according to instructions.

• Do NOT place media in a position that they may

fall into area in front of pilot.

• Do NOT use any media other than the media

supplied with this replace.

• Do NOT exceed one layer of media on base pan.

Fireplace will not function properly.

Delayed ignition may occur.

12. If installing a stone kit, refer to the instructions in

the next section.

13 Remove rock stop.

Consumer: Retain rock stop for future maintenance

or service needs.

14. Reinstall seal plate, glass assembly and decorative

front.

15. Re-connect electrical supply and turn on gas.

Service Parts

MODEL DESCRIPTION PART NUMBER

CKRUBY30

Burner Assembly 2535-007

Exhaust Bafe 2535-138

Base Pan 2542-131

CKRUBY35

Burner Assembly 2536-007

Exhaust Bafe 2536-138

Base Pan 2544-131

Insulation Board 2536-158

BOTH

Rock Stop Assembly 2535-197

Stone Placement Jig 2542-198

Pilot Shield 2535-120

Note: A tall, deep orange ame should be avoided; this

type of ame may cause increased soot residue. If this

type of ame is noticed, try adjusting the media directly

beneath the ame. If all ames appear to be tall and deep

orange in color, then open the primary air shutter.

Please contact your Majestic dealer with any questions

or concerns.

For the location of your nearest Majestic dealer,

please visit www.majesticproducts.com.

Majestic, a brand of Hearth & Home Technologies

7571 215th Street West, Lakeville, MN 55044

www.majesticproducts.com

Installing Stone Kit

NOTE: Rock Stop Jig must be in place to install

stones.

1. Place stone jig on glass media with “STONE JIG” fac-

ing up. Ensure that the stone jig sits ush against the

rock stop. See Figure 4.

2. Place stones in a random manner in the open spots on

the base pan.

3. Remove stone jig and then the rock stop.

Consumer: Retain both stone jig and rock stop for

future maintenance or service needs.

Figure 3. Glass Media Installed

WARNING! Glass seal plate must be properly installed

Risk of elevated component temps and carbon monox-

ide exposure.

ROCK STOP

REAR MEDIA LEDGE

ROCK STOP

STONE JIG

STONES

This manual suits for next models

Other Majestic Indoor Fireplace manuals

Majestic

Majestic MERIDPLA36IN User manual

Majestic

Majestic 400BBV Manual

Majestic

Majestic 32VFH User manual

Majestic

Majestic RUBY25IN User manual

Majestic

Majestic 300DVBLN/PSC User manual

Majestic

Majestic 300DVB User manual

Majestic

Majestic Thulman L28A User manual

Majestic

Majestic NV360 Mounting instructions

Majestic

Majestic Ashland Series User manual

Majestic

Majestic ASH50 User manual

Majestic

Majestic SR/SC Series "A" SC36A Mounting instructions

Majestic

Majestic FSUV20 Operating instructions

Majestic

Majestic DV360 Mounting instructions

Majestic

Majestic SB5400 User manual

Majestic

Majestic Ruby User manual

Majestic

Majestic 32VFHNVC User manual

Majestic

Majestic VF User manual

Majestic

Majestic M28 User manual

Majestic

Majestic DV6000 User manual

Majestic

Majestic RUBY25IN User manual

Majestic

Majestic Vemont Castings RHE25 User manual

Majestic

Majestic Thulman L28A User manual

Majestic

Majestic B36LA Manual

Majestic

Majestic NVC36 Operating instructions

Popular Indoor Fireplace manuals by other brands

Brigantia

Brigantia 35-DVRS31N-2 User's installation, operation and maintenance manual

Nordpeis

Nordpeis Bergen Installation and user manual

Superior

Superior BCT2536TMN Installation and operation instructions

Quadra-Fire

Quadra-Fire 5100I-GD-B owner's manual

Renaissance

Renaissance RUMFORD 1000 user manual

Lacunza

Lacunza IV-800 Instruction book

Baxi

Baxi 940 Installer and owner guide

Dru

Dru Maestro 60/2 Tall RCH installation manual

Diamond Fireglass

Diamond Fireglass SS-O22 General assembly, installation, and operation instructions

HearthStone

HearthStone Windsor Bay 8830 Owner's manual and installation guide

Napoleon

Napoleon ASCENT B42 quick start guide

Enviro

Enviro E33GI owner's manual

Smeg

Smeg L30 FABE Installation & user's instructions

KEDDY

KEDDY K700 Installation instructions care and firing instructions

Godin

Godin 3451 manual

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Installation and operation instructions

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 operating manual

Desa

Desa CCFPDFT Owner's operating & installation manual