King-Griller 5252 User manual
OM5252 B.2 ™ & © Char-Griller / A&J Mfg.
Double Play Model# 5252
!
OWNER’S MANUAL
Charcoal and LP
Gas Grill
WARNING
For Outdoor Use Only
(outside any enclosure)
DANGER:
DO NOT use gas grill for indoor cook-
ing or heating. TOXIC fumes can accu-
mulate and cause asphyxiation. Do
not use in or on boats or recreational
vehicles.
PROP 65 WARNING:
Chemicals known to the state of Cali-
fornia to cause cancer, birth defects
or other reproductive harm are creat-
ed by the combustion of propane.
SAVE THESE INSTRUCTIONS FOR FU-
TURE REFERENCE. IF YOU ARE ASSEM-
BLING THIS UNIT FOR SOMEONE ELSE,
GIVE THIS MANUAL TO HIM OR HER TO
SAVE FOR FUTURE REFERENCE.
FOR CUSTOMER SERVICE, CALL 912-
638-4724
WARNING:
Improper installation, adjustment, al-
teration, service or maintenance could
cause injury or property damage Read
the installation, operation and mainte-
nance instructions thoroughly before
assembling or servicing this equip-
ment.
Failure to follow these instructions
could result in fire or explosion that
could cause property damage, person-
al injury or death.
A propane gas cylinder is required for
operation. This gas grill is not intended
for commercial use.
Keep your receipt with this manual for
Warranty.
Patented
OM5252 B.2 ™ & © Char-Griller / A&J Mfg. 2
! Danger
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open Lid.
4. If odor continues, keep away from the appliance and
immediately call your gas supplier or your fire depart-
ment.
! Warning
Do not store or use gasoline or other flammable liquids or va-
pors in the vicinity of this or any other appliance.
An LP cylinder not connected for use shall not be stored in the
vicinity of this or any other appliance.
For Your Safety
Stop! Call us first! Do Not return product to store. This grill has
been made to high quality standards. If you have any questions
not addressed in this manual or if you need parts please call our
customer service department at 1-912-638-4724 (USA), Mon-
day-Friday 8:30am-5pm (EST).
Have your grills serial number (located on the back of the grill
body or on the leg) when calling.
OM5252 B.2 ™ & © Char-Griller / A&J Mfg. 3
Page intentionally left blank for notes
OM5252 B.2 ™ & © Char-Griller / A&J Mfg. 4
WARNING
FOR YOUR SAFETY
1.DO NOT store or use gasoline or any other flammable vapors and liquids within 25 feet
(8m) of this or any other appliance.
2. When cooking with oil/grease, do not allow the oil/grease to exceed 350°F (177°C).
Do not store or use extra cooking oil in the vicinity of this or any other appliance.
3. An LP Cylinder not connected for use should be stored a minimum of 10 feet (3m)
away from this or any other appliance. Never fill the cylinder beyond 80 percent
full. If the above information not followed exactly, a fire causing death or serious
injury may occur.
4. If you smell gas:
- Shut Off gas to the grill.
- Extinguish any open flame.
- Open Lid
For Your Safety
Stop! Call us first! Do Not return product to store. This grill has been made to high
quality standards. If you have any questions not addressed in this manual or if you
need parts please call our customer service department at 1-912-638-4724
(USA), Monday-Friday 8:30am-5pm (EST).
NOTE: The use and installation of this product must conform to local codes. In absence
of local codes, use the National Fuel Gas Code, ANSI Z223.1/NFPA54.
IMPORTANT NOTICE: read all instructions prior to assembly and use.
Read and understand all warnings and precautions prior to operating your grill.
CAUTION
1.This grill is for use with propane gas only (propane gas cylinder not included).
2.Never attempt to attach this grill to the self-contained propane system of a camper
trailer, motor home or house.
3.Never use charcoal or lighter fluid with the gas grill.
4. Do not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must
be constructed and marked in accordance with the specifications for propane gas
cylinders of the U.S. Department of Transportation (DOT) CFR 49. This grill is not
intended to be used in or installed on recreation vehicles and/or boats.
5.Do not attempt to move the grill while it is lit.
6.Do not use the grill unless it is completely assembled and all parts are securely fas-
tened and tightened.
7.Keep all combustible items and surfaces at least 36 inches (91.4cm) away from grill
at all times.
8. DO NOT use this grill or any gas product near unprotected combustible constructions.
9. Do not use in an explosive atmosphere. Keep grill area clear and free from combus-
tible materials, gasoline and other flammable vapors and liquids.
OM5252 B.2 ™ & © Char-Griller / A&J Mfg. 5
10. Do not touch metal parts of grill until it has completely cooled (about 45 minutes) to
avoid burns, unless you are wearing protective gear (BBQ mittens, pot holders, etc.)
11. Do not alter this grill in any manner
12. Clean and inspect the hose before each use. If there is evidence of abrasion, wear,
cuts, or leaks, the hose must be replaced prior to operating the appliance. The re-
placement hose assembly will be that which is specified by the manufacturer.
13. Move gas hoses as far away as possible from hot surfaces and dripping hot grease.
14. Never Keep a filled container in a hot car or car trunk. Heat will cause the gas pres-
sure to increase, which may open the relief valve and allow gas to escape.
15. Keep the grill’s valve compartment, burners and circulating air passages clean. In-
spect the grill before each use.
WARNING
1. This grill is for outside use only, and should not be used in a building, garage or any
other enclosed area.
2. The use of alcohol, prescription or non-prescription drugs may impair the operator’s
ability to properly assemble or safely operate the grill.
3. Always open grill lid slowly and carefully as heat and steam trapped within the grill
can burn you severely.
4. Always place your grill on a hard, level surface far away from combustibles. An as-
phalt or blacktop surface may not be acceptable for this purpose.
5. Do not leave a lit grill unattended. Keep children and pets away form the grill at all
times.
6. Do not place this grill on any type of tabletop surface.
7. Do not use the grill in high winds.
8. Disconnect the propane tank (LP tank) by first turning off valve on top of propane
tank, turn off burner valves, then disconnect regulator from valve on propane tank
by turning plastic connector counter clockwise. Unscrew wing-bolt in bottom shelf to
release the tank for removal.
DANGER
Liquid propane (LP) gas is flammable and hazardous if handled improperly. Know its
characteristics before using any propane product.
1. Propane Characteristics; Flammable, explosive under pressure, heavier that air and
settles in pools and low areas
2. In its natural state, propane has no odor. For your safety, an odorant has been add-
ed.
3. Contact with propane can cause freeze burns to skin.
4. This grill is shipped from the factory for propane gas use only.
5. Never use a propane cylinder with a damaged body, valve, collar or footing.
6. Dented or rusted propane cylinders may be hazardous and should be checked by
your propane gas supplier.
OM5252 B.2 ™ & © Char-Griller / A&J Mfg. 6
1
3
5
6
7
8 9
10
11
14
12
16
17
20
19
20
21
22
23
24
25
26
27 28
28
29
2
4
13
15
30
31
32
33
34
18
26
35
OM5252 B.2 ™ & © Char-Griller / A&J Mfg. 7
ITEM QTY PART NAME PART NUMBER
1 1 GAS GRILL HOOD 30-0001
3 1 GAS GRILL BODY 30-0007
4 1 CHARCOAL GRILL BODY 30-0006
6 2 HOOD HANDLE 55-0002
7 2 WARMING RACK 20-0001
8 2 BURNER (short wire) 80-0001
9 1 BURNER (long wire) 80-0002
10 1 BASE 20-0009
11 3 FLARE-UP SHIELD 10-0001
12 1 FRONT SHORT LEG 20-0016
15 1 BACK LONG LEG 20-0019
16 2 BEZEL 10-0004
17 2 LEG CROSS BAR 10-0017
18 6 COOKING GRATE 10-0006
19 2 WHEEL 55-0006
20 2 LEG BRACE 10-0018
21 1 AXLE 10-0019
22 1 WIRE SHELF 20-0010
23 1 CONDIMENT BASKET 20-0011
24 1 SIDE BURNER/ CONTROL PANEL 80-0003
25 3 UTENSIL HOOK 50-0001
26 2 GREASE TRAY 10-0011
27 1 CATCH PAN 20-0012
28 2 DAMPER CIRCLE 10-0020
29 1 POT STAND 20-0005
2 1 CHARCOAL GRILL HOOD 30-0005
5 2 THERMOMETER 55-0001
13 1 BACK SHORT LEG 20-0017
14 1 FRONT LONG LEG 20-0018
30 2 FIRE GRATE HANGERS, 8.5 20-0024
31 2 HEAT SHIELD 10-0015
32 1 ASH PAN 20-0025
33 2 HUB CAP` 55-0007
34 1 SIDE HANDLE 20-0027
35 1 GRATE LIFTER 10-0045
OM5252 B.2 ™ & © Char-Griller / A&J Mfg. 8
¼-20x 1-½” BOLT……8 PCS
¼-20x1/2” BOLT….... 34 PCS
2/5” FLAT WASHER….2 PCS
¼” FLAT WASHER…16 PCS
¼-20 HEX NUT……..14 PCS
¼” LOCK WASHER…38 PCS
HINGE PINS………..2 PCS
LARGE HAIR COTTER PIN….2 PCS
SMALL HAIR COTTER PIN….6 PCS
CENTER HINGE PIN…...1 PC
¼-20x 2” BOLT……4 PCS
Assembly: Requires 2 people. Get another person to help. Tools Needed: Pliers, Phillips Head
Screwdriver and a 7/16” Nut Driver.
NOTE: Do Not tighten any bolts unless instructed to do so. Tightening too soon may prohibit
parts from fitting together. All Hex Nuts should be on the inside of the grill unless stated other-
wise. Unpack all contents in a well cleared and padded area. Estimated Assembly Time: 45
minutes STOP! Do Not Return to Store. If you are missing parts or need assistance please
missing parts. Hardware:
OM5252 B.2 ™ & © Char-Griller / A&J Mfg. 9
Step 1
Attach the LEG CROSSBAR to the frame as shown making sure that the holes on the
CROSSBAR are facing inward. See Below.
Leg Crossbar
Left Leg
Right Leg
Step 2
Attach Leg Assembly to the base using (4) 2” BOLTS and four (4) ¼” FLAT WASHERS
as shown. When you install the LEFT LEG & RIGHT LEG, make sure that the holes at
the top of the LEGS are facing out. Please note that the wheel legs have inside and
outside sides. Install one leg assembly at a time as shown.
On back LEG Assembly, insert an additional (2) ½”BOLTS and (2) ¼” FLAT WASH-
ERS as shown.
OM5252 B.2 ™ & © Char-Griller / A&J Mfg. 10
Step 4
Install the LEG BRACES to the LEGS using eight (8) LOCK WASHERS and eight (8)
½” BOLTS as shown. Remember to NOT tighten the bolts until completing step 6.
Step 3
Attach WIRE SHELF to the LEGS (as shown below).
Other manuals for 5252
1
This manual suits for next models
1
Table of contents
Other King-Griller Grill manuals
Popular Grill manuals by other brands
Kenmore
Kenmore 415.16123800 Use and care guide
Camp Chef
Camp Chef PG24CLAU Warning & instruction booklet
Tucker Barbecues
Tucker Barbecues GTR Series Assembly, installation and operating instructions
Monogram
Monogram ZGG540NCP1SS owner's manual
Equipex
Equipex Sodir Savoy Operation manual
Gaggenau
Gaggenau VR 414 610 use and care manual
