Kemlan CUBE Manual

Specialists in fireplace design and manufacture

KEMLAN CUBE

INSTALLATION & OPERATING INSTRUCTIONS

IMPORTANT:

INSTALLER, PLEASE LEAVE THESE INSTRUCTIONS WITH THE UNIT ON COMPLETION.

10 YEAR FIREBOX WARRANTY

The firebox is covered by a 10 year warranty.

Other parts are covered by a one year limited warranty.

Head Office –13 French Avenue, Brendale, Queensland 4500

Telephone –PH: (07) 3490 5500

Facsimile –FAX: (07) 3490 5520

Website: - www.jetmaster.com.au

Business hours: - Monday to Thursday 7:30am-4:00pm. Friday 7:30am-2:00pm

Email: - sales@jetmaster.com.au

DIMENSIONS

KEMLAN CUBE

A B C D E F G H

MEASUREMENT 522 499 705 510 218 353.5 568 526

Ver.20

450

06/06/2023 2

A B C D E F G H I J K

MEASUREMENT 120 300 125 338 654 540 1004 875 1114 570 300

MINIMUM CLEARANCES:

MINIMUM CLEARANCES FOR THE

KEMLAN CUBE

INSTALLED WITH DEFAULT FLUE KIT

Ver.20

1007

920

260 927 300

STEEL BENCH MEASUREMENTS:

FRONT VIEW

TOP VIEW

06/06/2023 3

Ver.20

HEARTH MEASUREMENT

Cube

A. UNIT HEIGHT ABOVE FLOOR 300 MIN.

B. HEARTH DIMENSION FORWARD OF UNIT 300

120

06/06/2023 4

Ver.20

AIR GAP DETAIL

06/06/2023

NOTE:- When installing this unit onto a table, make sure to leave the

4x bolts in place. The bolts are necessary to allow air flow to the

underside of the firebox. The removal of these bolts will lead to

overheating to the underside of the unit and eventually cause

malfunction. The removal of these bolts could void your warranty.

Ver.20

AIR GAP DETAIL

06/06/2023

The bolts will need to be removed when the appliance is installed onto a meridian

base. However, the same bolts must be used to fix appliance to the meridian base.

Air gap

There must be an air gap between the bottom of the appliance and the top of a

table. This is necessary to allow air flow to the appliance.

Meridian base

Table

Run a bead of silicone down

the vertical seam of the outer

casing to the flashing

10” Flue

KEMLAN CUBE

FLAT CEILING INSTALLATION

6” Flue

Flash roof to outer casing

(supplied by installer)

INSTALLATION INSTRUCTION

Pop rivet or

screw brackets to

the outside of the

outer casing

Short tube fits into flue

pipe. All flues should

be trimmed level

DETAIL A

8” Decro with double heat shield

Stainless steel flue pipe.

All flue pipes must be

connected with pop rivets

supplied by installer

All casing flue pipes must

be connected with pop

rivets supplied by installer

Flue system to be installed

to suit AS/NZS 2918.2001

Vented cap

Support outer flue with

Brackets supplied

Bracing supplied by installer

NOTE:- When Decromesh / Heatshield is fitted, it must

finish a minimum of 600mm below the ceiling or extend

through the ceiling drop box into the outer flue casing

8” Flue

DETAIL

All

8”-10” assembled flues must

have the crimps pointing upwards

crimped

plain

All 6” assembled flues must have

the crimps pointing downwards

crimped

plain

DETAIL D

Ver.20

06/06/2023 7

12mm

Air gap

Ceiling trim

DETAIL B

150

Run a bead of silicone down

the vertical seam of the outer

casing to the flashing

Raked ceiling trim

KEMLAN CUBE

RAKED CEILING INSTALLATION

Flash roof to outer

casing

(supplied by installer)

INSTALLATION INSTRUCTION

Pop rivet or

screw brackets to

the outside of the

outer casing

Short tube fits into flue

pipe. All flues should

be trimmed level

DETAIL A

DETAIL B

Stainless steel flue pipe.

All flue pipes must be

connected with pop rivets

supplied by installer

Flue system to be installed

to suit AS/NZS 2918.2001

Vented cap

Bracing supplied by installer

All casing flue pipes must

be connected with pop

rivets supplied by installer

12mm

Air Gap

8” Decro with double

heat shield

10” Flue

6” Flue

NOTE:- When Decromesh / Heatshield is fitted, it must

finish a minimum of 600mm below the ceiling or extend

through the ceiling drop box into the outer flue casing

8” Flue c

DETAIL

All

8”-10” assembled flues must

have the crimps pointing upwards

DETAIL D

All 6” assembled flues must have

the crimps pointing downwards

crimped

plain

crimped

plain

Ver.20

06/06/2023 8

Ver.20

SUPER NOVA / CUBE /TEMPO GRAND

BAFFLE PLATE INSTALLATON INSTRUCTIONS

1. MAKE SURE TO INSTALL AIR TUBE AS

REQUIRED. THE OPENING ON THE TUBE

END NEEDS TO BE AGAINST THE BACK

WALL. ALL ROUND EXIT HOLES MUST BE

POINTING TO THE BOTTOM OF THE FIRE

BOX OR THE SIDE WALLS.

2. CERAMIC BAFFLE PLATES SIZE

230mmX240mm. INSTALL THE BAFFLE

PLATE 230mm FRONT TO BACK, 240mm

SIDE TO SIDE. GET BAFFLE PLATE

INSIDE THE FIREBOX AND TILT ON AN

ANGLE. PUSH BAFFLE PLATE OVER

THE AIR TUBE

3. THEN MOVE SIDEWAYS UNTIL SUPPORTED

BY THE SUPPORT PLATE AND TOUCHING THE

SIDE WALL

4. REPEAT THE PROCESS FOR THE

OTHER SIDE. PUSH BOTH BAFFLE PLATES

UNTIL IT IS AGAINST THE SIDE AND REAR

WALLS.

06/06/2023 9

Ver.2006/06/2023 10

Table of contents

Other Kemlan Indoor Fireplace manuals

Kemlan

Kemlan Super Nova Freestanding Series II Manual

Kemlan

Kemlan XL Manual

Kemlan

Kemlan CELESTIAL 900 Manual

Kemlan

Kemlan Convectaire User manual

Kemlan

Kemlan Power Flue Horizon Gas Fireplaces User manual

Kemlan

Kemlan Super Nova Insert RF Manual

Kemlan

Kemlan Horizon 3 Sided User manual

Kemlan

Kemlan 700 Low Line User manual

Kemlan

Kemlan Super Nova User manual

Kemlan

Kemlan 700 Low Line User manual

Kemlan

Kemlan Horizon Natural Draft Electronic Ignition User manual

Kemlan

Kemlan Tempo Stack User manual

Popular Indoor Fireplace manuals by other brands

Brigantia

Brigantia 35-DVRS31N-2 User's installation, operation and maintenance manual

Nordpeis

Nordpeis Bergen Installation and user manual

Superior

Superior BCT2536TMN Installation and operation instructions

Quadra-Fire

Quadra-Fire 5100I-GD-B owner's manual

Renaissance

Renaissance RUMFORD 1000 user manual

Lacunza

Lacunza IV-800 Instruction book

Baxi

Baxi 940 Installer and owner guide

Dru

Dru Maestro 60/2 Tall RCH installation manual

Diamond Fireglass

Diamond Fireglass SS-O22 General assembly, installation, and operation instructions

HearthStone

HearthStone Windsor Bay 8830 Owner's manual and installation guide

Napoleon

Napoleon ASCENT B42 quick start guide

Enviro

Enviro E33GI owner's manual

Smeg

Smeg L30 FABE Installation & user's instructions

KEDDY

KEDDY K700 Installation instructions care and firing instructions

Godin

Godin 3451 manual

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Installation and operation instructions

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 operating manual

Desa

Desa CCFPDFT Owner's operating & installation manual