23
Use a slightly dampened cloth to clean the housing and lead sets. Do not use
solvents or soaps.
11. Place the power cords where they will not be stepped on, tripped over or
subjected to stress or abuse.
12. Never attempt to charge a frozen battery. Allow the battery to return to room
temperature before connection. Suggested operation range is 32°F (0°C) to
122°F (50 °C) in ambient temperature.
13. Never use the charger in or on any boat or watercraft directly. You must remove
the battery from the boat or watercraft and charge the battery at a properly
installed location.
14. Do not expose the charger to moisture or subject it to inclement weather.
B WARNING - RISK OF EXPLOSIVE GASES
1. Working in the vicinity of a lead-acid battery is dangerous. Batteries generate
explosive gases during operation. Thus, it is of utmost importance that you
follow the instructions each time you use the charger.
2. To reduce the battery explosion risk, follow these instructions and those published
by the battery manufacturer and manufacturer of any equipment you intend to use
in the battery’s vicinity. Observe cautionary markings on these items.
3. Someone should be within your voice range or close enough to come to your
aid when you work near a lead-acid battery.
4. Wear the proper eye, face and hand protection.
5. Avoid touching eyes while working near the battery.
6. Be extra cautious about reducing the risk of dropping a metal tool onto the
battery. It could spark or short-circuit the battery or other electrical parts and
could cause an explosion.
7. Remove personal metal items such as rings, bracelets, necklaces and watches
when working with a lead-acid battery. It can produce a short circuit current high
enough to weld a ring or the like to metal, causing a severe burn.
8. This appliance is not intended for use by persons (including children) with
reduced physical, sensory or mental capabilities, or lack of experience and
knowledge, unless they have been given supervision or instruction concerning
the appliance’s use by a person responsible for their safety.
9. If battery acid contacts the skin or clothing, wash immediately with soap and
water. If acid enters the eye, immediately ood the eye by running cold water
for at least 15 minutes and get medical attention right away.
10. NEVER smoke or allow a spark or ame in the vicinity of the battery or engine.
11. Use the charger for charging lead-acid batteries only. It is not intended to
supply power to a low voltage electrical system other than in a starter-motor
application. Do not use the battery charger for charging dry-cell batteries that
are commonly used with home appliances. These batteries may burst and cause
injury to a person and damage to property.
IMPORTANT SAFETY INSTRUCTIONS - READ THESE FIRST
A SAFETY
1. This manual contains important safety and operating instructions for this battery
charger/maintainer. Please read, understand and follow these instructions and
precautions carefully.
2. Use this charger on 6V and 12V lead-acid, AGM and gelled electrolyte (gel-cell)
batteries. Do not attempt to use other voltages and types of batteries (DRY
CELL, NICKEL CADMIUM, NICKEL METAL HYDRIDE, etc.) commonly found in
small home appliances. This may cause chargers and batteries to burst, resulting
in damage or injury to person and property.
3. Do not expose this charger to direct sunlight, rain or snow.
4. If the battery is installed, please ensure that the vehicle is turned off and no
accessory loads are present before attempting to charge.
5. Do not use attachments to this charger that are not recommended.
Nonrecommended accessories may result in injury, electric shock or re and
voids the warranty.
6. To reduce the risk of damage to electric plug and cord, pull by plug rather than
cord when disconnecting charger.
7. If it is necessary to use an extension cord, it should be an adequately grounded
cord. The use of an improper extension cord could result in a risk of re and
electric shock.
a. Ensure that the pins on the extension cord’s plug are the same number,
size and shape as those of the charger’s plug.
b. Ensure the extension cord is correctly wired and in good electrical
condition.
c. Ensure that the wire size is large enough for the AC ampere rating of
charger as specied in the AWG Size of Cord Table.
8. Do not operate charger with a damaged cord or plug – replace the cable or
plug immediately.
9. Do not operate the charger if it receives a sharp blow, has been dropped or
otherwise damaged; take it to an authorized service center.
10. To prevent injury during cleaning or maintenance, disconnect all batteries and
move them to clear access for the unit. Unplug the charger from the wall outlet.
AWG SIZE OF CORD
Length of cord, feet (m)
25 50 100 150
(7.6) (15.2) (30.5) (45.6)
18 18 18 16
