gourmetmaxx CG3023E User manual
LP Gas & Charcoal Grill LP Gas & Charcoal Grill LP Gas & Charcoal Grill LP Gas & Charcoal Grill
Model # CG3023 Model # Model # CG3023 Model # CG3023E
Assembly Instructions Assembly Instructions Assembly Instructions Assembly Instructions
Warnings Warnings Warnings Warnings
FOR YOUR SAFETY: FOR YOUR SAFETY: FOR YOUR SAFETY: FOR YOUR SAFETY:
1.Read this Grill Guide before attempting to assemble or
operate your grill.
2.Follow all safety instructions.
3.Check for leaks according to directions in this Grill Guide
before operating your grill, even if you purchased this grill
assembled.
4.Keep this Grill Guide for future reference.
THIS GRILL IS FOR OUTDOOR USE ONLY. THIS GRILL IS FOR OUTDOOR USE ONLY. THIS GRILL IS FOR OUTDOOR USE ONLY. THIS GRILL IS FOR OUTDOOR USE ONLY.
If stored indoors, then detach and leave propane cylinder
outside.
TO THE INSTALLER OR PERSON ASSEMBLING THIS GRILL: TO THE INSTALLER OR PERSON ASSEMBLING THIS GRILL: TO THE INSTALLER OR PERSON ASSEMBLING THIS GRILL: TO THE INSTALLER OR PERSON ASSEMBLING THIS GRILL:
Leave this Grill Guide with the consumer.
TO THE CONSUMER: TO THE CONSUMER: TO THE CONSUMER: TO THE CONSUMER:
Retain this Grill Guide for future reference.
2
Warnings Warnings Warnings Warnings
Safety Precautions
Always read and follow all DANGER, WARNING, AND FOR YOUR SAFETY notices in this Grill
Guide. Failure to follow these notices may result in property damage, bodily injury, or death.
1. Grill installation must conform with local codes, or in their absence, with either the National Fuel
Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or
Propane Storage and Handling Code, B149.2.
2. This gas grill, when installed, must be electrically grounded in accordance with local codes, or, in
the absence of local codes, with the National Electrical Code, ANSI Z21.58-2007, or the Canadian
Electrical Code, CSA 1.6-2007.
3. This gas grill is intended for outdoor use only, and should not be used in a building, garage, or any
other enclosed area.
4. This gas grill is not intended to be installed in or on recreational vehicles and/or boats.
5. Never use any other type of fuel for this grill other than LP gas (propane).
6. Only use the pressure regulator with a type 1 connector that is supplied with this gas grill
7. Before each use, check the gas hose for excessive abrasion, cracking, fraying, wear, or cuts.
Replace a hose assembly showing those signs with the hose assembly specified in the parts list
before using the grill.
8. Always perform a Leak Test before operating your grill.
!
WARNING
1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or
any other appliance.
2. An LP cylinder not connected for use should not be stored in the vicinity of this or any other
appliance.
!
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from appliance and call your local fire department.
3
Table of Contents
•Tools and Parts
•Hardware
•Assembly Instructions
•Care and Maintenance
•Warranty Information
4
2
1
Description
Screwdriver
(not provided)
Description
Adjustable wrench
(not provided)
Tools Required Tools Required Tools Required Tools Required
5
Parts List Parts List Parts List Parts List
Qty Picture Description H
Qty picture Description G
Qty Picture Description F
Qty Picture Description E
Qty Picture Description D
Qty Picture Description C
Qty Picture Description B
Qty Picture Description A
6
7
Hardware Hardware Hardware Hardware
8
Assembly Instructions Assembly Instructions Assembly Instructions Assembly Instructions
Step 1: Step 1: Step 1: Step 1:
Assemble the two middle panels (16, 18)
and four side panels (11,15, 27, 29).
Make sure to assemble the two middle
panels (16, 18) first.
Assemble two middle panels using
8-M6x12 Bolts (B), and assemble side
panels using 11-M6x12 Bolts(B) and
11-FLANGE LOCK NUTS (H).
See the illustration below.
Step 2: Step 2: Step 2: Step 2:
Assemble the ash pan (28) use
BOLT M6x12 (B) fasten the ash pan and
right middle panel. Then assemble the plug
(51). See the illustration below.
9
Assembly Instructions Assembly Instructions Assembly Instructions Assembly Instructions
Step 3: Step 3: Step 3: Step 3:
Attach the ash pan to the front and back
panels using 4-BOLT M6x12 (B) and
4-M6 FLANGE LOCK NUTS (H).
See the illustration below.
Step 4: Step 4: Step 4: Step 4:
Turn over the grill body and assemble
the left leg (38) and right leg (42) onto
the body using 8-BOLT M6x12 (B) and
6-M6 FLANGE LOCK BUTS (H).
Please do not tighten the screws
at this time.
10
Table of contents
Other gourmetmaxx Grill manuals
gourmetmaxx
gourmetmaxx KG 1000 User manual
gourmetmaxx
gourmetmaxx 22912A0 User manual
gourmetmaxx
gourmetmaxx 04488 User manual
gourmetmaxx
gourmetmaxx SLG5003-18 User manual
gourmetmaxx
gourmetmaxx Turbo Grill Deluxe SP-26B User manual
gourmetmaxx
gourmetmaxx XDE-3626 User manual
gourmetmaxx
gourmetmaxx 02874 Vario Chef 3-in-1 User manual
gourmetmaxx
gourmetmaxx Z 03036 User manual
gourmetmaxx
gourmetmaxx Keramik Chefgrill User manual
gourmetmaxx
gourmetmaxx KS-306 User manual
Popular Grill manuals by other brands
Kenmore
Kenmore 415.16123800 Use and care guide
Camp Chef
Camp Chef PG24CLAU Warning & instruction booklet
Tucker Barbecues
Tucker Barbecues GTR Series Assembly, installation and operating instructions
Monogram
Monogram ZGG540NCP1SS owner's manual
Equipex
Equipex Sodir Savoy Operation manual
Gaggenau
Gaggenau VR 414 610 use and care manual
