George Foreman GP200RED User manual

OWNER’S MANUAL

For Model: GP200RED

GEORGE FOREMAN

Portable Propane Grill

™

GP200RED IB_13-4-02 13/4/02 14:11 Page 2

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open Lid.

4. If odor continues, immediately call your gas supplier or your

fire department.

FOR YOUR SAFETY

1. Do not store or use gasoline or other flammable vapors and

liquids in the vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in

the vicinity of this or any other appliance.

WARNING

1. Do not store spare LP cylinder within 10 feet (3 m) of this

appliance.

2. Do not store or use gasoline or other flammable liquids or

vapors within 25 feet (8 m) of this appliance.

GP200RED IB_13-4-02 13/4/02 14:11 Page 3

IMPORTANT SAFEGUARDS

READ AND SAVE THESE INSTRUCTIONS

WARNING: A risk of fire or explosion exists in all propane grills.

Read this manual before use. Failure to follow all instructions

may result in serious personal injury, property damage, or death.

When using propane grills, basic safety precautions should always be

followed to reduce the risk of fire and injury to persons, including the

following:

1. Read all instructions before using the grill.

2. Do not touch hot surfaces. Use handles or knobs and oven mitts or

pot holders.

3. Keep children and pets away from the grill at all times.

4. This grill is not for use by children.

5. Do not leave this grill unattended while in use.

6. Do not move the grill when in use. Allow to cool before moving,

putting on or taking off parts, and before cleaning and storing the

grill.

7. To disconnect, turn Temperature Control Knob to LOCK/OFF.

8. Do not operate any grill after the grill malfunctions, or has been

dropped or damaged in any manner. Contact Consumer Service for

return authorization, examination, repair or adjustment.

9. The use of accessory attachments not recommended by the grill

manufacturer may cause injuries.

10. This grill is for outdoor use only. NEVER operate grill in enclosed

areas, as this could lead to gas accumulating from a leak, causing

an explosion or a carbon monoxide buildup which could result in

injury or death. DO NOT USE in garages, sheds or any enclosed

areas.

11. Do not use grill for other than intended use.

12. Extreme caution must be used when moving a grill containing hot oil

or other hot liquids. Allow liquid to cool before removing and empty-

ing Drip Tray. Do not remove Grill from Base until Grill is cool.

13. Do not attempt to dislodge food or clean the grill when it is hot.

14. Fuel, such as charcoal briquettes, is not to be used with this grill.

SAVE THESE INSTRUCTIONS

THIS GRILL IS NOT FOR COMMERCIAL USE.

FOR OUTDOOR USE ONLY.

GP200RED IB_13-4-02 13/4/02 14:11 Page 6

Additional Important Safeguards

1. CAUTION: This grill generates heat and escaping steam during use.

Proper precautions must be taken to prevent the risk of burns, fires or

other damage to persons or property. Use of protective oven mitts or

gloves is recommended.

2. All users of this grill must read and understand this Owner's Manual before

operating or cleaning this grill.

3. When using this grill, provide adequate air space above and on all sides for

air circulation. Do not allow this grill to touch clothing, dish towels or other

flammable materials during use.

4. IMPORTANT: Minimum clearance of 16 inches around all sides of the grill

should always be maintained and the appliance shall not be located under

overhead unprotected combustible construction.

5. If this grill begins to malfunction during use, immediately turn the

Temperature Control Knob to LOCK/OFF. Do not use or attempt to repair the

malfunctioning grill.

6. This outdoor cooking gas grill is not intended for use in or on recreational

vehicles and/or boats.

7. The use of alcohol, prescription or non-prescription drugs may impair the

consumer’s ability to properly assemble or safely operate the grill.

8. When cooking with oil/grease, fire extinguishing materials shall be readily

accessible. In the event of an oil/grease fire do not attempt to extinguish

with water. Use Type BC dry chemical fire extinguisher or smother fire with

dirt, sand or baking soda.

9. In the event of rain while cooking with oil/grease, turn off the grill burner

and gas supply, and immediately cover the Grill Plate. Do not attempt to

move the grill or Grill Plate.

10. When cooking, the grill must be on a level and stable surface in an area

clear of combustible materials. An asphalt surface (blacktop) may not be

acceptable for this purpose.

11. Make sure the grill is in the LOCK/OFF position when placing the Grill Plate

into position.

12. The grill is not intended for and should never be used as a heater.

13. Keep grill area clear and free from combustible materials, gasoline and

other flammable vapors and liquids.

14. Do not obstruct the flow of combustion and ventilation air.

15. Always remove lid before lighting your grill.

16. Do not attempt to disconnect the regulator or any gas fitting while the unit

is in operation.

17. Do not wear clothing with loose flowing sleeves while lighting or using the

grill.

18. Use barbecue tools with long, heat-resistant handles.

19. The grill should never face directly into the wind.

20. Do not operate Grill in a high-traffic area.

21. After use, allow Grill to cool completely before cleaning.

22. We recommend storing Grill indoors or, if unable to store indoors, always

cover Grill with protective cover. Always keep out of the reach of children.

GP200RED IB_13-4-02 13/4/02 14:11 Page 7

Special Instructions for the Use of Regulator

and LP (Propane) Cylinders

•The propane grill is equipped with a regulator

having a CGA No. 600 cylinder connection

device which is for connecting to a one pound

PROPANE cylinder ONLY. See Illustration.

•Grill installation must conform with local

codes, or in the absence of local codes, with

the National Fuel Gas Code, ANSI Z223.1,

Storage and Handling of Liquefied Petroleum

Gases, ANSI/NFPA 58 or CSA B149.1, Natural

Gas and Propane Installation Code.

•Use grill only with LP (propane) gas. Use grill only with the regulator/valve

assembly supplied.

•Never use charcoal briquettes or lighter fluid in a gas grill.

•Discard used and empty fuel cylinder in a safe place.

•Store spare fuel canisters in a well-ventilated area away from the grill.

•Do not puncture or burn fuel canister.

•Do not operate the grill if there is a gas leak present.

•Do not enlarge orifice or burner ports when cleaning the regulator and burner.

•If you smell gas, turn Temperature Control Knob to LOCK/OFF to shut off gas to

the grill. Extinguish any open flame and open Lid. If odor continues, immedi-

ately call your gas supplier or your fire department.

•Do not store or use gasoline or other flammable vapors and liquids in the

vicinity of this or any other grill.

•An LP cylinder not connected for use shall not be stored in the vicinity of this

or any other appliance.

•The LP-gas supply cylinder to be used must be constructed and marked in

accordance with the specifications for LP-gas cylinders of the U.S.

Department of Transportation (DOT) CFR 49 or the National Standard of

Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation

of Dangerous Goods.

•If the grill is not in use, the Temperature Control Knob must be turned to

LOCK/OFF to shut off the gas cylinder. Storage of a grill indoors is permissible

only if the cylinder is disconnected and removed from the grill. Cylinders must

be stored outdoors out of the reach of children and must not be stored in a

building, garage or any other enclosed area.

•The regulator may make a humming or whistling noise during operation. This

will not affect safety or use of grill.

•Save cylinder cap and reinstall when not in use.

•Cylinder supply system must be arranged for vapor withdrawal. The gas cylin-

der must be upright in use. Do not block the pressure relief valve during use

or storage.

•Always remove one pound cylinder from grill when transporting and when not

in use.

.550 Min

(13.96mm)

.850 - .935

(21.58 - 23.75mm)

.666 - .750

(16.92 - 19.05mm)

CGA No. 600

GP200RED IB_13-4-02 13/4/02 14:11 Page 10

Getting To Know Your GP200RED Propane Grill

1. Lid Handle/Vent (P/N 21659)

2. Lid Assembly (P/N 21680)

3. Screw/Washer (P/N 21661)

4. Ignitor Assembly (P/N 21648)

5. Ignitor Button

6. Temperature Control Knob (P/N 21647)

7. Regulator (P/N 21663)

8. Side Tray, Left (P/N 21688)

9. Flame Viewing Hole

10. Match Holder (P/N 21656)

11. Transport Handle (P/N 21684)

12. Wheel/Leg Frame (P/N 21681)

13. Wheel (2) (P/N 21687)

14. Securing Rod (P/N 21686)

15. Apron

16. Storage Arm (2) (P/N 21682)

17. Storage/Leg Frame (P/N 21685)

18. Base Plate (P/N 21683)

19. Burner Assembly

20. Side Tray, Right (P/N 21689)

21. Grill Base

22. Side Tray Support Tube/Locking Clip

(P/N 21690)

23. Drip Tray (P/N 21646)

24. Grill Plate (P/N 21645)

}

12 16

13 14 15

622

GP200RED IB_13-4-02 13/4/02 14:11 Page 11

Before First Use

1. Remove the Grill and any packaging materials.

2. Place the Base Frame on a flat, level surface.

3. Lift off the Side Trays and set them to the side. Disconnect the Storage

Arms from the Wheel/Leg Frame to allow access to the Grill Assembly.

4. Remove the Grill Plate, Grill Base, Lid and Drip Tray. Wipe the Grill Base and

Lid with a damp cloth to remove any dust. Wash the Grill Plate and Drip

Tray in warm, soapy water. Rinse

and dry thoroughly.

5. The Handle/Vent and mounting

hardware, (Screw/Washer) are

shipped in an inverted fashion,

requiring minor assembly.

Remove the Handle/Vent from

the inside of the Lid by unscrew-

ing the Screw/Washer. Remove

all parts, then properly position

the Handle/Vent on the top of the

Lid. Make sure the Handle/Vent stop pin enters the Vent slot in the Lid. From

the inside of the Lid, place the Screw/Washer through the hole in the Lid

and Handle/Vent. Securely fasten with a Phillips head screw driver. See

Figure 1.

6. Slide the Drip Tray into the slots in the Grill Base.

7. See "Grilling Positions" on the following pages and place the Grill Base on

the Base Frame.

8. Place the Grill Plate on the Grill Base and place the Lid over the Grill Plate.

Grill Positions

The Wheel-It and Grill-It™Portable

Propane Grill is compact enough to

transport to any grilling location.

Wheel-It from the storage shed to the

patio, to a picnic in the park, or off on

a camping trip. The Portable Propane

Grill easily transforms from storage to

transport and to high or low Grill-It

positions.

Storage Position: This position

makes the Grill compact enough for

space saving storage. The Side Trays

are stored on the Leg Assemblies and

the Transport Handle slides into the

top of the Frame.

Screw/Washer

Handle/Vent

Lid

Vent Slot

Figure 1

Figure 2

GP200RED IB_13-4-02 13/4/02 14:12 Page 14

Grill Positions (Cont.)

Transport Position: To

transform the Grill from

the Storage Position to

the Transport Position,

slide out the Transport

Handle from the closed

position

and roll away

Low Grilling Position:

Using the Grill in the

Low Position is great

for beach barbeques,

camping sites, tail-gate

parties or picnics in the

park.

To transform the Grill

from the Transport Position to

the Low Grilling Position, slide

the Transport Handle into the

Frame, remove both Side

Trays, then lay the GP200RED

down.

Disconnect the Storage Arms

from the Leg Assemblies. Lift

the Grill Assembly from the

Base Frame and set it to the

side, then reconnect the

Storage Arms.

Transport

Handle

Figure 3

Figure 4

Slots For

Drip Tray

Locator Pegs

GP200RED IB_13-4-02 13/4/02 14:12 Page 15

Grill Positions (Cont.)

Low Grilling Position, Continued: . Place the

Grill Base on the Base Frame by placing the

"slot" of the Hook Bracket around the Locator

Peg under the Base Frame. Align the hole in

the front of the Grill Base with the Locator Peg

on the front side of the Base Frame. Make

sure the Grill Base is secure. Place the Grill

Plate on the Grill Base. Slide the Side Trays

into position and attach the Drip Tray into the

slots.Attach the Propane Cylinder. See

'Attaching Propane Gas Cylinder' for details.

The Grill is ready for use.

Upright Grilling Position: This position is ideal

for patio use or any time you feel more com-

fortable Grilling in the standing position.

To transform the GP200RED from the Storage Position to the Upright Grilling Position, lay

unit down, with wheels on ground as seen in

Figure 4. Remove the Side Trays and discon-

nect the Storage Arms. Pull the Securing Rod

from its storage position. Raise the

Storage/Leg Frame upwards and hook the

Securing Rod into the opposing leg. Lift the

Grill Assembly. from the Base Frame, set it to

the side then raise the Frame upright,as seen

in Figure 6.

Place the Grill Base on the Leg Frame with the

Regulator on the same side as the wheels.

Hook the underside of the Grill Base to the

Frame with the Hook Bracket, then press down

evenly and firmly on the Base until the Spring

Lock 'snaps' into place. See Figure 7. Make sure

the Grill Base is secure. Place the Grill Plate,

Side Trays and Drip Tray in position. Attach the

Propane Cylinder as instructed in 'Attaching

Propane Gas Cylinder'. The Grill is ready for use.

Make sure the Drip Tray is in proper position,

and remember that the Grill should always be

operated with the Regulator on the left and the

Drip Tray in the rear.

NOTE: If the Lid is to be removed temporarily it

can be placed on the Base Frame as shown in

Figure 6.

CAUTION: Never use the Frame as a chair.

Never load anything on the frame except the

Grill. Never load over 6 1/2 lbs. (3kg) on each

Side Tray. It is advisable that two persons

assemble the grill.

Figure 6

Figure 5

Hook

Bracket

Spring Lock

Figure 7

'Slot'

GP200RED IB_13-4-02 13/4/02 14:12 Page 18

Attaching Propane Gas Cylinder

Turn the Temperature Control Knob to the

LOCK/OFF Position. Push the one pound

propane cylinder slightly into the valve

while turning counterclockwise until a snug

fit is obtained.

Testing for Leaks

SAFETY PRECAUTIONS:

•Test all gas connections for leaks before

using your propane grill.

•Test for leaks every time you connect

the gas supply.

•Do not smoke while checking for leaks.

•DANGER - Do not use an open flame to

check for gas leaks. Be sure there are

no sparks or open flames in the area

while you check for leaks. This will

result in a fire or explosion which can

cause serious bodily injury or death,

and damage to property.

•Test for leaks outdoors in a well venti-

lated area.

1. Mix a couple tablespoons of liquid

detergent with an equal amount of

water. Use mild soap and water. DO

NOT USE HOUSEHOLD CLEANING

AGENTS.

2. Be sure that the Temperature Control

Knob is in the LOCK/OFF position.

3. Use a clean paint brush to brush soapy solution onto connection

between gas cylinder and Regulator orifice, and watch for bubbles.

4. If bubbles form or if a bubble grows, there is a leak. Retighten connec-

tion and repeat steps (2) and (3).

NOTE: If you cannot stop a leak, remove gas cylinder and check for dam-

aged threads, dirt and debris at the connection and gas cylinder. Also check

to see if anything is obstructing flow of gas at the connection and gas cylin-

der openings. Remove any obstruction that may be found and repeat leak

test.

Checking the Ignitor:

•The Temperature Control Knob must be in the “LOCK/OFF” position.

Press the Ignitor button rapidly. A “CLICK” should be heard and spark

seen through Flame Viewing Hole.

Propane

Cylinder

Regulator

Assembly

(P/N 21663)

Figure 8

GP200RED IB_13-4-02 13/4/02 14:12 Page 19

Table of contents

Other George Foreman Grill manuals

George Foreman

George Foreman G-broil GRP72CTB Installation instructions

George Foreman

George Foreman SmartTemp Grill Installation instructions manual

George Foreman

George Foreman GBZ0103B User manual

George Foreman

George Foreman 25040-56 User manual

George Foreman

George Foreman GGR57 User manual

George Foreman

George Foreman GR390FP User manual

George Foreman

George Foreman GR340FB User manual

George Foreman

George Foreman Power Grill Supreme GR72RTP User manual

George Foreman

George Foreman RPGD3994 SERIES User manual

George Foreman

George Foreman GRP46R Installation instructions

George Foreman

George Foreman GR26EVT User manual

George Foreman

George Foreman GR1036BTR User manual

George Foreman

George Foreman GR20840AU User manual

George Foreman

George Foreman GR0038 User manual

George Foreman

George Foreman GRES060BSC User manual

George Foreman

George Foreman GRP4 Installation instructions

George Foreman

George Foreman GFO201RX User manual

George Foreman

George Foreman GBQ440 User manual

George Foreman

George Foreman 14181 User manual

George Foreman

George Foreman GRP100CAN The Next Grilleration User manual

George Foreman

George Foreman GR136B127V User manual

George Foreman

George Foreman GPA12RL User manual

George Foreman

George Foreman GRP360 Installation instructions

George Foreman

George Foreman GR31SB User manual

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide

Stalgast

Stalgast 9730100 instruction manual