Gasmate BQ1076 User manual

Important: Retain these instructions for future use.

Powerful 8MJ/h stainless steel burner for true

BBQ performance

Piezo ignition for easy lighting

Generous cooking area of 45 x 29cm

Reversible satin enamel cast iron cooking surface

Complete unit packs down into sturdy storage

and carry case

Includes stainless steel braided hose to suit

3/8” BSP LH cylinders

Gas certiﬁed to Australian Standards

Model No. BQ1076

03617 09/17

Gasmate® is a registered trademark of

Sitro Group Australia Pty Ltd www.gasmate.com.au

Aber, N.Z. www.gasmate.co.nz

For any queries or assistance call

Customer Service (Australia Only)

1300 174 876

Hours of operation: Monday to Friday 8am - 5pm EST

Do not return to place of purchase.

Keep your purchase receipt, this will be required to

make any claims under the 12 month warranty.

READ ME FIRST

GAS LEAK TESTING

It is important that you leak test the BBQ before ﬁrst use and every time the gas

cylinder is reﬁlled and reconnected to the BBQ.

To Complete Leak Test

• In a small container, mix up a solution of water and detergent/soap.

• Mix the solution well (about the same concentrate as washing up water).

• Turn the cylinder ON by rotating the knob to open position.

• Using a brush or spray bottle apply the soap solution to the gas line and each

join in the gas line including:

- the gas connection at the inlet of the BBQ

- all gas hose connections

- the gas connection at the gas cylinder

• If bubbles appear, there is a gas leak.

• If the leak is at the connection, re-tighten and re-seal.

• If the leak is anywhere else or you cannot resolve the leak by tightening the

connection DO NOT PROCEED.

• Replace gas hose

• Replacement hose can be purchased from your local BBQ retail specialist.

GENERAL INFORMATION

Barbecues for use with bottled gas are labelled

‘propane gas’.

Clearances

Minimum Clearances from combustible materials

must be:

Rear - 300mm

Sides - 300mm

Above - 1000mm

Speciﬁcations

Barbecue speciﬁcations can be found on the

data label attached to the barbecue body.

Hose connection thread is 1/4” B.S.P.

IMPORTANT

Read these instructions carefully prior to

use. Familiarise yourself with the appliance

before connecting it to it’s gas container.

Keep these instructions for future reference.

IF YOU SMELL GAS

1. Shut off gas to the barbecue at its

source, if possible.

2. Extinguish any open ﬂame.

3. If odour continues immediately call your

gas supplier or ﬁre department.

Hose Safety

When connecting the hose assembly to the gas

cylinder, take care to avoid unnecessary twisting

of the ﬂexible hose.

After the assembly has been secured, turn on

the gas and check for leaks by brushing a soap

and water solution over all connections.

If you are unable to correct the leak by tightening

the connections, turn off the gas and contact the

supplier immediately.

Always ensure the barbecue is kept away from

ﬂammable materials and the gas cylinder clear of

any heat source.

When changing over from an empty gas cylinder

to a full one make sure this procedure is carried

out in a well ventilated location, preferably

outside, away from people and away from any

sources of ignition; such as naked ﬂames, pilot

ﬂames, electric heaters/equipment.

Gas Cylinder Use & Safety

This is a high pressure barbecue and must only

be used as supplied. Your barbecue is designed

for use with camping gas cylinders certiﬁed to

AS 2469.

The gas cylinder should be ﬁlled by a reputable

gas supplier and visually inspected and re-

qualiﬁed at each ﬁlling.

Always keep cylinder in an upright position.

Always close the cylinder valve when the

barbecue is not in use.

Do not subject gas cylinder to excessive heat.

NEVER STORE YOUR GAS CYLINDER INDOORS.

If you store your barbecue indoors, ALWAYS

disconnect the gas cylinder ﬁrst and store the

cylinder safely outside.

Cylinders must be stored outdoors in a well

ventilated area out of reach of children, and must

not be stored in a building, garage or any other

enclosed area.

FOR YOUR SAFETY

Failure to comply with these instructions

could result in a ﬁre or explosion which

could cause serious bodily injury, death or

property damage.

CAUTION: Accessible parts may be very

hot.

Keep young children away.

DO NOT modify this appliance.

DO NOT move this barbecue during use.

Turn off gas supply at the gas cylinder after

use.

Parts sealed by the manufacturer or their

agent must not be manipulated by the user.

This barbecue is only to be used and stored

outdoors.

• Do not test for gas leaks with an open

ﬂame.

• If this information is not followed exactly

a ﬁre causing death or serious injury

may occur. Do not store a spare gas

cylinder under or near this barbecue. This

barbecue is only to be used and stored

outdoors.

• If there is a leak on your appliance (smell

of gas) immediately attempt to turn off

the cylinder valve. Remove the appliance

to a well ventilated location away from

any ignition source. Only check for leaks

outdoors using soapy water. DO NOT try

to detect leaks using a ﬂame.

• Check for leaks by brushing a soap and

water solution over all connections. If

you are unable to correct the leak by

tightening the connections, turn off

the gas and contact customer service

immediately.

GENERAL INFORMATION

• Only use the hose assembly as supplied

with this appliance for connection to the

cylinder - DO NOT USE ADAPTERS.

• Maximum hose length - 1000mm.

• After use turn the gas cylinder valve off

and wait for the ﬂame to go out.

• Avoid twisting or kinking the ﬂexible

hose.

• Do not store or use petrol or other

ﬂammable liquids in the vicinity of this or

any other appliance.

• Do not store empty or full spare gas

cylinders under or near this or any other

appliance.

• Never test for gas leaks with a lit match

or open ﬂame.

• Never lean over cooking surface when

lighting.

• Never alter or modify the gas supply

assembly.

• This barbecue must not be used indoors.

• Only use in well ventilated areas.

• CARBON MONOXIDE HAZARD - USING

THIS APPLIANCE IN AN ENCLOSED

SPACE MAY CAUSE DEATH. DO NOT

USE IN CARAVANS, TENTS, MARINE

CRAFT, CARS, MOBILE HOMES OR

SIMILAR LOCATIONS.

• Ensure the barbecue is set up on a level

and stable surface.

• Do not move the barbecue while in use

or when hot.

• Do not use this appliance if it is leaking,

damaged or does not operate properly.

IF THERE IS A LEAK

• Turn the cylinder off.

• Ventilate the area to disperse gas.

• Check all connections.

• If leak persists, keep the cylinder upright.

Keep skin away from any gas or liquid

escaping from the cylinder.

• Keep the cylinder at least 20 metres

away from any sparks or ignition sources,

including electrical equipment, camera

ﬂashes, engines and motors.

• Disperse gas by encouraging maximum

ventilation and spraying with a ﬁne water

spray.

IF THERE IS A FIRE

• If the ﬁre is at the barbecue, turn the gas

off at the cylinder. Smother the ﬂames

with a wet cloth, ﬁre blanket or extinguish

using a ﬁre extinguisher.

• If the ﬁre is at the cylinder, or you can

not get to the valve to turn the gas off,

contact the ﬁre brigade immediately.

• Using a garden hose, direct the water to

the middle of the cylinder to keep it cool.

Try not to extinguish the ﬂame. At least

if the gas is burning, it won’t be able to

build up pressure and explode.

Location of your Barbecue

DO NOT use your barbecue in garages, porches,

sheds, breezeways, or other enclosed areas.

Your barbecue is to be used OUTDOORS. The

barbecue is not intended to be installed in or on

recreational vehicles and/or boats and should

not be placed under any surface that will burn.

Do not obstruct the ﬂow of combustion and

ventilation air around the barbecue housing.

Protect Children

Keep children away from barbecue during

use and until barbecue has cooled after you

have ﬁnished. Do not allow children to operate

barbecue.

Always ensure that no sporting or physical

activities are carried out in close proximity to the

barbecue during use and while still hot.

Check Barbecue for any Damage

Inspect barbecue parts as you proceed.

Contact your supplier for assistance regarding

replacement of any damaged or missing parts.

Do not assemble or operate a barbecue that

appears damaged. Barbecues for use with gas

cylinders are labelled ‘Propane Gas’.

This appliance is designed to use a camping gas

cylinder.

IT MAY BE HAZARDOUS TO ATTEMPT TO

FIT OTHER TYPES OF GAS CONTAINERS.

Check labelling at the gas connection on your

barbecue.

Nominal Hourly Gas Consumption

Main Burner

Gas Type Propane

Inj. Size 0.138 mm

Gas Cons. 8 MJ/h

Gas Pressure Cylinder

GENERAL INFORMATION

CONNECTING & DISCONNECTING

TO GAS SOURCE

Familiarise yourself with the general information

and safety guidelines located at the front of this

manual.

Check

1. Gas cylinder is ﬁlled. A sloshing sound will be

heard when shaken.

Connecting

1. Ensure valve is in OFF position.

2. Check for any damage to the cylinder

connection.

3. Attach the hose to the cylinder valve and

tighten ﬁrmly with a spanner.

4. Use a soapy water solution to check the joint. If

bubbles appear the connection will need to be

re-tightened.

LIGHTING PROCEDURE

Burner Operation & Ignition System Check

1. With cylinder valve in ‘OFF’ position check the

piezo igniter by pushing in. Check for sparking to

the burner.

2. If spark is not evident at the burner ignition point,

check that the ignition lead is ﬁrmly attached to

the control and sparker tip.

3. With sparking established install the hotplate

and open the cylinder valve whilst pushing the

igniter.

4. If the burner fails to light after several attempts turn

off gas and inspect for obstructions to gas ﬂow.

If re–ignition is necessary while the gas barbecue is

still hot, you must wait for a minimum of 5 minutes

before commencing to re–ignite (this allows

accumulated gas fumes to clear).

Overall Barbecue Dimensions

Length Width Height

500mm 300mm 290mm

IMPORTANT

• CAUTION: When the barbecue is

not in use, the gas cylinder must be

disconnected.

• Check that the seals between the

appliance and the gas cylinder are in place

and in good condition before connecting

the gas cylinder.

• Do not use this appliance if it has

damaged or worn seals.

• NOTE: If for some reason, ignitor fails

to produce a spark at the electrode,

barbecue can be lit by a long barbecue

match.

• Do not smoke when attempting to ignite

barbecue.

• Always use protective gloves when

handling hot components.

OPERATION

IMPORTANT

Do not smoke at any time when attempting

to ignite the barbecue burners.

Do not leave the barbecue unattended

when alight.

BURNER OPERATION & IGNITION SYSTEM CHECK

Problem Possible Reason Solution

Burner will not ignite

No gas Replace gas cylinder

Piezo igniter is faulty Use a long barbecue match

Food is not cooking

or is taking too long

Burner has gone out Check that the gas bottle is not empty

and re-ignite the burner

Cooking surface was not given

enough time to warm up before

the food was applied

Remove the food and give the burner time

to warm the cooking surface (5-10 mins)

There is too much food on the

cooking surface Cook smaller portions

ASSEMBLY

Slide the four legs into the holders on the

underside of the body.

Insert the bayonet tube into the centre hole

rotating it clockwise and ensure it is securely

attached.

Attach the hose to the 3/8” BSP LH ﬁtting of the

gas cylinder and tighten ﬁrmly with a spanner.

SERVICING

Servicing should be conducted every year or

sooner if required.

The appliance must only be serviced by an

authorised person.

This appliance shall only be used in an above ground open-air situation with natural ventilation,

without stagnant areas, where gas leakage and products of combustion are rapidly dispersed by

wind and natural convection.

Any enclosure in which the appliance is used shall comply with the following:

An enclosure with walls on all sides, but at least one permanent opening at ground level and no

overhead cover.

Within a partial enclosure that includes an overhead cover and no more than two walls.

Within a partial enclosure that includes an overhead cover and more than two walls,

the following will apply:

at least 25% of the total wall area is completely open, and

at least 30% of the remaining wall area is open and unrestricted.

In the case of balconies, at least 20% of the total wall area shall be and remain open

and unrestricted.

SAFE APPLIANCE LOCATIONS

DIAGRAMMATIC REPRESENTATIONS OF OUTDOOR AREAS

The following ﬁgures are diagrammatic representations of outdoor areas. Rectangular areas have been

used in these ﬁgures – the same principles apply to any other shaped area.

This manual suits for next models

Table of contents

Other Gasmate Grill manuals

Gasmate

Gasmate GALAXY BQ1190BLB User manual

Gasmate

Gasmate TELLUS 4 User manual

Gasmate

Gasmate Gemini GM172-120 User manual

Gasmate

Gasmate ODYSSEY 2T User manual

Gasmate

Gasmate AVENIR GM174-054 User manual

Gasmate

Gasmate ADVENTURER DELUXE 1 User manual

Gasmate

Gasmate Odyssey User manual

Gasmate

Gasmate CATERER 6 User manual

Gasmate

Gasmate BBQ 1010 User manual

Gasmate

Gasmate ADVENTURERDELUXE 2 User manual

Gasmate

Gasmate GM174-045 User manual

Gasmate

Gasmate Nebula 6420 User manual

Gasmate

Gasmate BQE303 User manual

Gasmate

Gasmate NOVA BQ2090 User manual

Gasmate

Gasmate VOYAGER BQ1075 User manual

Gasmate

Gasmate Odyssey User manual

Gasmate

Gasmate Horizon GM172-008 User manual

Gasmate

Gasmate BQ3471 User manual

Gasmate

Gasmate Ignite BQIG10 User manual

Gasmate

Gasmate ODYSSEY2 User manual

Gasmate

Gasmate HOT 0ZI II Series User manual

Gasmate

Gasmate ODYSSEY2T BQ1062 User manual

Gasmate

Gasmate BQ8342 User manual

Gasmate

Gasmate TELLUS GM165-023 User manual

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide