EvenGlo GA301M User manual

LT071 Oct. 4, 2018

563 Barton Street

Stoney Creek ON L8E 5S1 Canada

www.irenergy.ca

WARNING:

California Proposition 65

This appliance, its related accessories and by-product of

operation, contain chemicals known to the State of California

to cause cancer and birth defects or other reproductive harm.

For more information go to www.P65Warnings.ca.gov.

Series GA301

Models U, T, H, M, MP

DANGER: If you smell gas:

1. Shut off gas to appliance.

2. Extinguish any open flame.

3. If odour continues,

immediately call your gas

supplier.

WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury

or property damage. Read the installation, operating and maintenance instructions thoroughly before

installing or servicing this equipment.

FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapours and liquids in the

vicinity of this or any other appliance. An LP cylinder not connected for use shall not be stored in the

vicinity of this or any other appliance.

IMPORTANT: The installer or seller must leave these instructions with the owner. Only those who are

certified to do so should perform service on these heaters.

Please retain these instructions for future reference.

* FOR OUTDOOR USE ONLY: The evenGLO® heater has been approved for indoor use in non-

residential applications. (See page 8 for details) for natural gas units ONLY!

Even-GLO™ Series GA301 Page 2 Oct. 4, 2018

Table Of Contents

CAUTION AND GENERAL SAFETY............................................................................................... 3

PRE-INSTALLATION OVERVIEW .............................................................................................. 4-8

WHAT YOU WILL RECEIVE ...................................................................................................................... 4,5,6,7

MOUNTING PLATE HOLE PATTERN.................................................................................................................... 8

WHAT YOU NEED TO SUPPLY ........................................................................................................................... 9

LOCATION PLANNING ............................................................................................................. 10

GENERAL LOCATION LAYOUTS ........................................................................................................................ 10

SAFETY REQUIREMENTS ................................................................................................................................ 10

SPECIFICATIONS / DETAILS................................................................................................. 11-16

EQUIPMENT DIMENSIONS.................................................................................................................... 10,11,12

Floor Mount Models # GA301 & GA301 - T...................................................................................................... 11

Hanging Model # GA301- H .............................................................................................................................. 12

Floor Mount & Portable Models # GA301- M & GA301 - MP .......................................................................... 13

CLEARANCE TO COMBUSTIBLES....................................................................................................................... 13

INSTALLATION /CODE REQUIREMENTS ............................................................................................................ 15

POWER &GAS SPECIFICATIONS...................................................................................................................... 16

ASSEMBLY & INSTALLATION INSTRUCTIONS ........................................................................... 17

PORTABLE..............................................................................................................................................17-21

FLOOR MOUNT....................................................................................................................................... 22-27

CEILING MOUNT .....................................................................................................................................28-35

HEATER POSITION ........................................................................................................................................ 36

SECURE HEATER........................................................................................................................................... 37

LIGHTING & SHUTDOWN INSTRUCTIONS ........................................................................... 38-40

MAINTENANCE & TROUBLESHOOTING............................................................................... 41-45

MODELS GA301, GA301-T &GA301-H.......................................................................................................... 41

MODELS GA301-M &GA301-MP .............................................................................................................42-45

PARTS LIST ........................................................................................................................ 46-49

MODELS GA301-H ...................................................................................................................................... 46

MODELS GA301-U, GA301-T ....................................................................................................................... 47

MODELS GA301-M &GA301-MP ............................................................................................................. 48,49

WIRING DIAGRAMS ........................................................................................................... 50-52

WARRANTY ............................................................................................................................ 53

Even-GLO™ Series GA301 Page 3 Oct. 4, 2018

Caution and General Safety

At all times maintain clearance to combustible materials as further specified in

this manual. Failure to do so can result in serious fire hazard.

Never operate heaters in atmosphere containing flammable vapours or

combustible dusts.

This heater is equipped with an electronic and automatic ignition device. Do not

attempt to light the burner by hand. Failure to comply can result in a serious fire

and personal injury hazard.

Certain materials, when stored under this heater are subjected to radiant heat

can soften, distort or otherwise be damaged, special care should be taken of

plastic materials

Appliance surfaces, other than the obvious flame and emitter surfaces, attain

elevated temperatures during operation. Do not touch the heater head during

operation. Everyone should be alerted to this hazard to avoid burning.

Children should be strictly supervised when in the area of this heating appliance.

Playing or running around the structure should be strictly forbidden.

Clothing or other flammable materials should not be hung on or near this heater.

CAUTION: FIRE OR BURN INJURY HAZARD

Even-GLO™ Series GA301 Page 4 Oct. 4, 2018

Pre-installation Overview

What You Will Receive:

evenGLO GA301 Models U & T:

Even-GLO™ Series GA301 Page 5 Oct. 4, 2018

Pre-installation Overview

What You Will Receive:

evenGLO GA301 Model MP:

Even-GLO™ Series GA301 Page 6 Oct. 4, 2018

Pre-installation Overview

What You Will Receive –CONTINUED:

evenGLO GA301 Model MP: Hose Kits

DESCRIPTION

PART #

EG065 –12’ HOSE KIT

EG066 –15’ HOSE KIT

**NG REGULATOR



QD SOCKET –½” – NG



REGULATOR MOUNTING

BRACKET w/ ½” CLOSE

NIPPLE



½” X 12’ NG SUPPLY HOSE



½” X 15’ NG SUPPLY HOSE



** NG Regulator will be secured in position on the Mounting Bracket w/ Nipple attached.

NG Supply Hose w/Quick Disconnect ½” QD Socket NG Regulator w/Mounting Plate & Nipple

Even-GLO™ Series GA301 Page 7 Oct. 4, 2018

Pre-installation Overview

Hardware Kits

MODEL GA301-MP:

EH001: Top Reflector to Support Arms (Blue Tape)

EH027: 1/4”-20 x 1/2” S.S Carriage Bolt (x4), CH143: 1/4” S.S Flat Washer (x4), EH028

1/4”-20 S.S Acorn Nut (x4)

EH084: Housing Top Cover to Base Housing (Yellow Tape)

EH042: 8-32 x 3/8” 18-8 S.S Button Socket Cap Screw (x4), EH062: 3/32” Allen Key

(x1)

EH085: Heater Head to Pole Neck (Green Tape)

EH041: #10 –24 S.S Button Socket Cap Screw (x4), EH063: 1/8” Allen Key (x1)

EH086: Pole Flange to Bottom Base (Black Tape)

EH057:3/8” –16 S.S Nylon Insert Lock Nut (x4), EH056: 3/8” S.S Flat Washer 0.875”

OD (x4)

EH087: Pole Neck to Pole (Orange Tape)

EH070: 5/16” – 18 X ½” 18 – 8 S.S Button Socket Cap Screw (x4), EH081: 5/16” S.S

Internal Lock Washer (x4) EH072: 5/16” – 18 Brass Nylon Insert Lock Nut (x4), EH088:

5/16” Allen Key (x1)

MODEL GA301-M:

EH001: Top Reflector to Support Arms (Blue Tape)

EH027: 1/4”-20 x 1/2” S.S Carriage Bolt (x4), CH143: 1/4” S.S Flat Washer (x4), EH028

1/4”-20 S.S Acorn Nut (x4)

EH085: Heater Head to Pole Neck (Green Tape)

EH041: #10 –24 S.S Button Socket Cap Screw (x4), EH063: 1/8” Allen Key (x1)

EH087: Pole Neck to Pole (Orange Tape)

EH070: 5/16” – 18 X ½” 18 – 8 S.S Button Socket Cap Screw (x4), EH081: 5/16” S.S

Internal Lock Washer (x4) EH072: 5/16” – 18 Brass Nylon Insert Lock Nut (x4), EH088:

5/16” Allen Key (x1)

MODEL GA301-U, GA301-T:

EH001: Top Reflector to Support Arms (Blue Tape)

EH027: 1/4”-20 x 1/2” S.S Carriage Bolt (x4), CH143: 1/4” S.S Flat Washer (x4), EH028

1/4”-20 S.S Acorn Nut (x4)

EH021: Pole Package

MODEL GA301-H

EH001: Top Reflector to Support Arms (Blue Tape)

EH027: 1/4”-20 x 1/2” S.S Carriage Bolt (x4), CH143: 1/4” S.S Flat Washer (x4), EH028

1/4”-20 S.S Acorn Nut (x4)

EH022: Hanging Package

Even-GLO™ Series GA301 Page 8 Oct. 4, 2018

Pre-installation Overview

Mounting Plate Hole Pattern

(Full size)

Ø0.42"

6.30"

Even-GLO™ Series GA301 Page 9 Oct. 4, 2018

Pre-installation Overview

What You Need to Supply

1. Heater anchoring hardware for either the moveable base, flange base mount

or the hanging model.

2. Materials necessary to construct a concrete base for floor mounted model for

GA301-U & GA301-T only.

3. Gas supply line that is installed to the Gas and Electric Supply according to

the: National Fuel Gas Code, ANSI Z.223.1 (NFPA 54) in the US and Natural

Gas and Propane Installation Code, CSA B149.1 or Propane Storage and

Handling Code, B149.2 in Canada.

4. Electrical supply rated at 24 VAC with two stage control for GA301-U, GA301-

H &GA301-T only.

Even-GLO™ Series GA301 Page 10 Oct. 4, 2018

Location Planning

General Location Layouts

One Even-GLO heater, at high fire and in windless conditions, has a comfort

radius of about twelve feet (24 ft. circle).

A series of heaters providing area heat should be placed about 14-20 feet apart.

Wind protection has an important influence on the body’s ability to retain radiant heat.

Use natural or newly built wind barriers where possible, such as existing buildings,

shrubbery or tree lines and fences. A clear plastic six-foot fence is used in some

commercial restaurants to give an open look while giving good wind protection.

A patio that has been almost entirely closed in with a roof and windbreak walls or

a tent may be considered an indoor location by some code authorities. The Even-

GLO heater has been approved for indoor use in non-residential applications

(Natural Gas Models ONLY). Venting of the flue gases is accomplished by means

of an interlocked fan. Refer to the National Fuel Gas Code, ANSI Z.223.1 (NFPA

54) in the US and CAN/CGA B149.1 and B149.2 Installation Codes in Canada.

Safety Requirements

1. Never locate the heater directly below electrical lines, gas lines or sprinkler

systems.

2. Do not locate heater too close to vinyl or plastic wall coverings. These

materials may discolour or soften well before they reach combustible limits.

3. The heater requires a minimum clearance from combustible materials. See

the Clearance to Combustible Materials section for specific requirements.

4. Always allow room for removal of the top reflector and heater head for

maintenance purposes.

5. The heater aspirates air for combustion. Do not locate heater where there are

severe draft conditions or airflow restrictions to the heater head base.

NOTE: Sprinkler head heat fuse link performance may alter with age.

WARNING!

This heater is NOT approved for any indoor Residential

application. If in doubt of your application consult with your

local fire marshal or gas authority having jurisdiction. Indoor

spaces include but are not limited to attached garages,

solariums, living quarters etc.

This manual suits for next models

Table of contents

Other EvenGlo Patio Heater manuals

EvenGlo

EvenGlo GA 301 H Instruction manual

EvenGlo

EvenGlo GA201M Owner's manual

EvenGlo

EvenGlo GA201M2 Manual

EvenGlo

EvenGlo GA 301 H User manual

EvenGlo

EvenGlo GA201M2 Owner's manual

EvenGlo

EvenGlo GA 301 Manual

Popular Patio Heater manuals by other brands

empasa

empasa HMXD-E-NHS operating instructions

Sunred

Sunred Indus manual

HEAT1

HEAT1 ECO pro-line 2300W instructions

Heatmaxx

Heatmaxx SRPH98 instruction manual

Sunjoy

Sunjoy A30600640 manual

Event Furniture

Event Furniture 16091 Operating & safety guide

Prem-I-Air

Prem-I-Air EH1462 manual

Blumfeldt

Blumfeldt 10028637 manual

Sunjoy

Sunjoy L-PH011PSS-2 owner's manual

Melissa

Melissa 670-202 user guide

Quality Heating

Quality Heating THE-12DW manual

DCS

DCS PHFS-P4 Use and care and installation guide

EUROM

EUROM 334241 instruction manual

Lava Heat

Lava Heat Venetian owner's manual

EHS Ltd.

EHS Ltd. HQH-2000W instruction manual

VONROC

VONROC ALICUDI PH515AC Original instructions

OZONA

OZONA Heatflow IF010997 Safety instructions and operation manual

theBBQshop

theBBQshop 51611010 Safety, Installation, Operation and Maintenance