Empire Comfort Systems Mantis User manual

Page 1

— Donotstoreorusegasolineorotherammable

vaporsandliquidsinthevicinityofthisoranyother

appliance.

— WHAT TO DO IF YOU SMELL GAS

 • Donottrytolightanyappliance.

 • Do not touch any electrical switch; do not

useanyphoneinyourbuilding.

 • Immediately call your gas supplier from a

neighbor’sphone.Followthegassupplier’s

instructions.

 • Ifyoucannotreachyourgassupplier,callthe

redepartment.

— Installationandservicemustbeperformedbya

qualiedinstaller,serviceagencyorthegassup-

plier.

™

EMPIRE

Comfort Systems

WARNING

HOT GLASS

DO NOT TOUCH

NEVER

WILL

CAUSE BURNS.

GLASS

UNTIL COOLED.

ALLOW CHILDREN

TO TOUCH GLASS.

OWNER’SMANUAL

POWER-VENT

HIGH-EFFICIENCY FIREPLACE

BAY WINDOW MANTIS MODELS

BF28(B,C,G)M(K)(N,P)-5

BP28(B,C,G)M(K)(N,P)-5

BI28(B,C,G)M(N,P)-5

FIREPLACE MANTIS MODELS

FF28BM(K)(N,P)-3

FW28BM(K)(N,P)-3

FI28BM(N,P)-3

Youngchildrenshouldbecarefullysupervisedwhen

theyareinthesameroomastheappliance.Toddlers,

young children and others may be susceptible to

accidental contact burns. A physical barrier is

recommendedifthereareatriskindividualsinthe

house. To restrict access to a replace or stove,

install an adjustable safety gate to keep toddlers,

young children and other at risk individuals out of

theroomandawayfromhotsurfaces.

This appliance may be installed in an aftermarket,

permanentlylocated,manufacturedhome(USAonly)

ormobilehome,wherenotprohibitedbystateorlocal

codes.

Thisapplianceisonlyforusewiththetypeofgas

indicated on the rating plate. This appliance is not

convertibleforusewithothergases,unlessacertied

kitisused.

WARNING:Ifnotinstalled,operatedandmaintained

inaccordancewiththemanufacturer’sinstructions,

thisproductcouldexposeyoutosubstancesinfuel

orfrom fuel combustionwhichcan cause deathor

serious illness.

Installer: Leavethismanualwiththeappliance.

Consumer: Retainthismanualforfuturereference.

WARNING:Iftheinformationintheseinstructions

arenotfollowedexactly,areorexplosionmayresult

causingpropertydamage,personalinjuryorloss

of life.

29007-0-0911Page 2

IMPORTANT SAFETY INFORMATION

THIS IS A HEATING APPLIANCE

Safetymarkingsarefrequentlyusedinthismanualtodesignateadegreeorlevelofserious-

nessandshouldnotbeignored.

WARNINGindicatesapotentiallyhazardoussituationthatifnotavoided,couldresultin

personal injury or death.

CAUTIONindicatesapotentiallyhazardoussituationthatifnotavoided,mayresultinmi-

norormoderateinjuryorpropertydamage.

WARNING

This appliance must be installed and repaired by

a qualied service person who is familiar with the

properinstallationandoperationoftheMantisPow-

er-VentHighEfciencyFireplace.Installerswhoare

not familiar with the installation of the Mantis and

havequestions,shouldcontactEmpireComfortSys-

tems,Inc.priortoinstallingtheappliancetoavoid

creating a hazardous operating condition.

• Duetohightemperaturestheapplianceshouldbe

locatedoutoftrafcandawayfromfurnitureand

draperies.

• Childrenandadultsshouldbealertedtothehaz-

ardsofhighsurfacetemperaturesandshouldstay

awaytoavoidburnsorclothingignition.

• Young children should be carefully supervised

whentheyareinthesameroomastheappliance.

Toddlers,youngchildrenandothersmaybesus-

ceptible to accidental contact burns. A physical

barrier is recommended if there are at risk indi-

vidualsinthehouse.Torestrictaccess toare-

placeorstove,installanadjustablesafetygateto

keepaway toddlers,youngchildren andotherat

riskindividualsoutoftheroomandawayfromhot

surfaces.

• Clothing or other ammable material should not

beplacedonorneartheappliance.

• Anysafetyscreenorguardremovedforservicingan

appliance,mustbereplacedpriortooperatingthe

appliance.

• Keepburnerandcontrolcompartmentclean.

• Formanufacturedhome(USAonly)ormobilehome

orresidentialinstallationconvertibleforusewith

natural gas and liqueed petroleum gases when

provisionismadeforthesimpleconversionfrom

one gas to the other.

WARNING

InstallationandrepairshouldbedonebyaQUALI-

FIED SERVICE PERSON. The appliance should

be inspected before use and at least annually by

a qualied service person. More frequent clean-

ing may be required due to excessive lint from

carpeting, bedding materials, etc.  It is impera-

tive that control compartments, burners and

circulatingairpassagewaysoftheappliancebekept

clean.

• DONOTput anythingaroundthe heaterthatwill

obstruct the ow of combustion and ventilation

air.

• DO keep the appliance area clear and free from

combustiblematerial,gasolineandotherammable

vapors and liquids.

• Do examine venting system periodically and re-

placedamagedparts.

• Domakeaperiodicvisualcheckofburner.Clean

andreplacedamagedparts.

• DONOTusethisheaterifanyparthasbeenunder

water.Immediatelycallaqualiedservicetechni-

cian to inspect the heater and to replace any part

ofthecontrolsystemandanygascontrolwhich

hasbeenunderwater.

• DONOToperatethisappliance without the front

panel installed.

29007-0-0911 Page 3

SAFETY INFORMATION FOR USERS OF LP-GAS

LP-Gas (Propane) is a ammable gas which can cause res

and explosions. In its natural state, propane is odorless and

colorless. You may not know all the following safety precautions

which can protect both you and your family from an accident.

Read them carefully now, then review them point by point with the

members of your household. Someday, there may not be a

minute to lose, everyone’s safety will depend on knowing ex-

actly what to do. If, after reading the following information, you

feel you still need more information, please contact your gas

supplier.

LP-GAS WARNING ODOR

Ifagasleakhappens,youshouldbeabletosmellthegasbecauseoftheodorantputintheLP-Gas.

That’syoursignaltogointoimmediateaction!

• Do not operate electric switches, light matches, use your

phone. Do not do anything that could ignite the gas.

• Get everyone out of the building, vehicle, trailer, or area.

Do that IMMEDIATELY.

• Close all gas tank or cylinder supply valves.

• LP-Gas is heavier than air and may settle in low areas

such as basements. When you have reason to suspect

a gas leak, keep out of basements and other low areas.

Stay out until reghters declare them to be safe.

• Use your neighbor’s phone and call a trained LP-Gas

service person and the re department. Even though

you may not continue to smell gas, do not turn on the

gas again. Do not re-enter the building, vehicle, trailer,

or area.

• Finally, let the service man and reghters check for es-

caped gas. Have them air out the area before you return.

Properly trained LP-Gas service people should repair the

leak, then check and relight the gas appliance for you.

NO ODOR DETECTED - ODOR FADE

Some people cannot smell well. Some people cannot smell

the odor of the chemical put into the gas. You must nd out if

you can smell the odorant in propane. Smoking can decrease

your ability to smell. Being around an odor for a time can affect

your sensitivity or ability to detect that odor. Sometimes other

odors in the area mask the gas odor. People may not smell

the gas odor or their minds are on something else. Thinking

about smelling a gas odor can make it easier to smell.

The odorant in LP-Gas is colorless, and it can fade under

some circumstances. For example, if there is an underground

leak, the movement of the gas through soil can lter the odor-

ant. Odorants in LP-Gas also are subject to oxidation. This

fading can occur if there is rust inside the storage tank or in

iron gas pipes.

The odorant in escaped gas can adsorb or absorb onto or

into walls, masonry and other materials and fabrics in a room.

That will take some of the odorant out of the gas, reducing its

odor intensity.

LP-Gas may stratify in a closed area, and the odor intensity

could vary at different levels. Since it is heavier than air, there

may be more odor at lower levels. Always be sensitive to the

slightest gas odor. If you detect any odor, treat it as a serious leak.

Immediately go into action as instructed earlier.

SOME POINTS TO REMEMBER

• Learn to recognize the odor of LP-Gas. Your local LP-Gas

Dealer can give you a “Scratch and Sniff” pamphlet. Use

it to nd out what the propane odor smells like. If you sus-

pect that your LP-Gas has a weak or abnormal odor, call

your LP-Gas Dealer.

• If you are not qualied, do not light pilot lights, perform

service, or make adjustments to appliances on the LP-

Gas system. If you are qualied, consciously think about

the odor of LP-Gas prior to and while lighting pilot lights

or performing service or making adjustments.

• Sometimes a basement or a closed-up house has a musty

smell that can cover up the LP-Gas odor. Do not try to

light pilot lights, perform service, or make adjustments in

an area where the conditions are such that you may not

detect the odor if there has been a leak of LP-Gas.

• Odor fade, due to oxidation by rust or adsorption on walls

of new cylinders and tanks, is possible. Therefore, people

should be particularly alert and careful when new tanks or

cylinders are placed in service. Odor fade can occur in new

tanks, or reinstalled old tanks, if they are lled and allowed

to set too long before relling. Cylinders and tanks which

have been out of service for a time may develop internal

rust which will cause odor fade. If such conditions are

suspected to exist, a periodic sniff test of the gas is

advisable. If you have any question about the gas odor,

call your LP-Gas dealer. A periodic sniff test of the LP-

Gas is a good safety measure under any condition.

• If, at any time, you do not smell the LP-Gas odorant and

you think you should, assume you have a leak. Then take

the same immediate action recommended above for the

occasion when you do detect the odorized LP-Gas.

• If you experience a complete “gas out,” (the container

is under no vapor pressure), turn the tank valve off

immediately. If the container valve is left on, the container

may draw in some air through openings such as pilot light

orices. If this occurs, some new internal rusting could

occur. If the valve is left open, then treat the container as

a new tank. Always be sure your container is under vapor

pressure by turning it off at the container before it goes

completely empty or having it relled before it is

completely empty.

29007-0-0911Page 4

Operating the Heater

Before you start

1. Verifythereiselectricalpowertotheunit.

If electrical power is present, the Power light on the front

control panel will be illuminated. If the Power light is not

illuminated, verify the heater is plugged in and the breaker

and the main power switch are on.

2. Verifythemaingassupplytotheunitison.

The shutoff valve should be in the “OPEN” position.

CLOSED

OPEN

How to Start the Heater – Both Burners

Operating

1. Turn both Front and Rear burner switches to the “ON”

position and adjust the remote thermostat to the de-

sired temperature or press “ON” on the remote. Both

the Front and Rear lights should be illuminated, and the

rear burner light will ash.

2. The light for the Exhaust Fan will illuminate as the heat-

er prepares to ignite.

3. In 15 to 20 seconds, the rear igniter will glow red, and

the burner will light.

4. After the rear burner is lit, the front light will ash and

the igniter will start to glow red and the front burner will

light.

5. The Blower light will illuminate after 3 to 5 minutes. The

blower will automatically advance to a higher speed if

it is needed. The blower speed will be indicated on the

front control panel.

29007-0-0911 Page 5

HowtoStarttheHeater–OneBurnerOnly

1. Turn either the Rear or Front burner switch to the “ON” posi-

tion. If the Rear burner is powered, the Rear display light

will be illuminated. If the Front burner is powered, the Front

display light will be illuminated.

Rearburneronly

Frontburneronly

2. The light for the Exhaust Fan will illuminate as the heater pre-

pares to ignite.

3. In 15 to 20 seconds, the appropriate igniter will glow red, and

the burner will light.

4. The Blower light will become illuminated after 3 to 5 minutes.

The blower will automatically advance to a higher speed if it is

needed. The blower speed will be indicated on front control

panel.

HowtoChangeBurners–SwitchingBurners

If the heater is being operated on one burner, and it is desired to

change and operate the other burner, rst turn the other burner

“ON” before turning the original burner “OFF”.

The table below outlines the input rate of both front and rear burn-

ers.

Model Front Burner

Input(BTUH)

Rear Burner

Input(BTUH)

Bay Window Mantis 9,000 19,000

Fireplace Mantis 13,000 15,000

Example: If the front burner is operating and then you would like

more heat in the room and would like to change to the rear burner,

rst turn the rear burner switch “ON”, wait a second, then turn the

front burner switch “OFF”. If this sequence is not followed, the

control in the heater will lock up, and will need to be reset.

HowtoResettheHeater

If for any reason the heater needs to be reset, remove the front

louvered cover from the heater, then turn the Main Power Switch

to the “OFF” position. The heater must remain off for 5 minutes.

Note: If the blower is running, allow it to complete its cycle and

shut down automatically before turning the main power switch to

the “OFF” position. This will ensure that the heater has been prop-

erly cooled down.

After waiting 5 minutes, the Main Power Switch can be moved to

the “ON” position. Burner operation will resume.

HumidierOperation

The Mantis Power-Vent High-Efciency Fireplace has an auto-

matic humidier designed into the heater. As the heater operates,

condensate is created and collected inside the heater. The con-

densate is then transferred to a pan where it evaporates into the

air stream. The humidier does not operate with every cycle.

While the condensate is being transferred to the pan, it is normal

to hear a slight hissing sound. The Humidier light will be illumi-

nated while the condensate is being transferred.

29007-0-0911Page 6

HowtoTurntheHeaterOff

To turn the heater off, simply switch the burner switch or

switches to the “OFF” position, turn the remote off, or adjust

the temperature down. The burners will instantly go off, but

the circulating blower will still operate until the heater cools

off. It is normal for the blower to turn on and off while it is

cooling down.

HowtoOperateEconomyMode

Verify the burner switches are in the “OFF” position, and

have been for at least 5 minutes. Press and release the red

button that is located next to the burner switches. The but-

ton will illuminate.

Next, turn both burner switches to the “ON” position.

The front burner will operate and will remain on. The rear

burner will cycle with the thermostat.

HowtoDeactivateEconomyMode

To deactivate the Economy Mode, press and release the

red button. If desirable, the burner switches can be turned

“OFF” or the thermostat will control the heat.

HowtoCleantheGlassDoor

WARNING

Donotoperatedthisappliancewithouttheglassdoor

inplace.Donotoperateiftheglassfrontisbrokenor

damaged.Donotusetheglassdoorifthegasketis

missingordamaged.

Over time, the glass door will need to be cleaned. For best

results, it is recommended to clean the glass with replace

glass cleaner.

If the glass needs to be replaced, contact a qualied service

person. Only glass approved by Empire Comfort Systems

Inc. can be used, any other product will void the warranty.

To clean inside the glass door, the door will need to be re-

moved.

CAUTION

Donotattempttocleantheglasswhenitishot.Do

notstrikeorhittheglass.

CAUTION

Becertaintheglassiscoolbeforehandling.

How to Clean the Glass Door - Bay Window

Mantis Models

First, remove the top of the cabinet by holding it on the sides

and lifting off.

29007-0-0911 Page 7

BayWindowMantisModels-Continued

Second, open the panels on the right and left sides.

Next, release the two door latches on the left and the two

door latches on the right side of the rebox.

Carefully hold the glass frame and pull the glass door to-

wards you. DO NOT damage or remove the gasket from

the door.

How to Clean the Glass Door - Fireplace

Mantis Models

First, remove the lower louvered panel by lifting up, then

pulling out.

Second, release the two door latches on the underside of

the rebox.

29007-0-0911Page 8

Fireplace Mantis Models Continued

Next, hold the bottom of the glass door and lift, keeping a

rm grip on the door.

Keep the glass angled to the rebox, then gently pull the

glass door away from the heater. DO NOT damage or re-

move the gasket from the door.

How to Replace the Remote Control System

Batteries

Both the handheld remote control and the remote receiver

(located inside of the heater) are battery operated. These

batteries will need to be replaced periodically as part of the

normal maintenance of the heater.

HowtoReplacetheRemoteControlBatteries

Slide open the battery compartment panel located on the

back of the remote control.

BATTERY COMPARTMENT

HowtoReplacetheRemoteReceiverBatter-

ies

1. Remove the lower louvered panel of the heater.

2. Turn the Main power switch to the “OFF” position.

3. Lift the remote receiver from its location on top of the

blower housing. The remote receiver is held onto the

blower housing with hook and loop tape. Do not discon-

nect the wires.

RECEIVER LOCATION

ADJ. LEARN

REMOTE ONOFF

4. Slide open the battery compartment panel located on

the bottom of the remote receiver.

OFF REMOTE ON

BATTERY COMPARTMENT

29007-0-0911 Page 9

Service and Maintenance

Although most service should be conducted by a qualied

service person, there are several things that can be checked

to ensure safe and comfortable operation.

The area surrounding the heater should be free from any

types of combustible materials, and the lter should be

checked and cleaned on a monthly basis. All other mainte-

nance should be conducted by a qualied service person.

RECOMMENDED MAINTENANCE

MAINTENANCE ITEM

FREQUENCYOFMAINTENANCE

MONTHLY

CHECKBY

HOMEOWNER

ANNUALLY

CHECKBYA

SERVICE PERSON

Verify the area is free from combustible materials. X X

Verify the combustion and ventilation air is not restricted. X

Verify the ue and inlet pipes do not have any cracks or

holes. X

Verify burner ame. X

Clean the blower compartment X

Clean the burners. X

Verify the condensate system is clean and leak free. X

29007-0-0911Page 10

APPLIANCE SERVICE HISTORY

Date DealerName ServiceTechnicianName ServicePerformed/Notes

This manual suits for next models

Table of contents

Languages:

Other Empire Comfort Systems Indoor Fireplace manuals

Empire Comfort Systems

Empire Comfort Systems White Mountain Hearth DVTL27FP90N-1 Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVCD32FP30N-1 User manual

Empire Comfort Systems

Empire Comfort Systems MANTIS BF28(B User manual

Empire Comfort Systems

Empire Comfort Systems MILLIVOLT 3 Series Quick start guide

Empire Comfort Systems

Empire Comfort Systems White Mountain Hearth VFP24FP20LN-1 Quick start guide

Empire Comfort Systems

Empire Comfort Systems VFP36PP32EP-2 Quick start guide

Empire Comfort Systems

Empire Comfort Systems VFP32FB0F-5 Quick start guide

Empire Comfort Systems

Empire Comfort Systems American Hearth DVCT 36 Series User manual

Empire Comfort Systems

Empire Comfort Systems Mantis Series User manual

Empire Comfort Systems

Empire Comfort Systems VFD26FM series User manual

Empire Comfort Systems

Empire Comfort Systems VFPC20in33N-1 Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVCT35CBN95N User manual

Empire Comfort Systems

Empire Comfort Systems DVD32FP3(0 Quick start guide

Empire Comfort Systems

Empire Comfort Systems White Mountain Hearth DVCX36FP91N-1 Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVLT42FP92N-2 Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVCP36PP30 Series Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVP42FP30N-4 Quick start guide

Empire Comfort Systems

Empire Comfort Systems VFP32FB2DL-4 Quick start guide

Empire Comfort Systems

Empire Comfort Systems EBL74 User manual

Empire Comfort Systems

Empire Comfort Systems VFP20IN3 series User manual

Empire Comfort Systems

Empire Comfort Systems DVC28IN71 Quick start guide

Empire Comfort Systems

Empire Comfort Systems OLP36FP72SN-2 User manual

Empire Comfort Systems

Empire Comfort Systems VFP36SP32E Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVL25IN73N-1 User manual

Popular Indoor Fireplace manuals by other brands

Brigantia

Brigantia 35-DVRS31N-2 User's installation, operation and maintenance manual

Nordpeis

Nordpeis Bergen Installation and user manual

Superior

Superior BCT2536TMN Installation and operation instructions

Quadra-Fire

Quadra-Fire 5100I-GD-B owner's manual

Renaissance

Renaissance RUMFORD 1000 user manual

Lacunza

Lacunza IV-800 Instruction book

Baxi

Baxi 940 Installer and owner guide

Dru

Dru Maestro 60/2 Tall RCH installation manual

Diamond Fireglass

Diamond Fireglass SS-O22 General assembly, installation, and operation instructions

HearthStone

HearthStone Windsor Bay 8830 Owner's manual and installation guide

Napoleon

Napoleon ASCENT B42 quick start guide

Enviro

Enviro E33GI owner's manual

Smeg

Smeg L30 FABE Installation & user's instructions

KEDDY

KEDDY K700 Installation instructions care and firing instructions

Godin

Godin 3451 manual

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Installation and operation instructions

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 operating manual

Desa

Desa CCFPDFT Owner's operating & installation manual