Empire Comfort Systems BVD34FP30(F Quick start guide

Page 1

INSTALLATION INSTRUCTIONS

AND

OWNER’S MANUAL

WARNING: If not installed, operated and maintained

in accordance with the manufacturer’s instructions,

this product could expose you to substances in fuel or

from fuel combustion which can cause death or seri-

ous illness.

NOT INTENDED FOR USE AS A PRIMARY HEAT

SOURCE. This appliance is tested and approved as

either supplemental room heat or as a decorative

appliance. It should not be factored as primary heat

in residential heating calculations.

This appliance is only for use with the type of gas

indicated on the rating plate. This appliance is not

FRQYHUWLEOHIRUXVHZLWKRWKHUJDVHVXQOHVVDFHUWL¿HG

kit is used.

"B" Vent Zero Clearance Gas Fireplace

WARNING: If the information in this manual is not

IROORZHGH[DFWO\D¿UHRUH[SORVLRQPD\UHVXOWFDXVLQJ

property damage, personal injury or loss of life.

-'R QRW VWRUH RU XVH JDVROLQH RU RWKHU ÀDPPDEOH

vapors and liquids in the vicinity of this or any

other appliance.

-WHAT TO DO IF YOU SMELL GAS

Ɣ Do not try to light any appliance.

Ɣ Do not touch any electrical switch; do not use any

phone in your building.

Ɣ ,PPHGLDWHO\FDOO\RXUJDVVXSSOLHUIURPDQHLJKERUV

phone. Follow the gas supplier's instructions.

Ɣ ,I\RXFDQQRWUHDFK\RXUJDVVXSSOLHUFDOOWKH¿UH

department.

-Installation and service must be performed by

D TXDOL¿HG LQVWDOOHU VHUYLFH DJHQF\ RU WKH JDV

supplier.

GAS-FIRED

Installer: Leave these instructions with the consumer.

Consumer: Retain these instructions for future use.

B-VENT

GAS FIREPLACE

MODEL SERIES

MILLIVOLT

BVD34FP30(F,L)N-2

BVD36FP3(0,2)(F,L)N-1

BVP42FP30(F,L)N-1

BVP42FP32(F,L)N-3

DIRECT IGNITION

BVD34FP50(F,L)N-2

BVD36FP5(0,2)(F,L)N-1

BVP42FP50(F,L)N-1

BVP42FP52(F,L)N-3

UL FILE NO. MH45034

EMPIRE

Comfort Systems

26534-1-0610Page 2

Important Safety Information....................................................................................................3

Safety Information for Users of LP Gas....................................................................................4

Introduction ..............................................................................................................................5

6SHFL¿FDWLRQV.............................................................................................................................6

Fireplace Dimensions................................................................................................................6

Clearances .................................................................................................................................7

Locating Fireplace.....................................................................................................................7

Gas Supply .............................................................................................................................8-9

Installation .........................................................................................................................10-11

Venting................................................................................................................................12-13

Log Placement (BVD34 and BVD36) (5 Log Set) .................................................................14

Log Placement (BVP42) (4 Log Set)......................................................................................15

Operating Instructions........................................................................................................16-17

Standing Pilot Wiring Diagram...............................................................................................18

Standing Pilot Lighting Instructions........................................................................................19

Standing Pilot Troubleshooting...............................................................................................20

Standing Pilot Propane/LP Gas Conversion.......................................................................21-22

Direct Ignition Wiring Diagram..............................................................................................23

Optional Remote Control (120V Direct Ignition)...................................................................23

Direct Ignition Lighting Instructions.......................................................................................24

Direct Ignition Troubleshooting..............................................................................................25

Direct Ignition Propane/LP Gas Conversion......................................................................25-26

Maintenance and Service.........................................................................................................27

BVD34 and BVD36 Parts List................................................................................................28

BVD34 and BVD36 Parts View..............................................................................................29

BVP42 Parts List.....................................................................................................................30

BVP42 Parts View...................................................................................................................31

FBB4 Optional Variable Speed Blower Installation Instructions.......................................32-33

Junction Box Wiring Installation Instructions.........................................................................34

Optional Accessories...............................................................................................................35

Decorative Accessories............................................................................................................36

Master Parts Distributor List...................................................................................................37

How To Order Repair Parts.....................................................................................................37

Quick Reference Guide......................................................................................................38-39

Section Page

TABLE OF CONTENTS

26534-1-0610 Page 3

Before enclosing the vent pipe assembly, operate the appliance to ensure it is venting properly.

 ,I WKLV DSSOLDQFH LV LQVWDOOHG GLUHFWO\ RQ FDUSHWLQJ

tile or other combustible material other than wood

ÀRRULQJWKHDSSOLDQFHVKDOOEHLQVWDOOHGRQDPHWDO

or wood panel extending the full width and depth of

the appliance.

 7KHEDVHUHIHUUHGWRDERYHGRHVQRWPHDQWKH¿UHSURRI

base as used on wood stoves. The protection is for

rugs that are extremely thick and light colored tile.

 &KLOGUHQDQGDGXOWVVKRXOGEHDOHUWHGWRWKHKD]DUGV

of high surface temperatures and should stay away

to avoid burns or clothing ignition.

 <RXQJFKLOGUHQVKRXOGEHFDUHIXOO\VXSHUYLVHGZKHQ

they are in the same room as the appliance.

 &ORWKLQJRURWKHUÀDPPDEOHPDWHULDOVKRXOGQRWEH

placed on or near the appliance.

 $GHTXDWHDFFHVVLELOLW\FOHDUDQFHVIRUVHUYLFLQJDQG

proper operation.

 7KLVDSSOLDQFHPXVWQRWVKDUHRUEHFRQQHFWHGWRDÀXH

serving a separate solid-fuel burning appliance.

 .HHS WKH DUHD DURXQG \RXU DSSOLDQFH FOHDU RI

FRPEXVWLEOHPDWHULDOVJDVROLQHDQGRWKHUÀDPPDEOH

vapor and liquids.

 8QGHU QR FLUFXPVWDQFHV VKRXOG DQ\ VROLG IXHOV

(wood, coal, paper or cardboard etc.) be used in this

appliance.

 7KHÀRZRIFRPEXVWLRQDQGYHQWLODWLRQDLUPXVWQRW

be obstructed in any way.

 'XHWRKLJKWHPSHUDWXUHVWKHDSSOLDQFHVKRXOGEH

ORFDWHGRXWRIWUDI¿FDQGDZD\IURPIXUQLWXUHDQG

draperies.

 $Q\SDUWUHPRYHGIRUVHUYLFLQJWKHDSSOLDQFHPXVW

be replaced priorto operating the appliance. Work

VKRXOGEHGRQHE\DTXDOL¿HGVHUYLFHSHUVRQ

 .HHSEXUQHUDQGFRQWUROFRPSDUWPHQWFOHDQ

 9HQWFDSLVKRWZKLOH¿UHSODFHLVLQRSHUDWLRQ

 Installation and repair should be done by a

48$/,),('6(59,&(3(5621The appliance

shouldbeinspectedbeforeuseandatleastannually

by a qualified service person. More frequent

cleaningmay be required dueto excessive lint from

carpeting, bedding materials, etc. It is imperative

thatcontrolcompartments,burnersandcirculating

air passageways of the appliance be kept clean.

 '2127SXWDQ\WKLQJDURXQGWKH¿UHSODFHWKDWZLOO

REVWUXFWWKHÀRZRIYHQWLODWLRQDLU

 &OHDUDQFHLQDFFRUGDQFHZLWKORFDOLQVWDOODWLRQFRGHV

and the requirements of the gas supplier.

 '2 keep the appliance area clear and free from

FRPEXVWLEOHPDWHULDOJDVROLQHDQGRWKHUÀDPPDEOH

vapors and liquids.

 '2 examineventingsystemperiodicallyandreplace

damaged parts.

 '2makeaperiodicvisualcheckofpilotandburners.

Clean and replace damaged parts.

 '2127XVHWKLV¿UHSODFHLIDQ\SDUWKDVEHHQXQGHU

ZDWHU,PPHGLDWHO\FDOODTXDOL¿HGVHUYLFHWHFKQLFLDQ

to inspect the heater and to replace any part of the

control system and any gas control which has been

under water.

 $Q\VDIHW\VFUHHQRUJXDUGUHPRYHGIRUVHUYLFLQJ

an appliance must be replaced prior to operating

the appliance.

IMPORTANT SAFETY INFORMATION

26534-1-0610Page 4

Some people cannot smell well. Some people cannot smell the

RGRURIWKHFKHPLFDOSXWLQWRWKHJDV<RXPXVW¿QGRXWLI\RX

can smell the odorant in propane. Smoking can decrease your

ability to smell. Being around an odor for a time can affect your

sensitivity or ability to detect that odor. Sometimes other odors

in the area mask the gas odor. People may not smell the gas odor

or their minds are on something else. Thinking about smelling a

gas odor can make it easier to smell.

TheodorantinLP-Gasiscolorless,anditcanfadeundersome

circumstances. For example, if there is an underground leak, the

PRYHPHQWRIWKHJDVWKURXJKVRLOFDQ¿OWHUWKHRGRUDQW2GRUDQWV

in LP-Gas also are subject to oxidation. This fading can occur if

there is rust inside the storage tank or in iron gas pipes.

Theodorantinescapedgascanadsorborabsorbontoorintowalls,

masonry and other materials and fabrics in a room. That will take

some of the odorant out of the gas, reducing its odor intensity.

LP-Gas may stratify in a closed area, and the odor intensity could

vary at different levels. Since it is heavier than air, there may be

more odor at lower levels.Always be sensitive to the slightest gas

odor. If you detectanyodor,treat itasa serious leak. Immediately

go into action as instructed earlier.

3URSDQH/3*DVLVDÀDPPDEOHJDVZKLFKFDQFDXVH¿UHV

and explosions. In its natural state, propane is odorless and

colorless. You may not know all the following safety precau-

tions which can protect both you and your family from an

accident. Read them carefully now, then review them point

bypointwith the members ofyourhousehold.Somedaywhen

theremaynotbeaminutetolose,everyone’ssafetywilldepend

on knowing exactly what to do. If, after reading the following

information, you feel you still need more information, please

contact your gas supplier.

 /HDUQWRUHFRJQL]HWKHRGRURI/3*DV Your localLP-Gas

'HDOHUFDQJLYH\RXD³6FUDWFKDQG6QLII´SDPSKOHW8VHLWWR¿QG

out what the propane odor smells like. If you suspect that your

LP-Gas has a weak or abnormal odor, call your LP-Gas Dealer.

 ,I\RX DUH QRW TXDOL¿HG GRQRW OLJKW SLORWOLJKWV SHUIRUP

service,ormakeadjustmentstoappliancesontheLP-Gassystem.

,I\RXDUHTXDOL¿HGFRQVFLRXVO\WKLQNDERXWWKHRGRURI/3*DV

prior to and while lighting pilot lights or performing service or

making adjustments.

 6RPHWLPHVD EDVHPHQW RU DFORVHGXS KRXVH KDV DPXVW\

smell that can cover up the LP-Gas odor. Do not try to light pilot

lights, perform service, or make adjustments in an area where the

conditions are such that you may not detect the odor if there has

been a leak of LP-Gas.

 2GRUIDGHGXHWRR[LGDWLRQE\UXVWRUDGVRUSWLRQRQZDOOV

of new cylinders and tanks, is possible. Therefore, people should

be particularly alert and careful when new tanks or cylinders are

placedinservice. Odor fade canoccurin new tanks, orreinstalled

ROGWDQNV LI WKH\DUH ¿OOHG DQGDOORZHG Wo set too long before

UH¿OOLQJ&\OLQGHUVDQGWDQNVZKLFKKDYHEHHQRXWRIVHUYLFHIRU

a time may develop internal rust which will cause odor fade. If

such conditions are suspected to exist, a periodic sniff test of the

gas is advisable. If you have any question about the gas odor,

call your LP-Gas dealer.Aperiodic sniff test of the LP-Gas is

a good safety measure under any condition.

 ,IDWDQ\WLPH\RXGRQRWVPHOOWKH/3*DVRGRUDQWDQG\RX

think you should, assume you have a leak. Then take the same

immediateaction recommendedabove fortheoccasion whenyou

do detect the odorized LP-Gas.

 ,I \RX H[SHULHQFH D FRPSOHWH ³JDV RXW´ WKH FRQWDLQHU LV

under no vapor pressure), turn the tank valve off immediately. If

the container valve is left on, the container may draw in some air

WKURXJKRSHQLQJVVXFKDVSLORWOLJKWRUL¿FHV,IWKLVRFFXUVVRPH

new internal rusting could occur. If the valve is left open, then

treat the container as a new tank. Always be sure your container

is under vapor pressure by turning it off at the container before it

JRHVFRPSOHWHO\HPSW\RUKDYLQJLWUH¿OOHGEHIRUHLWLVFRPSOHWHO\

empty.

 'R QRW RSHUDWH HOHFWULF VZLWFKHV OLJKW PDWFKHV XVH \RXU

phone. Do not do anything that could ignite the gas.

 *HWHYHU\RQHRXWRIWKHEXLOGLQJYHKLFOHWUDLOHURUDUHD'R

that IMMEDIATELY.

 &ORVHDOOJDVWDQNRUF\OLQGHUVXSSO\YDOYHV

 /3*DVLVKHDYLHUWKDQDLUDQGPD\VHWWOHLQORZDUHDVVXFK

as basements. When you have reason to suspect a gas leak,

keep out of basements and other low areas. Stay out until

¿UH¿JKWHUVGHFODUHWKHPWREHVDIH

 8VH\RXUQHLJKERU¶VSKRQHDQGFDOODWUDLQHG/3*DVVHUYLFH

SHUVRQDQGWKH¿UHGHSDUWPHQW(YHQ WKRXJK\RXPD\QRW

continue to smell gas, do not turn on the gas again. Do not

re-enter the building, vehicle, trailer, or area.

 Finally,OHWWKHVHUYLFHPDQDQG¿UH¿JKWHUVFKHFNIRUHVFDSHG

gas. Have them air out the area before you return. Properly

trained LP-Gas service people should repair the leak, then

check and relight the gas appliance for you.

SOME POINTS TO REMEMBER

NO ODOR DETECTED - ODOR FADE

LP-GAS WARNING ODOR

If a gas leak happens, you should be able to smell the gas because of the odorant put in the LP-Gas.

That’s your signal to go into immediate action!

SAFETY INFORMATION FOR USERS OF LP GAS

26534-1-0610 Page 5

Instructions to Installer

1. Installer must leave instruction manual with owner after

installation.

 ,QVWDOOHUPXVWKDYHRZQHU¿OORXWDQGPDLOZDUUDQW\FDUGVXSSOLHG

ZLWKWKH¿UHSODFH

3. Installer should show owner how to start and operate the

¿UHSODFH

ThisisaB-Ventgasappliance andmustbeinstalled withalistedB-

Ventventsystem.Theinformationcontainedinthismanualpertains

to all models and gas control systems unless otherwise noted.

Warning: This unit is not for use with solid fuels.

$SSOLDQFH&HUWL¿FDWLRQ

7KLV ¿UHSODFH LV GHVLJQ FHUWL¿HG LQ DFFRUGDQFH ZLWK $PHULFDQ

National Standard/CSAStandardANSI Z.21-50/CSA2.22 and by

Underwriters Laboratories as a Vented GasAppliance and shall be

installed according to these instructions.

Consult your local building code agency, prior to installation,

to ensure compliance with local codes-including permits and

inspections.

7KH ¿UHSODFH ZKHQ LQVWDOOHG PXVW EH HOHFWULFDOO\ JURXQGHG LQ

accordance with local codes or, in absence of local codes, with

the National Electric Code ANSI/NFPA 70 if an external electrical

source is utilized.

These models may be installed in a bedroom or bed-sitting room

in the U.S.A.

4XDOL¿HG,QVWDOOLQJ$JHQF\

,QVWDOODWLRQDQGUHSODFHPHQWRIJDVSLSLQJJDVXWLOL]DWLRQHTXLSPHQW

RU DFFHVVRULHV DQG UHSDLU DQG VHUYLFLQJ RI HTXLSPHQW VKDOO EH

SHUIRUPHGRQO\E\DTXDOL¿HGDJHQF\7KHWHUP³TXDOL¿HGDJHQF\´

PHDQVDQ\LQGLYLGXDO¿UPFRUSRUDWLRQRUFRPSDQ\ZKLFKHLWKHULQ

person or through a representative is engaged in and is responsible

for (a) the installation or replacement of gas piping or (b) the

FRQQHFWLRQLQVWDOODWLRQUHSDLURUVHUYLFLQJRIHTXLSPHQWZKRLV

H[SHULHQFHGLQVXFKZRUNIDPLOLDUZLWKDOOSUHFDXWLRQVUHTXLUHG

DQGKDVFRPSOLHGZLWKDOOWKHUHTXLUHPHQWVRIWKHDXWKRULW\KDYLQJ

jurisdiction.

Theinstallationmustconformwithlocalcodesor,intheabsenceof

local codes, with the National Fuel Gas Code ANSI Z223.1/NFPA

54* Natural Gas and Propane Installation Code, or CSA B149.1

in Canada. *Available from the American National Standards Institute, Inc. 11

West 42nd St., New York, N.Y. 10036.

Any alteration of the original design, installed other than as

shownintheseinstructionsorusewithatypeofgasnotshownon

therating plateistheresponsibilityofthepersonand company

making the change.

Important

AllcorrespondenceshouldrefertocompleteModelNumber,Serial

Number and type of gas.

High Altitude

When installing this unit at an elevation above 2000 feet (in the

United States) it may be necessary to decrease the input rating by

FKDQJLQJWKHH[LVWLQJEXUQHURUL¿FHWRDVPDOOHUVL]H*HQHUDOO\

input should be reduced 4 percent for each 1000 feet above sea

level. However, if the heating value of the gas has been reduced,

this general rule may not apply. Check with local gas utility for

SURSHURUL¿FHVL]HLGHQWL¿FDWLRQ

Canadian High Altitude

Altitude: 0-4500 feet (0-1370 m)

Wheninstallingthisunitatanelevationabove4500feet(inCanada),

check with local authorities.

Consult your local gas utility for assistance in determining the

SURSHURUL¿FHIRUORFDWLRQ

Preparation

7KLVJDV ¿UHSODFHDQG LWVFRPSRQHQWV DUH WHVWHG DQG VDIHZKHQ

installed in accordance with this Installation Manual. Report to

\RXU GHDOHU DQ\ SDUWV GDPDJHG LQ VKLSPHQW VSHFL¿FDOO\ FKHFN

glass condition. Do not install unit with damaged, incomplete, or

substitute parts. Read all instructions before starting installation

and follow these instructions carefully during installation to insure

PD[LPXPEHQH¿WDQGVDIHW\)DLOXUHWRIROORZWKHPZLOOYRLG\RXU

ZDUUDQW\DQGPD\SUHVHQWD¿UHKD]DUG

The warranty will be voided by, and the warrantor disclaims any

responsibility for the following actions:

 ,QVWDOODWLRQ RI DQ\ GDPDJHG ILUHSODFH RU YHQW V\VWHP

component.

 0RGL¿FDWLRQRIWKH¿UHSODFHRUYHQWV\VWHP

 ,QVWDOODWLRQRWKHUWKDQDVLQVWUXFWHGE\(PSLUH&RPIRUW6\VWHPV

Inc.

 ,PSURSHUSRVLWLRQLQJRIWKHORJVJODVVGRRURSWLRQDODFFHVVRULHV

or decorative rock.

 ,QVWDOODWLRQDQGRUXVHRIDQ\FRPSRQHQWSDUWQRWPDQXIDFWXUHG

or approved by manufacturer.

*ODVV6SHFL¿FDWLRQV

Optional glass door kits manufactured with tempered glass

may be installed in hazardous locations such as bathtub

HQFORVXUHVDVGH¿QHGE\WKH&RQVXPHU3URGXFW6DIHW\&RPPLVVLRQ

&36&7KHWHPSHUHGJODVVKDVEHHQWHVWHGDQGFHUWL¿HGWRWKH

UHTXLUHPHQWV RI ANSI Z97.1 and CPSC 16 CFR 1202

6DIHW\ *OD]LQJ &HUWL¿FDWLRQ &RXQFLO SGCC# 1595 and 1597.

Architectural Testing, Inc. Reports 02-31919.01 and

02-31917.01).

This statement is in compliance with CPSC 16 CFR Section

1201.5 &HUWL¿FDWLRQ DQG ODEHOLQJ UHTXLUHPHQWV ZKLFK UHIHUV

to 15 U.S. Code (USC) 2063 VWDWLQJ 6XFK FHUWL¿FDWH VKDOO

accompany the product or shall otherwise be furnished to any dis-

tributor or retailer to whom the product is delivered."

INTRODUCTION

State of Massachusetts: The installation must be made

E\ D OLFHQVHG SOXPEHU RU JDV ¿WWHU LQ WKH &RPPRQZHDOWK RI

0DVVDFKXVHWWV 7KH VWDWH RI 0DVVDFKXVHWWV UHTXLUHV WKDW D

ÀH[LEOHDSSOLDQFHFRQQHFWRUFDQQRWH[FHHGWKUHHIHHWLQOHQJWK

Warning: ANY CHANGE TO THIS FIREPLACE OR ITS

CONTROLS CAN BE DANGEROUS.

,PSURSHULQVWDOODWLRQRUXVHRIWKH¿UHSODFHFDQFDXVHVHULRXV

LQMXU\RUGHDWKIURP¿UHEXUQVH[SORVLRQVRUFDUERQPRQR[LGH

poisoning.

26534-1-0610Page 6

Figure 1

Dim %9' %9' %93

A37"

940mm 39"

990mm 43"

1092mm

B34"

864 mm 36"

914mm 40"

1,016mm

C22 7/8"

581mm 24 7/8"

632mm 24 7/8"

632mm

D35 5/8"

905 mm 37 5/8"

956 mm 37 5/8"

956 mm

E32 3/4"

832mm 34 3/4"

883 mm 34 3/4"

883 mm

F14 7/8"

378mm 18 3/8

467mm 18 3/8"

467mm

G6 3/8"

162mm 6 3/8"

162mm

H5 7/8"

149mm 8 3/8"

213mm 6 3/8"

162mm

I24 1/2"

622mm 22 1/2"

572mm 26 1/2"

673mm

J12 1/4"

311mm 11 1/4"

286mm 13 1/4"

337mm

K1 1/4"

32mm 1 1/4"

32mm

L31 3/4"

807mm 33 3/4"

857mm 33 3/4"

857mm

M32 11/16"

830mm 34 11/16"

881mm 34 11/16"

881mm

N2 1/16"

53mm 2 1/16"

53mm

O5 5/8"

143mm 5 5/8"

143mm

P4 7/8"

124mm 4 7/8"

124mm

Remote Control Options &

Accessories Description

FRBC MILLIVOLT BATTERY REMOTE ON/OFF

FREC DIRECT IGNITION/MILLIVOLT 120V ON/OFF REMOTE

FWS-1 DIRECT IGNITION/MILLIVOLT WALL SWITCH

BVD34FP BVD36FP BVP42FP

Input Btu/hr Maximum 21,000 25,000 30,000

KWH (Maximum) 6.2 7.3 8.8

B-Vent Size 4" Diameter 6" Diameter 6" Diameter

NAT. (Standard)

2UL¿FH #44 (.086)

P-252 #42 (.0935)

P-286 #37 (.104)

P-213

Air Shutter Opening 1/8" (3.2mm) 1/8"(3.2mm) 1/8" (3.2mm)

/3&RQYHUVLRQ.LW5HTXLUHG

2UL¿FH 1.35mm

P-289 1.45 mm

P-208 1.65mm

P-250

Air Shutter Opening 5/16" (7.9mm) 5/16" (7.9mm) Full Open

Height without standoff 32 3/4"(832mm) 34 3/4"(883mm) 34 3/4"(883mm)

Width 37" (940mm) 39" (990mm) 43" (1,092mm)

Depth 14 7/8" (378mm) 18 3/8" (467mm) 18 3/8" (467mm)

Gas Inlet Shutoff Valve (Pipe) 1/2 NPT 1/2 NPT 1/2NPT

NOTE: Air shutter

settings are factory

minimumsettings.Some

venting configurations

PD\ UHTXLUH PLQRU DLU

shutter adjustments for

optimum performance.

*NOTE:/3&RQYHUVLRQNLWVDUHLQFOXGHGRQWKHYGLUHFWLJQLWLRQPRGHO¿UHSODFHV)RUPLOOLYROWPRGHOVXVHNLW

#19160 for BVD34FP Series, kit #19161 for BVD36FP Series, and kit #19162 for BVP42FP Series.

SPECIFICATIONS

FIREPLACE DIMENSIONS

26534-1-0610 Page 7

Mantel Chart (Figure 3)

Figure 3

&OHDUDQFHV)LJXUH

&OHDUDQFHIURPWRSIURQWHGJHRI¿UHSODFHWRFHLOLQJLV

&OHDUDQFHIURPVLGHRI¿UHSODFHWRDGMDFHQWVLGHZDOOLV

)LJXUH

Figure 5

Note: When you install your

Fireplace on wall corner

positions,aminimumof6inches

clearance must be maintained

fromtheperpendicularsidewall

and the screened opening of the

appliance.

Figure 2

Combustible Material

No greeting cards, stockings or ornamentation of any type should

EH SODFHG RQ RU DWWDFKHG WR WKH ¿UHSODFH 7KH ÀRZ RI KHDW FDQ

ignite combustibles.

Clearance to Combustibles

Back 0" (0 mm)

Side 0" (0 mm)

Floor 0" (0 mm)

Top Stand-off 0" (0 mm)

Top Framing Edge 1" (25mm)

CLEARANCES

LOCATING FIREPLACE

26534-1-0610Page 8

Figure 6

The gas pipeline can be brought in through the right or left side of

the appliance. Consult the current National Fuel Gas Code, ANSI

Z223.1 CAN/CGA-B149 (.1 or .2) installation code.

Installing a New Main Gas Cock

Each appliance should have its own manual gas cock.

A manual main gas cock should be located in the vicinity of

the unit. Where none exists, or where its size or location is not

DGHTXDWH FRQWDFW \RXU ORFDO DXWKRUL]HG LQVWDOOHU IRU LQVWDOODWLRQ

or relocation.

Compounds used on threaded joints of gas piping shall be resistant

WRWKHDFWLRQRIOLTXH¿HGSHWUROHXPJDVHV7KHJDVOLQHVPXVWEH

checked for leaks by the installer. This should be done with a soap

solution watching for bubbles on all exposed connections, and if

unexposed, a pressure test should be made.

1HYHUXVHDQH[SRVHGÀDPHWRFKHFNIRUOHDNV$SSOLDQFHPXVW

be disconnected from piping at inlet of control valve and pipe

capped or plugged for pressure test. Never pressure test with

appliance connected; control valve will sustain damage!

NOTE: 7KHPLOOLYROWJDVFRQWUROVDUHHTXLSSHGZLWKDFDSWXUHG

screwtypepressuretestpoint,thereforeitisnotnecessarytoprovide

a 1/8" test point up stream of the control.

2QGLUHFWLJQLWLRQYDOYHVKH[SOXJVPD\EHUHSODFHGZLWKKRVH¿WWLQJV

IRUSUHVVXUHFKHFNVWKHQUHLQVWDOOHGEHIRUHRSHUDWLQJ¿UHSODFH

:KHQXVLQJFRSSHURUÀH[FRQQHFWRUXVHRQO\DSSURYHG¿WWLQJV

Theapplianceandit’sindividualshutoffvalvemustbedisconnected

fromsupplypipingsystemduringanypressuretestingofthatsystem

at test pressures in excess of 1/2 psig (3.5kPa).

The appliance must be isolated from the gas supply piping system

by closing its individual manual shut off valve during any pressure

WHVWLQJRIWKHJDVVXSSO\SLSLQJV\VWHPDWWHVWSUHVVXUHVHTXDOWRRU

less than 1/2 psig (3.5kPa).

Attention! If one of the procedures results in pressures in excess

RISVLJZFN3DRQWKH¿UHSODFHJDVYDOYHLWZLOO

result in a hazardous condition.

Gas Supply Pressure (inches w.c.)

Minimum Normal Maximum

Natural Gas 4.5" 7.0" 14.0"

LP (Propane) 10.8" 11.0" 14.0"

Manifold Pressure (inches w.c.)

Normal (HI)

Natural Gas 3.5"

LP (Propane) 10.0"

Recommended Gas Pipe Diameter

Pipe Length

(Feet) Schedule 40 Pipe

Inside Diameter Tubing, Type L

Outside Diameter

Nat. L.P. Nat. L.P.

0-10 1/2"

12.7mm 3/8"

9.5mm 1/2"

12.7mm 3/8"

9.5mm

11-40 1/2"

12.7mm 1/2"

12.7mm 5/8"

15.9mm 1/2"

12.7mm

41-100 1/2"

12.7mm 1/2"

12.7mm 3/4"

19mm 1/2"

12.7mm

101-150 3/4"

19mm 1/2"

12.7mm 7/8"

22.2mm 3/4"

1.9 mm

Note:1HYHUXVHSODVWLFSLSH&KHFNWRFRQ¿UPZKHWKHU\RXUORFDO

codes allow copper tubing or galvanized.

Note: Since some municipalities have additional local codes, it is

always best to consult your local authority and installation code.

The use of the following gas connectors is recommended:

— ANSZ21.24ApplianceConnectorsofCorrugatedMetalTubing

and Fittings.

— ANS Z21.45 Assembled Flexible Appliance Connectors of

Other Than All-Metal Construction

The above connectors may be used if acceptable by the authority

KDYLQJMXULVGLFWLRQ7KHVWDWHRI0DVVDFKXVHWWVUHTXLUHVWKDWDÀH[LEOH

appliance connector cannot exceed three feet in length.

GAS SUPPLY

26534-1-0610 Page 9

Figure 7

Checking Manifold Pressures

Both Propane and Natural gas valves have a built-in pressure

regulator in the gas valve. Natural gas models will have a manifold

pressure of approximately 3.5" w.c. (.871kPa) at the valve outlet

with the inlet pressure to the valve from a minimum of 4.5" w.c.

(1.120kPa) for the purpose of input adjustment to a maximum of

14.0" w.c. (3.484kPa). Propane gas models will have a manifold

pressure approximately 10.0" w.c. (2.49kPa) at the valve outlet

with the inlet pressure to the valve from a minimum of 10.8" w.c.

(2.68kPa) for the purpose of input adjustment to a maximum of

14.0" w.c. (3.484kPa).

Figure 8

GAS SUPPLY (CONT)

26534-1-0610Page 10

Framing dimension "A" includes a three inch clearance for

VWDQGRIIVRQ¿UHER[

Framing and Finishing

1. Choose unit location.

  )UDPHLQ¿UHSODFHZLWKDKHDGHUDFURVVWKHWRS,WLVLPSRUWDQW

WRDOORZIRUWKH¿QLVKHGIDFHWKLFNQHVVZKHQVHWWLQJWKHGHSWK

of the frame. See Figures 9 & 11.

  $WWDFK¿UHSODFHWRIUDPLQJXVLQJDGMXVWDEOHQDLOLQJÀDQJHV

Preset depth to suit facing material (adjustable to 1/2", 5/8" or

3/4" depths).

4. Use (8)1/2" hex-head screws suppliedin hardware package to

VFUHZWKURXJKVORWWHGKROHVLQQDLOLQJÀDQJHVWKHQVFUHZLQWR

SUHGULOOHGKROHVRQ¿UHSODFHVLGH0HDVXUHIURPIDFHRI¿UHSODFH

WRIDFHRIWKHQDLOLQJÀDQJHVWRGHWHUPLQH¿QDOGHSWK

9HQW3LSH&OHDUDQFH

Note: Maintainoneinch(1")ofclearancearoundverticalventpipe.

)ROORZWKH%9HQWV\VWHPLQVWUXFWLRQVIRULQVWDOODWLRQUHTXLUHPHQWV

and clearances. Failure to follow the B-Vent manufacturer's

LQVWUXFWLRQVPD\FDXVHLPSURSHUGUDIWDQGSRVVLEOH¿UHKD]DUG

Figure 10

,QVWDOOWKH)UHVK$LU.LW%9$

Afresh air kit is available as an optional feature with this appliance.

The fresh air kit helps to decrease the amount of room air taken by

utilizing outside airfor combustion. It isstrongly recommended that

it be installed. Installation of the fresh air kit should be performed

DWWKHIUDPLQJVWDJHRIWKH¿UHSODFHLQVWDOODWLRQ

7KHIUHVKDLUNLWLQVWDOOVRQWKHOHIWVLGHRIWKH¿UHSODFH

ToinstalltheBVA1freshairkit,refertotheinstallationinstructions

provided with the kit.

Note: The outside air kit can terminate at any level with the

exception that it must terminate at least 1 ft below the vent

terminationcap.Thefreshairkitinlethoodshouldbepositioned

at least 2 ft above the ground level, in a manner that will not

allow snow, leaves, etc. to block the inlet.

WARNING: Exhaust products of gasoline engines are

KD]DUGRXV7KHRXWVLGHDLUPXVWQRWEHWDNHQIURPDJDUDJH

VSDFHDWWLFVSDFHVEDVHPHQWVRUDERYHWKHURR¿QJZKHUH

RWKHUKHDWLQJDSSOLDQFHIDQVRUFKLPQH\VH[KDXVWRUXWLOL]H

the air.

Figure 9

Framing (Figure 11)

)LUHSODFHIUDPLQJFDQEHEXLOWEHIRUHRUDIWHUWKH¿UHSODFHLVVHWLQ

place.Framingshouldbepositionedtoaccommodatewallcovering

DQG ¿UHSODFH IDFLQJ PDWHULDO 7KH ¿UHSODFH IUDPLQJ VKRXOG EH

constructed of 2 x 4 lumber or heavier. The framing headers may

UHVWRQWKH¿UHSODFH VWDQGRIIV5HIHUWR )LJXUH IRUPLQLPXP

framing dimensions.

CAUTION: MEASURE FIREPLACE DIMENSIONS AND

9(5,)<)5$0,1*0(7+2'6$1':$//&29(5,1*

DETAILS BEFORE FRAMING CONSTRUCTION

BEGINS.

INSTALLATION

This manual suits for next models

Table of contents

Other Empire Comfort Systems Indoor Fireplace manuals

Empire Comfort Systems

Empire Comfort Systems DVCC32BP30N-3 User manual

Empire Comfort Systems

Empire Comfort Systems VFD32FB0L-3 Quick start guide

Empire Comfort Systems

Empire Comfort Systems St.Clair 3000 User manual

Empire Comfort Systems

Empire Comfort Systems OP36FP32MN-1 User manual

Empire Comfort Systems

Empire Comfort Systems Mantis Series User manual

Empire Comfort Systems

Empire Comfort Systems DVP36CPWH User manual

Empire Comfort Systems

Empire Comfort Systems White Mountain Hearth DVTL27FP90N-1 Quick start guide

Empire Comfort Systems

Empire Comfort Systems Deluxe VFD32FB0L-3 Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVX36FP33CL Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVD32FP33N-4 User manual

Empire Comfort Systems

Empire Comfort Systems INTERMITTENT PILOT DVCD36FP70 User manual

Empire Comfort Systems

Empire Comfort Systems DVL25IN33N-1 User manual

Empire Comfort Systems

Empire Comfort Systems DVP42 Series Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVP36XKR-1 User manual

Empire Comfort Systems

Empire Comfort Systems VFHS-20R-1 User manual

Empire Comfort Systems

Empire Comfort Systems DVCT30CBN95N-1 Planning guide

Empire Comfort Systems

Empire Comfort Systems AV36MTEKN-1 Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVP20MS Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVCP36PP30 Series Quick start guide

Empire Comfort Systems

Empire Comfort Systems DVCT36CBP95N-2 Series Planning guide

Empire Comfort Systems

Empire Comfort Systems White Mountain Hearth DVCX42FP91K-3 Quick start guide

Empire Comfort Systems

Empire Comfort Systems EBL34 User manual

Empire Comfort Systems

Empire Comfort Systems VF24FP2-1 Quick start guide

Empire Comfort Systems

Empire Comfort Systems Boulevard VFLB60FP90N-1 Planning guide

Popular Indoor Fireplace manuals by other brands

Brigantia

Brigantia 35-DVRS31N-2 User's installation, operation and maintenance manual

Nordpeis

Nordpeis Bergen Installation and user manual

Superior

Superior BCT2536TMN Installation and operation instructions

Quadra-Fire

Quadra-Fire 5100I-GD-B owner's manual

Renaissance

Renaissance RUMFORD 1000 user manual

Lacunza

Lacunza IV-800 Instruction book

Baxi

Baxi 940 Installer and owner guide

Dru

Dru Maestro 60/2 Tall RCH installation manual

Diamond Fireglass

Diamond Fireglass SS-O22 General assembly, installation, and operation instructions

HearthStone

HearthStone Windsor Bay 8830 Owner's manual and installation guide

Napoleon

Napoleon ASCENT B42 quick start guide

Enviro

Enviro E33GI owner's manual

Smeg

Smeg L30 FABE Installation & user's instructions

KEDDY

KEDDY K700 Installation instructions care and firing instructions

Godin

Godin 3451 manual

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Installation and operation instructions

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 operating manual

Desa

Desa CCFPDFT Owner's operating & installation manual