Elecate Grill ELVGRL-X User manual

IMPORTANT

DANGER & WARNINGS

You Must Read This User Manual Before Operating Your Gas Grill

USER MANUAL

For Model: ELVGRL-X

Keep This Manual For Future Reference

POINTELEVATE.COM

!DANGER !DANGER

If you smell gas:

1. Shut off gas to the grill by

turning the control to the off

position.

2. Extinguish any open ﬂames.

3. Open lid.

4. If odor continues, keep

away from the appliance

and immediately call your

gas supplier or your ﬁre

department.

Failure to follow these instructions

could result in fire, explosion or

burn hazard, which could cause

property damage, personal injury

or death.

This manual contains important information necessary for proper assembly and safe use

of the appliance. Read and follow all warnings and instructions before assembling and

using the appliance. Follow all warning and instructions when using the appliance.

1. Never operate this appliance

unattended.

2. Never operate this appliance

within 10 ft. (3m) of any structure,

combustable material or other

gas cylinder.

3. Never operate this appliance

within 25 ft. (7.5m) of any

ﬂammable liquids.

4. If a ﬁre should occur, keep

away from the appliance and

immediately call your ﬁre

department. Do not attempt to

extinguish an oil or grease ﬁre

with water.

Failure to follow these instructions

could result in ﬁre, explosion or burn

hazard, which could cause property

damage, personal injury or death.

DANGER & WARNINGS

If there are local codes that apply to the portable

gas grills, you must conform with local codes or,

in the absence of local codes, with the National

Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and

Handling of Liqueﬁed Petroleum Gases, ANSI/

HFPA 58; or Natural Gas and Propane Installation

Code, CSA B149.1; Propane Storage and Handling,

CSA B149.2.

The LP gas supply cylinder must be constructed

and marked in accordance with the speciﬁcations for

LP gas cylinders, U.S. Department of Transportation

(DOT) or the Standard for Cylinders, Spheres and

Tubes for the Transportation of Dangerous Goods,

CAN/CSA-B339.

California Proposition 65 Warning: The burning

of gas cooking fuel generates some by-products

which are on the list of substances known by the

State of California to cause cancer and reproductive

harm. California law requires businesses to

warn customers of potential exposure to such

substances. To minimize exposure to these

substances always operate this unit according

to this grill manual, ensuring you provide good

ventilation when cooking with gas.

DANGER & WARNINGS

You must read this owner’s manual before operating your gas grill for the rst time.

GENERAL INSTRUCTIONS

• Follow all-leak check procedures carefully

listed in this manual prior to barbecue

operation. Do this even if a dealer assembled

the barbecue.

• Improper assembly may be dangerous.

Carefully follow the assembly instructions.

• After a period of storage and/or non-use,

carefully inspect the grill for gas leaks

or damages.

• Do not operate the grill if there is a gas-

leak present.

• Do not leave the appliance unattended. Keep

children and pets away from the appliance at

all times.

• Check and clean burners/venturi tubes for

insects and insect nests. A clogged tube can

lead to a ﬁre beneath the appliance.

• Do not use a ﬂame to check for gas leaks.

• Combustible materials should never be 24

inches of the grill.

• Children should never use the grill. Parts

of the grill get extremely hot and unsafe

to touch.

• Exercise reasonable care when operating

your grill. It will be hot during cooking and

cooling periods.

• Grill should be operated stationary.

• Grill should never be moved while under

operation. Follow the safety guidelines in

this manual for proper transportation of

this product.

• Should the burner go out while in operation

for any reason besides propane cylinder

being empty, turn off flow of gas and wait

ﬁve (5) minutes.

• Do not place charcoal or any material in your

grill. This is a gas barbecue grill.

• Never lean over an open grill while it

is operating.

• Never place hands or ﬁngers on the edge of

the cooking surface while grill is operating

or cooling.

• Certain parts of the grill will get hot under

operation. Exercise reasonable care while

grill is operating.

• Do not attempt to enlarge valve oriﬁce or

burner ports.

• Grill should be thoroughly cleaned on a

regular basis.

• The regulator supplied should only be used

with the Elevate Grill.

• This is a propane gas grill; not a natural gas

grill. Using natural gas with this grill will void

your warranty.

• Use heat-resistant barbecue gloves or mitts

when operating the barbecue grill.

• Keep grill away from electrical cord, any

heated surface and combustible byproducts

when in operation.

• This grill is intended to be used outdoor only.

• Do not operate this grill in a building, garage

or any other enclosed area.

• This grill is not intended to be installed in or

on a boat. This appliance is not intended to be

installed in or on recreational vehicles.

• Maintain proper clearance from combustible

construction, the minimum clearances must

be deﬁned (recommend 24 inches) from such

construction to the sides and back of the

appliance, and that the appliance shall not

be located used under overhead unprotected

combustible construction.

• Do not operate or attempt to start this grill

unless all parts are in place and in the proper

area assigned in this manual.

• Do not attempt to remove the regulator or

any gas ﬁtting while your barbecue grill is

in operation.

• Do not tamper, alter or modify any parts of

this grill. In doing so may cause explosion

resulting in property damage and serious

bodily harm, which may result in severe

injuries or death.

• Do not use this grill as a campﬁre

or heater.

• This grill is not intended for commercial use.

• Do not store a spare gas cylinder in or near

the appliance.

• If the instructions are not followed exactly,

a ﬁre causing death or serious injury may occur.

KNOWING YOUR GRILL

Grill

Regulator

Gas Circuit

Burner Assembly

Knob

Drip Tray

Grill Housing

Handle Assembly

Canister Door

Housing Top

Grill Housing Bracket

Lower Housing Bracket

Side Cover

Battery Cover

Feet

PARTS LIST:

MODEL #: ELVGRL-X

1. Locate Battery Compartment on the bottom of

the base.

4. Insert battery negative ﬁrst.

2. Remove battery compartment cover. 5. Replace and tighten battery cap.

3. Rotate counter-clockwise to loosen battery cap. 6. Replace battery compartment cover.

BATTERY INSTALLATION

SETTING UP YOUR GRILL FOR THE FIRST TIME

1. Place grill on steady ﬂat surface with the base

level to the surface.

2. Separate carrying handles and rotate

downwards until the handles engage the

locking position.

3. Unfold grill and lower each side until handle/

legs rest upon the ﬂat surface.

4. Insert the grate indentation under the grill lip

and then lower gently until grate rests evenly

in the grill.

5. Repeat the same process for second adjacent

side.

LEAK TESTING

After a period of nonuse, we recommend that you

perform the following maintenance procedures

for your safety.

• Inspect the burner for correct ﬂame pattern.

Clean if necessary, following the procedures

outlined in the “Maintanence” section of this

manual.

• Check all gas ﬁttings for leaks.

You will need soap, water solution and a rag to

conduct a leak test. To perform leak checks,

make sure the burner is in the OFF position. DO

NOT IGNITE BURNER WHILE LEAK CHECKING.

Check for leaks by wetting the connection with

the soap and water solution. Watch for bubbles.

If bubbles form or if a bubble grows, there is a

leak. If there is a leak, do not operate grill and

use a different propane cylinder and recheck for

leaks later. If a leak persists after retightening

the propane cylinder, contact our customer

service team located on the back of this manual.

!WARNING

You should check for gas leaks

every time you disconnect and

reconnect a gas ﬁtting.

!WARNING

Perform these leak checks even

if your grill was dealer or store-

assembled.

!WARNING

If you see, smell or hear the hiss

of escaping gas from the propane

cylinder:

1. Move away from the propane

cylinder.

2. Do not attempt to correct the

problem yourself

3. Call your ﬁre department.

NOTE: All factory-made connections have been

thoroughly checked for gas leaks. The burners

have been ﬂame tested. As a safety precaution,

you should recheck all ﬁttings for leaks before

using your Elevate grill. Shipping and handling

may have loosened or damaged a gas ﬁtting.

ATTACHING REGULATOR

& PROPANE CYLINDER (16.4 CANISTER)

1. Remove plastic cap on propane cylinder if

applicable.

2. Screw propane bottle into regulator hand tight by

rotating clock-wise. (Fig. 01)

3. Attach regulator to the inlet valve located behind

the base of the grill (Fig. 02).

4. Rotate the locking mechanism clock-wise

hand tight. (Fig. 03)

FIG. 03

FIG. 01

FIG. 02

Note: Use only propane cylinders with the capacity of 16.4 oz./465 g (1.02 lbs.). You can ﬁnd these tanks

available in most sporting and hardware stores.

Statement: The LP gas supply cylinder must be constructed and marked in accordance with the

speciﬁcations for LP gas cylinders, U.S. Department of Transportation (DOT) or the Standard for

Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods, CAN/CSA-B339.

Statement: The pressure regulator and regulator assembly supplied with the appliance must be used.

Replacement pressure regulator must be those speciﬁed by the manufacturer.

Statement: The cylinder supply system must be arranged for vapor withdrawal.

5. Grill with regulator and propane cylinder

properly assembled. (Fig. 04)

6. Never operate grill with propane cylinder in an

inverted position. (Fig. 05)

FIG. 04

FIG. 05

!WARNING

Do not use a wrench to tighten the

propane cylinder to the regulator.

Using a wrench could damage the

regulator coupling and cause a leak.

!WARNING

If there is a leak at connection,

remove the propane cylinder.

Do not operate grill and use a

different propane cylinder.

Table of contents

Popular Grill manuals by other brands

Orbegozo

Orbegozo GR 2300 instruction manual

bora

bora PT11 Operating and installation instructions

Klarstein

Klarstein 10031664 manual

Garland

Garland MWE3W Installation and operation manual

Char-Broil

Char-Broil 463722714 Product guide

Nexgrill

Nexgrill 720-0830HK Operating instruction

Kenmore

Kenmore 415.16123800 Use and care guide

Camp Chef

Camp Chef PG24CLAU Warning & instruction booklet

Tucker Barbecues

Tucker Barbecues GTR Series Assembly, installation and operating instructions

Monogram

Monogram ZGG540NCP1SS owner's manual

Equipex

Equipex Sodir Savoy Operation manual

Gaggenau

Gaggenau VR 414 610 use and care manual

Miele

Miele KM 408-1 operating instructions

George Foreman

George Foreman GGR50B owner's manual

AOG

AOG T series quick start guide

Gorenje

Gorenje TG2000CB Instruction manua

Weber

Weber Genesis Silver-B Permamount NG 051701 owner's guide

Glen

Glen SA 3037 user guide