Bosch 715ES Reference manual

Models: 715ES, C800ES, 2400ES, 2700ES, Evolution 500, Integra 500

Removing and replacing water valve

Service Bulletin G3-26

Introduction

When replacing the watervalve, it is very important to drain all

water from the water heater beforehand to prevent water

damage to the internal electronics.

Tools needed:

Phillips head screwdriver

Bucket to catch draining water

Plumber’s grease

Removing the water valve

1. Press On/Off button to Off and unplug power cord from electrical

outlet.

2. Loosen two Phillips head screws located at bottom rear of cover.

(Fig. 1).

3. Lift front cover upward and remove. (Fig. 1).

Step 1 Step 2

tep

Figure 1

4. Remove 3 Phillips screws from control unit (Fig. 2, step 1)

4. Place water heater‘s control unit into the service position.

(Fig. 2, step 2).

Step 2Step

Figure 2

Water

valve

5. Close installer supplied inlet and outlet shutoff valves.

6. Relieve water pressure from unit by opening pressure relief valve

on hot outlet side of unit. Have a bucket ready to catch the

draining water. Drain water from unit by removing cold water

inlet connection on bottom of heater.

Data subject to change without notice | Printed in the USA | BTC 710002311 B | 05.2009 Bosch Thermotechnology Corp.

Service bulletin

18 | G3-26 | 715ES, C800ES, 2400ES, 2700ES, Evolution 500, Integra 500

Bosch Thermotechnology Corp.

50 Wentworth Avenue

Londonderry, NH 03053

Tel: 1-866-642-3198

Fax: 1-603-584-1681

www.boschhotwater.com

7. Unplug smaller wire connectors (A) from water valve.

(Fig. 3).

8. Remove pipe clips (C) located at the base and side of water

valve. (Fig. 3).

9. With a rag ready to catch residual water, lift water valve upwards

to separate it from the brass inlet connection (D). (Fig. 3).

Please note only 715ES, C800ES, C920ES, C920ESC models

have a water lter screen in the base of the water valve.

10. Again with a rag ready to catch residual water, pull water valve

from pipe (E). (Fig. 3).

11. Remove water valve from heater and remove main wire plug

connection (B) from water valve. (Fig. 3)..

Figure 3

Replacing the water valve

1. Lubricate o-rings (F) with plumbers grease to prevent o-ring

damage or leaks. (Fig. 3).

2. Install replacement water valve by seating the side pipe

connection (E) rst (Fig. 3). Be careful to push water valve body

past o-ring on connecting pipe.

3. Reconnect clip (C) for side pipe connection. (Fig. 3).

4. Reinstall water valve onto brass inlet tting (D) (Fig. 3). Be

careful to seat water valve body past o-ring on inlet tting.

5. Reconnect remaining clip (C) on inlet tting connection (Fig. 3).

6. Check that both clips (C) are seated correctly in the anges

(Fig. 2). Improper seating will result in water leaks.

7. Reconnect main wire plug connection (B) to water valve. (Fig. 3).

8. Reconnect smaller wire connectors (A) for the water valve and

temperature sensor wires. (Fig. 3).

9. Open installer supplied inlet and outlet shutoff valves and

inspect for water leaks.

10. If no water leaks are present, return control unit to normal

position and secure with 3 Phillips screws (Fig 2). Plug power

cord into electrical outlet and push power button back to "On"

position. If an error code appears on the heater display, reset

the unit with the reset button. If error code reappears on the

display, press power switch to Off and check all wire

connections.

11. Push power switch back to On. If no errors are present, replace

cover and return heater to normal operation.

Other manuals for 715ES

This manual suits for next models

Other Bosch Water Heater manuals

Bosch

Bosch TR2500TO User manual

Bosch

Bosch THERM 1000 O Guide

Bosch

Bosch Tronic 3000 C Pro US12 User manual

Bosch

Bosch 8 718 686 408 0 Quick start guide

Bosch

Bosch Comfort Plus TR 4000 User manual

Bosch

Bosch Aquastar GWH 1600 H N User manual

Bosch

Bosch AquaStar 125B NGS User manual

Bosch

Bosch GWH 2400 ES NG User manual

Bosch

Bosch GWH 715 ES Instructions for use

Bosch

Bosch Stora WS 300-5 PK Operating instructions

Bosch

Bosch 125B LP User manual

Bosch

Bosch Tronic 5000 Series User manual

Bosch

Bosch Compress 3000 DW FOO User manual

Bosch

Bosch WR400-1K Series Owner's manual

Bosch

Bosch Compress 3000 User manual

Bosch

Bosch 520HN Reference manual

Bosch

Bosch Tronic 1000 4 T User manual

Bosch

Bosch WR 11 G Series Technical Document

Bosch

Bosch BC3200RABC3200RA5 User manual

Bosch

Bosch OptiFlow Professional GWH12 1 CTD E23 User manual

Bosch

Bosch TR8500 15/18 DESOB User manual

Bosch

Bosch C 950 Owner's manual

Bosch

Bosch GWH 10-2 G Series Technical Document

Bosch

Bosch TR5000 24EB User manual

Popular Water Heater manuals by other brands

Kenmore

Kenmore 153.582400 Use & care guide

Applimo

Applimo Edel AIR Installation and operating instructions

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Operating and installation instructions

clage

clage E-Mini Series Operating and installation instructions

Toyotomi

Toyotomi Oil Miser OM-180 installation manual

Bradford White

Bradford White EF Series Service manual

Eccotemp

Eccotemp 40-H Use & care manual

Dimplex

Dimplex ECSd125-580 Installation and user instructions

Dux

Dux 32FCR6N installation manual

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Operation and maintenance instructions

Noritz

Noritz N-132M Owner's guide and installation manual

TESY

TESY GCV7/4S 10047 Instructions for use and maintenance

A.O. Smith

A.O. Smith Gphe 50 instruction manual

Koryo

Koryo KWHZF15Y user manual

Pentair

Pentair PSC-14-4-02 Installation and operation manual

GE 40M06AAG Energy guide

Thermor

Thermor AEROMAX SPLIT 2 Instructions for use

American Hometec

American Hometec AHQ-B03X Installation and operation manual