BMW R1200GS User manual

1

BMW R1200GS Motorcycle (W348)

Customer Service Guide

MMXV © Copyright Rollplay

2

Customer Service Guide

Contents

I) Check Battery …………………………............................................. 3

II) Check Wiring Condition ……………………………..………………………. 6

III) Windshield Replacement ……………………………………………..….…. 9

IV) Gearbox Replacement ……………………………………………………… 10

V) Warning Stickers ……………………………………………..…….………… 14

VI) Schematic diagram ……………..…………….…..….………..…………. 17

VII) Exploded View ………………………....…....….……….……..……..…18

CAUTION :

Disconnect the battery before proceeding

with the following steps.

3

Customer Service Guide

I) Check Battery

Operation: Use a Flat head screwdriver to unlock and remove the seat. Locate the

battery harness, unplug the connector, and then use a volt-meter to check the

condition of the battery.

Step (1)

Turn and unlock this plastic knob

Step (2)

Unlock position

4

Customer Service Guide

I) Check Battery

Step (3)

Lift up the seat cover from the rear end

Step (4)

Unplug the battery connector underneath the seat

5

Customer Service Guide

I) Check Battery

Step

(5)

Reading Judgment: 6.0 V ~ 6.5 V –Good condition

5.6 V ~ 5.9 V –Recharge battery

5.5 V –Recharge battery. If after the stipulated

recharging time the voltage has not

increased, then replace the battery.

Below 5.5 V –Replace the battery.

6

Customer Service Guide

II) Check Wiring Connection

Operation: There are two wiring connections that should be checked.

A. Motor/Gearbox : Turn over the vehicle and locate the Gearbox harness at the

bottom.

Step (1)

The motor harness is near the rear wheel

Step (2)

Check the white connectors. Disconnect, then reconnect these connectors.

7

Customer Service Guide

II) Check Wiring Connection

B. Handlebar/Sounds : Disassemblethe windshield and check the two

connections per the below procedures.

Use a flat screwdriver to remove the bracket next to the windshield

Step (1)

Release the latch at the front

Step (2)

8

Customer Service Guide

II) Check Wiring Connection

Step (3)

Lift up the whole windshield

Check for any loose connectionson the handlebars.

Step (4)

Reverse the above procedures to reassemble the vehicle.

9

Customer Service Guide

III)Windshield Replacement

Operation: Follow the procedure (IIb) to detach the windshield,and then unplug the two

connectors to remove it completely for replacing.

Replace the Handlebar sub-assembly with a new one.

Reverse above procedures to re-assemble the vehicle

10

Customer Service Guide

IV)Gearbox Replacement

Operation: Follow below steps to replace the gearbox.

Use the two plastic wrenches to remove the nuts at both sides

Step (1)

Step (2)

Unscrew the motor cover on the left side of rear wheel.

Other manuals for R1200GS

1

Table of contents

Other BMW Motorcycle manuals

BMW

BMW K 1300 S User manual

BMW

BMW 1200 ST BROCHURE 2005 User manual

BMW

BMW F 800 R - Installation and maintenance manual

BMW

BMW K 1600 GT Installation and maintenance manual

BMW

BMW R 1200 RT - 2006 Installation and maintenance manual

BMW

BMW R 1200 GS ADVENTURE Installation and maintenance manual

BMW

BMW K 1200 LT User manual

BMW

BMW R 1200 RT-P 2015 Wiring diagram

BMW

BMW K 1200 GT - Installation and maintenance manual

BMW

BMW R 1200 CL User manual

BMW

BMW 2011 R 1200 GS Installation and maintenance manual

BMW

BMW F 650 GS Installation and maintenance manual

BMW

BMW R 1100 RS Operating instructions

BMW

BMW F 800 GT Installation and maintenance manual

BMW

BMW F 800 R - Installation and maintenance manual

BMW

BMW R 1200 RT Installation and maintenance manual

BMW

BMW K 1300 S User manual

BMW

BMW R 1200 GS Adventure Rallye 2017 User manual

BMW

BMW F 650 GS 2007 Operating and maintenance instructions

BMW

BMW K 1200RS Operating instructions

BMW

BMW HP4 Installation and maintenance manual

BMW

BMW F 800 R - User manual

BMW

BMW G 650 Xchallenge Installation and maintenance manual

BMW

BMW F 800 ST Installation and maintenance manual

Popular Motorcycle manuals by other brands

OHVALE

OHVALE GP-0 Use & maintenance

Yamaha

Yamaha Star XV19CTSZ 2009 owner's manual

KTM

KTM 350 XCF-W USA owner's manual

HYOSUNG

HYOSUNG ST7 owner's manual

Husqvarna

Husqvarna FC 250 2016 owner's manual

Ducati

Ducati SCRAMBLER 800 Workshop manual

MOTO GUZZI

MOTO GUZZI QUOTA 1100 ES owner's manual

APRILIA

APRILIA ETV MILLE CAPONORD - PART1 02-2001 manual

Yamaha

Yamaha 2006 YZF-R1V owner's manual

KTM

KTM Freeride E-XC 2021 owner's manual

Fantic

Fantic Enduro 125 user manual

Ducati

Ducati Supersport 750 desmodue owner's manual

MV Agusta

MV Agusta 2008 F4 312RR 1078 Workshop manual

Yamaha

Yamaha XVS650A owner's manual

Yamaha

Yamaha YZF-R6T(C) Supplementary service manual

Ducati

Ducati 748 monoposto strada owner's manual

ATK

ATK 1988 250 owner's manual

Excelsior-HENDERSON

Excelsior-HENDERSON 1999 HCX Riders handbook