BARRON TRACE-LITE AXL2 User manual

AXL2 (80-280W)

INSTALLATION INSTRUCTIONS

800.533.3948 • www.barronltg.com

Mounting Preparation

Slip Fitter (fits up to 2 3/8” OD)

1. Separate the slip-fitter from the knuckle by removing the adjustment bolt with a hex wrench (provided by

others) (Fig. 1).

2. Feed wire leads from the AXL2 through the knuckle and attached the knuckle to the head (Fig. 2).

3. Feed wire leads through the slip-fitter and then attach the slip-fitter to the knuckle (Fig. 3).

4. Electrical connections should be made at this time (see Wiring section).

5. Install the slip-fitter on the pole and secure with screws.

IMPORTANT SAFEGUARDS

READ AND FOLLOW ALL SAFETY INSTRUCTIONS.

When using electrical equipment, basic safety precautions should always be followed including the following:

• DISCONNECT AC POWER SUPPLY BEFORE SERVICING.

• Installation and servicing of this equipment should be performed by qualified service personnel only.

• Ensure that the electrical wiring conforms to the National Electrical Code NEC® and local regulations if applicable.

• Do not mount near gas or electric heaters.

• Equipment should be mounted in locations and at heights where it will not be readily subjected to tampering by

unauthorized personnel.

• The use of accessory equipment not recommended by the manufacturer may cause an unsafe condition.

• Any modification or use of non-original components will void the warranty and product liability.

• Do not use this equipment for other than intended use.

SAVE THESE INSTRUCTIONS!

Fig. 1 Fig. 2 Fig. 3

20070138 REV 1 P-5 - 2/19 1

Trunnion

1. Feed wire leads through slot in trunnion (Fig. 4).

2. Attach trunnion to the head (Fig. 5).

Yoke

1. Attach yoke to the head using a hex wrench (provided by others) (Fig 6).

INSTALLATION INSTRUCTIONS

800.533.3948 • www.barronltg.com

Fig. 4 Fig. 5

Fig. 6

20070138 REV 1 - 2/19

AXL2 (80-280W)

Surface/Pole Mounting

Slip-Fitter

1. Connect wires from AXL2 to supply (see Wiring section) and

position wires inside pole (Fig. 7)

2. Secure slip-fitter over pole and tighten.

3. To position, loosen the adjustment bolt using a hex wrench

(provided by others), position head as desired, then retighten

the bolt.

Notice: Adjustable angle is 0-90° (Fig. 7).

Arm

1. Disassemble the pole bracket from the arm.

2. If assembling to a round pole, remove and discard the adapter

gasket.

3. Using the pole bracket as a guide, drill holes in pole at desired

location.

4. Attach arm to pole with pole bracket inside pole.

5. Feed wire leads from the ALX2 through slot in arm.

6. Attach the AXL2 head to arm using adjustment bolt.

7. Adjust head to desired position and tighten adjustment bolt.

8. Wiring can be made inside the arm wiring compartment or inside

pole (see Wiring section).

9. Secure wiring cover to arm with gasket in between (Fig. 8)

Trunnion

1. Drill hole in mounting surface or rectangular pole.

2. Attach luminaire to mounting surface or retangular pole (Fig. 9).

3. Make supply connection in waterproof J-box or inside pole

(see Wiring section).

INSTALLATION INSTRUCTIONS

800.533.3948 • www.barronltg.com

Adjustment Bolt

Pole, round or rectangular

Slip Fitter

Pole

Bracket

Adapter

Gasket

Adjustment Bolt

Wiring Cover

Arm

Mounting surface

or rectangular pole

Fig. 7

Fig. 8

Fig. 9

20070138 REV 1 - 2/19

AXL2 (80-280W)

INSTALLATION INSTRUCTIONS

800.533.3948 • www.barronltg.com

Yoke

1. Drill hole in mounting surface or rectangular pole.

2. Attach AXL2 to mounting surface or rectangular pole

(Fig 12).

3. Make supply connection in waterproof J-box or inside pole

(see Wiring section).

Yoke Templates

Wiring

Make electrical connections as follows:

Black - Line

White - Neutral

Green/Yellow Green - Ground

If dimming is used:

Purple - Dim+

Gray - Dim-

Note: This fixture auto adjusts for voltages from 120-277V. Cap all

unused leads to prevent shorting.

IMPORTANT: Weatherproof your outdoor installation, be sure to seal

all holes in fixture housing. (Mounting, conduit, plugs, sensors and

photo-controls, etc.) with silicone sealant.

20070138 REV 1 - 2/19

Mounting surface

or rectangular pole

2.3"

1.2"

3.3" 0.5"

6-Φ0.5"

80-140W

2.3"

1.2"

3.3" 0.5"

6-Φ0.5"

240-280W

Φ0.8"

Φ0.79"

NEUTRAL

Fig. 12

LINE

NEUTRAL

AXL2 (80-280W)

Table of contents

Other BARRON Lighting Equipment manuals

BARRON

BARRON EXITRONIX SCL Series User manual

BARRON

BARRON Growlite GLB-315-A-120/277 User manual

BARRON

BARRON specialityLED RFX User manual

BARRON

BARRON EXITRONIX CRL Series User manual

BARRON

BARRON TRACE-LITE TL101 User manual

BARRON

BARRON TRACE-LITE WTA Series User manual

BARRON

BARRON Exitronix S900C Series User manual

BARRON

BARRON TL301 User manual

BARRON

BARRON EXITRONIX 82 Series User manual

BARRON

BARRON EXITRONIX ILX Series User manual

BARRON

BARRON EXITRONIX LED-51 Series User manual

BARRON

BARRON Exitronix NY900C Series User manual

BARRON

BARRON Exitronix LED-90 Series User manual

BARRON

BARRON Exitronix SCL Series User manual

BARRON

BARRON EXITRONIX VLED-90L Series User manual

BARRON

BARRON Exitronix VEX-8 NEMA User manual

BARRON

BARRON Exitronix NFT Series User manual

BARRON

BARRON EXITRONIX VLEDC Series User manual

BARRON

BARRON GROWLITE GRM User manual

BARRON

BARRON Speciality LED FBTCJ-24V User manual

BARRON

BARRON Growlite GRM User manual

BARRON

BARRON EXITRONIX LL30 Series User manual

BARRON

BARRON EXITRONIX EQUITY QMR Series User manual

BARRON

BARRON CP-EMW Series User manual

Popular Lighting Equipment manuals by other brands

Brizo

Brizo 8SP-MU-4 manual

LUCE&LIGHT

LUCE&LIGHT BROM 1.0 installation instructions

IKEA

IKEA BJÖRKSPIREA manual

Laserworld

Laserworld Evolution Series ES-400RGB manual

Alien

Alien RG STAR user manual

EuroLite

EuroLite LED B-40 user manual

Qazqa

Qazqa Suplux SL 3 Black 103062 instruction manual

Commercial Electric

Commercial Electric 54568141 Use and care guide

CREE LIGHTING

CREE LIGHTING 304 Series installation instructions

Goobay

Goobay 49867 user manual

ECOMAN ITALIA

ECOMAN ITALIA LED T8 instruction manual

Alkalite

Alkalite Krypton KT-81 user manual

Clas Ohlson

Clas Ohlson GU10 manual

DTS

DTS DELTA 10 F user manual

ring

ring Solar Steplight manual

One Stop Gardens

One Stop Gardens 57696 Owner's manual & safety instructions

Chauvet DJ

Chauvet DJ COREpar UV120 ILS user manual

SIREM

SIREM Swimeo A2 instructions