Barbas UNIVERSAL-6 65 Specification sheet

INSTRUCTIONS FOR USE & MAINTENANCE MANUAL

UNIVERSAL-6 65

Wood-burning appliance

Serial number:

Production date:

Barbas wishes you many cosy evenings with your new appliance

This document is an essential part of your appliance.

Read it carefully before use of the appliance and keep it in a safe place!

Version number: 03 - 339760

Date: 01-07-2019

UNIVERSAL-6 65

Instructions for use

Unique identification code of the product-type

Intended use or uses of the construction product, in

accordance with the applicable harmonised technical

specification, as foreseen by the manufacturer

Name, registered trade name or registered trade mark

and contact address of the manufacturer as required

pursuant to Article 11(5)

Where applicable, name and contact address of the

authorised representative whose mandate covers the

tasks specified in Article 12(2)

System or systems of assessment and verification of

constancy of performance of the construction product

as set out in Annex V

In case of the declaration of performance concerning a

construction product covered by a harmonised

standard

7. Declared performance

Fire safety

Distance to combustible materials Minimum distances, in mm

Insulation thickness rear = 100

Insulation thickness sides = 100

Insulation thickness ceiling = 100

Front = 800

Insulation thickness floor = 100

NPD

Thermal output

Energy efficiency

Signed for and on behalf of the manufacturer by:

Danny Baijens, CEO

(Name and function)

Bladel; September 18, 2018 ………………………………………………………………………..

(place and date of issue) (Signature)

The performance of the product identified in point 1 is in conformity with the declared performance in point 7.

This declaration of performance is issued under the sole responsibility of the manufacturer identified in point 3.

Water heating output

- kW

Pass

Nominal heat output

9 kW

Room heating output

9 kW

Electrical safety

Pass

Cleanability

Pass

Maximum operating pressure

Not applicable

Flue gas temperature at nominal heat output

T = 282 °C

78.8 %

NPD

Pass

Risk of burning fuel falling out

Pass

Declaration of Performance

According to regulation (EU) 305/2011

No. 1.801.003-3 - CPR-2013/07/01

Universal-6 65

Room heater without hot water supply

Barbas Bellfires BV; Hallenstraat 17; 5531 AB Bladel; The Netherlands

Not applicable

System 3

The notified laboratory SGS Nederland BV, No. 0608 performed the

determination of the product type on the basis of type testing under system 3

and issued test report EZKA/14/0164-11

Harmonized technical specification

EN13229:2001/A2:2004/AC:2007

Essential characteristics

Performance

CO = 0.07 vol%

Emission of combustion products

Mechanical resistance (to carry a chimney/flue)

Surface temperature

Release of dangerous substances

Pass

UNIVERSAL-6 65

Instructions for use

UNIVERSAL-6 65

Instructions for use

CONTENTS

Page

1. INTRODUCTION .............................................

.....

......

..........................

...... 7

2. SAFETY .......................................................................

.........................

...... 8

3. OPERATION ............................................................

......

.......

.....

..........

.. 10

4. USING THE APPLIANCE FOR THE FIRST TIME ........

....................

........ 11

5. USE ............................................................................................................. 14

6. FUEL ......................................................................

....

............................

..... 20

7. MAINTENANCE ......................................................

...................

.......

...

....... 22

8. FREQUENTLY ASKED QUESTIONS .....................

...............

.........

.....

...... 24

9. TECHNICAL DATA ....................

...............................................

...........

.....

... 28

10. WARRANTY TERMS ....................

...........................................................

... 30

UNIVERSAL-6 65

Instructions for use

UNIVERSAL-6 65

Instructions for use

1 INTRODUCTION

Congratulations on your purchase of this modern Barbas appliance.

This quality product will provide you with many years of enjoyment due to the ﬂame

effect and warmth that it provides.

This appliance is recommended as suitable for use in smoke control areas when

burning wood logs. The appliance, when sold into the UK market, include a factory-

installed modiﬁed air slider to ensure compliance with smoke emission requirements

within smoke control areas.

Study this manual carefully before using the ﬁreplace. We recommend you keep this

manual in a safe place for reference purposes.

The images in this manual are made of a different variant of this appliance.

The depicted appliance may differ from your device, but the actions and instructions

shown are fully valid for the unit described here.

“The Clean Air Act 1993 and Smoke Control Areas”

Under the Clean Air Act local authorities may declare the whole or part of the district of

the authority to be a smoke control area. It is an offence to emit smoke from a chimney

of a building, from a furnace or from any ﬁ xed boiler if located in a designated smoke

control area. It is also an offence to acquire an “unauthorised fuel” for use within a

smoke control area unless it is used in an “exempt” appliance (“exempted” from the

controls which generally apply in the smoke control area).

In England appliances are exempted by publication on a list by the Secretary of State

in accordance with changes made to sections 20 and 21 of the Clean Air Act 1993 by

section 15 of the Deregulation Act 2015.

In Scotland appliances are exempted by publication on a list by Scottish Ministers under

section 50 of the Regulatory Reform (Scotland) Act 2014.

In Northern Ireland appliances are exempted by publication on a list by the Department

of Agriculture, Environment and Rural Affairs under Section 16 of the Environmental

Better regulation Act (Northern Ireland) 2016.

In Wales appliances are exempted by regulations made by Welsh Ministers.

Further information on the requirements of the Clean Air Act can be found here:

https://www.gov.uk/smoke-control-area-rules.

Your local authority is responsible for implementing the Clean Air Act 1993 including

designation and supervision of smoke control areas and you can contact them for

details of Clean Air Act requirements.

UNIVERSAL-6 65

Instructions for use

2 SAFETY

Do not place ﬂammable objects within 110 cm of the appliance.

Pay special attention to furnishings and ornaments around the

appliance.

When you use your appliance, the exterior will become hot. Always wear

the glove or use the accessories supplied when ﬁlling etc. Protect

yourself and others (especially children!) from burns. Do not leave

children unattended when the appliance is burning.

Watch your clothing. Synthetic clothing in particular can easily catch

ﬁre and burn intensely.

Do not approach the appliance with ﬂammable materials or liquids.

Any work with solvents, adhesives etc. in the space heated by the

appliance can be very dangerous.

It is not allowed to connect the appliance to a ﬂue which is already

connected to another appliance.

Make sure you know what state your chimney is in. Cracks in the

chimney may not only lead to damp, staining of walls and leaking

of smoke, they can also impair the carrying off of smoke. Make

sure you get proper advice from your dealer or other specialist

company.

Avoid chimney ﬁres! Have your chimney swept at least once per

year - more often if you use your appliance a lot. Prevent excessive

deposits of soot inside the chimney by not burning freshly-cut

wood. Instead, burn clean, dry chopped wood.

Ensure that the room in which the appliance is situated has adequate

ntilatio

It is essential that the appliance, the ﬂue and combustion air supply

are cleaned and inspected annually by a Barbas dealer/specialist.

The safe operation of the appliance will thus remain guaranteed.

UNIVERSAL-6 65

Instructions for use

The appliance must never be used with the door open or the door

glass removed.

Wood and wood briquettes may be stoked in the appliance.

Coals can’t be burned in the appliance.

Avoid over-loading (white burning glow), caused, for example, by

lengthy burning with a fully open primary air vent (combustion air

supply slider all the way to “ +”), or by burning too much wood in

one go. The appliance can then become over-heated.

Never use the appliance to burn rubbish.

Do not use your appliance as a barbecue. This can cause (ﬂammable)

fat deposits to be left in the chimney and hastens the chimney

becoming clogged.

Ensure at all times that children and other people who are not aware

of the operation of a wood-burning appliance are only in the vicinity of

the appliance exclusively under supervision.

Use a ﬁreguard to protect the people and children mentioned

above against possible burns.

The appliance is suitable and approved for intermittent use.

The appliance can be taken in operation if national and local regulations

are satisﬁed. The required constructive adaptations should be

satisﬁed as well.

UNIVERSAL-6 65

Instructions for use

3 OPERATION



1 Handle

2 Ceramic heat-proof glass

3 Convection air outlet opening (appliance)

4 Outlet opening (2x grate) (chimney breast) ventilation air chimney breast

5 Outlet opening (2x grill convection set) (chimney breast) convection air

6 Grate

7 Ashtray

8 Inlet opening (2x grate)(chimney breast) ventilation air chimney breast

9 Combustion air-supply slider (Combined operation for the primary, secondary and

tertiary combustion air-supply)

10 Inlet opening combustion air (if there’s no direct outside air supply)

Inlet opening convection air

Other manuals for UNIVERSAL-6 65

Table of contents

Other barbas Indoor Fireplace manuals

barbas

barbas 90-55 PF2 Operating instructions

barbas

barbas Cuatro-7 75-60 User manual

barbas

barbas ATLANTA Technical manual

barbas

barbas UNILUX-6 270 User manual

barbas

barbas ROYAL 3-SIDED OPEN User manual

barbas

barbas Unilux-7 70 User manual

barbas

barbas EVO 80-65 User manual

barbas

barbas BOX30 75 Manual

barbas

barbas 90-70 PF2 Operating instructions

barbas

barbas Universal-6 80 User manual

barbas

barbas UNIVERSAL-6 85 Specification sheet

barbas

barbas Unilux-7 75 Manual

barbas

barbas ENERGA 80-50 User manual

barbas

barbas BOX 55 User manual

barbas

barbas Unilux-7 80 User manual

barbas

barbas Evolux 100-45 Manual

barbas

barbas UNILUX-6 55 Specification sheet

barbas

barbas UNILUX-3300 User manual

barbas

barbas Unilux-7 40 Manual

barbas

barbas Wi-Fi Box / Puck User manual

barbas

barbas UNIVERSAL-6 60 User manual

barbas

barbas Cuatro-7 75-60 Manual

barbas

barbas Unilux-3 40 User manual

barbas

barbas BOX Panorama 65 User manual

Popular Indoor Fireplace manuals by other brands

Brigantia

Brigantia 35-DVRS31N-2 User's installation, operation and maintenance manual

Nordpeis

Nordpeis Bergen Installation and user manual

Superior

Superior BCT2536TMN Installation and operation instructions

Quadra-Fire

Quadra-Fire 5100I-GD-B owner's manual

Renaissance

Renaissance RUMFORD 1000 user manual

Lacunza

Lacunza IV-800 Instruction book

Baxi

Baxi 940 Installer and owner guide

Dru

Dru Maestro 60/2 Tall RCH installation manual

Diamond Fireglass

Diamond Fireglass SS-O22 General assembly, installation, and operation instructions

HearthStone

HearthStone Windsor Bay 8830 Owner's manual and installation guide

Napoleon

Napoleon ASCENT B42 quick start guide

Enviro

Enviro E33GI owner's manual

Smeg

Smeg L30 FABE Installation & user's instructions

KEDDY

KEDDY K700 Installation instructions care and firing instructions

Godin

Godin 3451 manual

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Installation and operation instructions

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 operating manual

Desa

Desa CCFPDFT Owner's operating & installation manual

barbas UNIVERSAL-6 65 Specification sheet

Popular Indoor Fireplace manuals by other brands