LFP
AVON
LiFePO4
Lithium Iron Phosphate
Battery (LiFePO4)
AVON LFP User Guide
This guide should be read in conjunction with the appropriate battery’s specication
sheet for any specic requirements, this should be available from your point of
purchase. Alternatively, it is downloadable from www.avonbattery.co.uk
1. All AVON LFP batteries are supplied partially charged. Therefore, please ensure your battery
is fully charged BEFORE it goes into service
2. Your AVON LFP battery can be charged by 99% of all current Lead Acid battery chargers
as the charge is controlled by the batteries internal BMS (Battery Management System),
However, we advise to use a charger that has either an ‘AGM’ or ‘GEL’ setting. If in doubt,
consult your AVON Battery distributor or the Avon Battery web Site
3. The Bluetooth App, where tted, may give inaccurate information for the rst 4 - 10 charge
and discharge cycles. During these initial cycles the BMS is balancing and calibrating the
multiple lithium cells and the App is learning each batteries parameters
4. If you intend to use multiple AVON LFP batteries in series, parallel or both please see page 1
of this manual for detailed instructions
IMPORTANT : PLEASE READ BEFORE USE
Disposal & Recycling
Disposal & Recycling of a used or damaged Avon LFP battery must either be done at a
certied recycling location. There are many of these nationwide or returned to your point of
purchase or directly to Avon Batteries – please see www.avonbattery.co.uk for details.
Warranty
Avon LFP batteries are supplied with a 6-year (except Golf applications which is 3 years)
warranty from the date of purchase (please keep your proof of purchase) or 2000 cycles @ it’s
maximum discharge current (refer to product specication sheet), whichever comes rst and is
dependent upon correct application.
Note: A full cycle is determined by your battery being fully discharged down to 10% of its
designed capacity and then re-charged to 100% capacity. The warranty period assumes no
more than one full cycle per 24hr period.
In the event of a valid warranty claim your supplier will, at its discretion & consultation with
AVON Battery, supply a new or re-conditioned replacement battery dependent on how many
years have passed since the date of purchase or how many cycles the battery has undertaken to
ensure the original intended warranty period is achieved.
Whilst the AVON LFP has a warranty life of 6 years or 2000 cycles, its design life is far greater,
i.e. 3000 cycles @ 80% DOD or up to 6000 cycles @ 50% DOD (Depth of Discharge)
Conditions
1. Any warranty claim will only be validated by a proof of purchase
2. The warranty is invalid if the battery has been subject to misuse, abuse or physical damage
3. Your AVON LFP battery must be of the correct size, design and capacity for the intended
Application
4. The battery should be installed and operated at a temperature not exceeding the batteries design
limits as noted on the full specication sheet
5. The warranty shall become null & void if the battery becomes unserviceable due to misuse or
subjected to instances such as: re, abuse, modication or it suffers from an attempt to be re-
charge in a below zero °C temperature (unless tted with heating) and \or an over discharged
state. This includes the battery being subjected to instance outside of the Cells or BMS
6. Installation of the battery must be performed by a responsible and qualied person
7. Warranty is not transferable
In The Event Of A Warranty Claim
1. Contact or return to the original point of purchase
2. If returning via a courier service, the battery must only be returned in compliance with the
transport and packaging regulations ruling at the date of return. Failure to do this may result
in the carrier refusing to handle the battery
3. Warranty is on a ‘Return To Base’ basis to your place of purchase
Safety and Product Limitations
• Keep out of the reach of children
• Do not under any circumstances disassemble this battery
• Do not immerse the battery in liquid
• Do not use the battery with damaged cables or terminals
• This battery is not designed for high rate discharge applications
• Do not expose the battery to re or crush or puncture its casing
• Do not mix an AVON LFP battery with any other brand of Lithium OR Lead Acid batteries, in
any series or parallel conguration and do not mix new batteries with used batteries
Limited Liability
The manufacturer nor any of its employees, agents, distributors or resellers are liable for any
third-party damage howsoever caused. The extent to which the manufacturer is liable to a
customer is limited to the purchase price paid by the customer for their AVON LFP battery
More information can be found via the AVON Battery Website
www.avonbattery.co.uk
UN38.3
