Asus S37E User manual
Disassembly procedure
2 - 1
Disassembly Procedure
Please follow the information provided in this section to perform the complete
disassembly procedure of the notebook. Be sure to use proper tools described
before.
37E Notebook consists of various modules. This chapter describes the procedures for the
complete notebook disassembly. In addition, in between procedures, the detailed
disassembly procedure of individual modules will be provided for your service needs.
The disassembly procedure consists of the following steps:
•Battery Module
•CPU Module
•Memory Module
•WLAN Module
•HDD Module
•Optical Drive Module
•Keyboard Module
•Top Case Module
•Motherboard Module
•LCD Module
Chapter
2
S
Disassembly procedure
2 - 2
Battery Module
The illustration below shows how to remove the battery module.
Remove Battery module
1．Slide the battery latch 1 to open battery lock
2．Slide the battery latch 2 and pull the whole battery out.
CPU Module
The illustrations below show how to remove the CPU module from the notebook.
Removing CPU module
1. Remove 6 screws on CPU door and take the CPU door away.
BATTERY
CPU MODULE
REMOVAL
Disassembly procedure
2 - 3
2. Remove 2 screws and then disconnect the CPU fan cable.
3. Remove 1 piece of tape here and take away the CPU fan from the system.
4. Remove 7 screws on heat sink and take away the heat sink module.
Disassembly procedure
2 - 4
5. Turn the non-removable screw here 180 degrees counter-clockwise to loosen the CPU.
6. Squeeze the vacuum handling pump on the CPU and use it to lift the CPU away.
Memory Module
The illustration shows how to remove the memory module form the notebook.
Removing Memory module
1. Pull two latches here to pop the Memory module up at 45°angles, and then pull out the
module at that angle.
MEMORY
MODULE
MEMORY
REMOVAL
Disassembly procedure
2 - 5
WLAN Module
The illustration below shows how to remove the WLAN module from the notebook.
Remove WLAN module
1. Disconnect the three antennas here and then remove two screws to pop it up at 45 degree
angles and then pull it out at that angle.
HDD Module
The illustrations below show how to remove the HDD module from the notebook.
Removing HDD Module
1. Remove 2 screws here.
HDD
MODULE
HDD
MODULE
REMOVAL
WLAN
MODULE
WLAN
MODULE
REMOVAL
Disassembly procedure
2 - 6
2. Pull the hard disk module toward the direction of the arrow and then lift it up and take it
out.
3. Remove 4 screws to separate HDD from HDD housing.
Disassembly procedure
2 - 7
Optical Drive Module
1. Push the ODD module softly and slowly pull the ODD module out.
2. Remove 4 screws here and remove the ODD bracket.
Bottom Case Module
The illustrations below show how to disassemble and remove the bottom case module of the notebook.
The module contains the bottom case itself.
1. Remove 1 screw here and disconnect the cable.
OPTICAL
DRIVE
REMOVAL
BOTTOM CASE
REMOVAL
Disassembly procedure
2 - 8
2. Put the WLAN antennas through the hole of bottom case.
3. Disconnect the two cables here.
4. Remove 10 screws here on bottom case.
Disassembly procedure
2 - 9
5. Remove the left side cover, right side cover and the bottom case orderly.
Disassembly procedure
2 - 10
Keyboard Module
The illustrations below show how to remove the keyboard.
Removing Keyboard
1. Open 4 latches (Esc, F5, F10 and Pause) on keyboard module.
2. Turn over the keyboard plate and disconnect the keyboard FPC, and then remove the
keyboard plate.
KEYBOAR
Table of contents
Other Asus Laptop manuals
Asus
Asus UX51Vz-XH71 User manual
Asus
Asus ROG FLOW Z13-ACRNM RMT02 User manual
Asus
Asus UX30 User manual
Asus
Asus S400CA-DH51T User manual
Asus
Asus Z91N Instructions for use
Asus
Asus Z62J Instructions for use
Asus
Asus G71Gx - Core 2 Quad GHz User manual
Asus
Asus B23E User manual
Asus
Asus U43JC-C1 User manual
Asus
Asus A52F User manual
