Aprilaire 110 Technical specifications

Other manuals for 110

3

Table of contents

Other Aprilaire Humidifier manuals

Aprilaire

Aprilaire 400 Series User manual

Aprilaire

Aprilaire 600 Installation instructions

Aprilaire

Aprilaire 800 Series Installation and operating instructions

Aprilaire

Aprilaire 800 Series User manual

Aprilaire

Aprilaire 400 Series User manual

Aprilaire

Aprilaire 6055 User manual

Aprilaire

Aprilaire Humidifier User manual

Aprilaire

Aprilaire 850 Installation and operating instructions

Aprilaire

Aprilaire enviracaire 1606X Series User manual

Aprilaire

Aprilaire 500 User manual

Aprilaire

Aprilaire 400 Series User manual

Aprilaire

Aprilaire 500 Technical specifications

Aprilaire

Aprilaire 56 User manual

Aprilaire

Aprilaire 700 SERIES User manual

Aprilaire

Aprilaire 700 SERIES Technical specifications

Aprilaire

Aprilaire 110 Setup guide

Aprilaire

Aprilaire 550 Technical specifications

Aprilaire

Aprilaire 700 SERIES User guide

Aprilaire

Aprilaire 400 Series User manual

Aprilaire

Aprilaire 4655 Setup guide

Aprilaire

Aprilaire 1120 Setup guide

Aprilaire

Aprilaire 800 Series Installation and operating instructions

Aprilaire

Aprilaire 400 Series User manual

Aprilaire

Aprilaire 700A User manual

Popular Humidifier manuals by other brands

Boneco

Boneco H300 manual

Bionaire

Bionaire CM1 Instruction leaflet

Air-O-Swiss

Air-O-Swiss AOS 7131 Instructions for use manual

KING

KING K 5002 Rainbow instruction manual

Crane

Crane EE-6902 instruction manual

Glaziar

Glaziar Ness user manual

Philips

Philips DreamStation Go Faqs

Honeywell

Honeywell MISTMATE HUL520BC manual

Stadler Form

Stadler Form Hera Operation instructions

Hunter

Hunter 31206 owner's guide

TaoTronics

TaoTronics TT-AH004 user guide

adorini

adorini Cigar Heaven manual

Lanaform

Lanaform Aroma user manual

Pyle

Pyle SereneLife PHUMDIF8 Instruction book

Trotec

Trotec B 200 operating manual

Pure Humidifier

Pure Humidifier EC Series installation instructions

Crane

Crane EE-864 instruction manual

air&me

air&me Solnan user manual

Maintenance Instructions:

Aprilaire Model 110 Humidifier

1. Note manual humidifier control setting and turn dial to the "off" position.

2. Disconnect electrical power, turn water supply off.

3. Disconnect

a. 120 volt electrical service.

b. Copper Water Supply Line (1) and feed tube (2).

c. Drain line. d) 24 volt leads.

4. Turn two swing locks (3), one at either side of the lower housing of humidifier

flange

5. Lift humidifier straight up until bottom of t humidifier clears lip of lower

housing. Pull humidifier out at bottom, lower and remove.

Slide off three closure clips (4 & 5) that hold 2 halves of humidifier together.

6. Remove upper half of humidifier. Remove water distribution pan cover (6)

and remove any mineral deposits from the "V" notches. DO NOT scrape off

granular coating from the bottom. This textured surface helps ensure even

water flow for maximum performance. If the granular coating has been

removed. Place several drops of liquid dishwashing soap on the distribution

tray. This will only need to be done once if there is no granular coating.

7. Remove water panel evaporator and scale control insert

8. Remove water panel evaporator from insert and clean insert by flexing or

using putty knife. If scale control insert is not used, contact your dealer

about obtaining one.

9. Install a new water panel evaporator with colored spot UP, in scale control

insert. IMPORTANT: when installing scale control insert and water panel

evaporator into the humidifier, the insert spout must discharge directly into

the drain.

10. Remove drain line (7) from the bottom of the humidifier. If applicable, flex it

to loosen any mineral deposits or blockages. Then flush it with water under

pressure. If it does not properly clear, replace it. Slip the drain line back onto

the drain fitting. Make sure the drain line has a constant downward slope and

is not flattened or blocked.

11. Following water panel evaporator replacement and maintenance -

reassemble humidifier.

12. Reconnect electrical power

13. Turn on water supply

14. Check system operation: With the furnace blower operating, burn up manual

humidifier control and check system operation.

Set manual humidifier control to its original position.