Adexa EHP-2S User manual



GasCountertopstove



Thismanualcontainsimportantinformationregarding

yourpurchasedequipment.Pleasereadthemanualthoroughly

priortoequipmentset‐up,operationandmaintenance.

Failuretocomplywithregularmaintenanceguidelines

outlinedinthismanualmayvoidthewarranty.Pleasekeepitforfuture

referenceafterinstallationanddonotthrowitaway!

Thisisauniversalinstallationandoperationinstructionbookwhich

wouldapplytodifferentmodels.

PLEASEREAD!!!

WARNINGS

•Donotstoreorusegasolineorotherflammablevaporsorliquidsinthevicinityofthisoranyother

equipment.

•Improperinstallation,adjustment,alteration,serviceormaintenancecancausepropertydamage,

injuryordeath.

•Readtheinstallationandmaintenanceinstructionsthoroughlybeforeinstallingorservicingthis

equipment.

•Havetheequipmentinstalledbyaqualifiedinstallerinaccordancewithallfederal,stateandlocal

codes.

•Donotinstallorusewithoutall4legs.

•Thisequipmentisforuseinnon‐combustiblelocationsonly.

•Donotobstructtheflowofcombustionandventilationair.

•Donotspraycontrolsortheoutsideoftheequipmentwithliquidsorcleaningagents

•Allowforhotpartstocoolbeforecleaningormoving.

•Thisequipmentshouldonlybeusedinaflat,levelposition.

•Donotoperateunattended.

•Anyloosedirtormetalparticlesthatareallowedtoenterthegaslinesonthisequipmentwill

damagethevalveandaffectitsoperation.

•Ifyousmellgas,followtheinstructionsprovidedbythegassupplier.Donottouchanyelectrical

switch;donottrytolighttheburner;donotuseatelephonewithincloseproximity.

•Neverattempttomovegrateswhilecooking.

SETUP

1.Removeallpackingmaterialandtape,aswellasanyprotectiveplasticfromtheequipment.

2.Placetheequipmentinthedesiredpositionandheight.

3.Installthefour(4)legsontotheequipment.

4.Cleananddrytheequipmentthoroughlybeforeusing.

INSTALLATION:

Theinstallationofthisequipmentmustconformwithlocalcodes,orwiththeNationalGasCode,

ANSIZ223.1/NFPA54,orthe

NaturalGasandPropaneInstallationCode,CSAB149.1,asapplicable.

•Theequipmentanditsindividualshutoffvalvemustbedisconnectedfromthegassupplypiping

systemduringanypressuretestingofthatsystemattestpressuresinexcessof½psi(3.5kPa).

•Theequipmentmustbeisolatedfromthegassupplypipingsystembyclosingitsindividualmanual

shutoffvalveduringanypressuretestingofthegassupplypipingsystemattestpressuresequaltoor

lessthan½psi(3.5kPa).

Clearanceandpositioningaroundtheequipment:

•Thisequipmentmustbeinstalledadjacenttonon‐combustiblesurfacesonlywithaminimum

spacingof6”fromallsides.Thisequipmentmustbeadistanceof6”fromotherequipment.The

equipmentmusthavethe4”legsinstalledandbeplacedonanoncombustiblesurface.

AirSupplyandventilation:

•Theareainfrontandaroundtheequipmentmustbekeptcleartoavoidanyobstructionoftheflow

ofcombustionandventilationair.

•Adequateclearancemustbemaintainedatalltimesinfrontofandatthesidesoftheequipment

forservicingandproperventilation.

PressureRegulator:

•Allcommercialcookingequipmentmusthaveapressureregulatorontheincomingservicelinefor

safeandefficientoperation.Pleaseconsultthelocalgascompanytosourcepropergasregulator.



Checkthegassupplypressureafterinstallation.

Gassupplypressurecanbemeasuredwithaliquid‐filledpressuregauge(e.g.aU‐shaped

pressuregauge,minimumscaledivision0.1mbar)oradigitalgauge.Procedureasfollows:



Removethepanel,unscrewthescrewonthepressureport(Picture1);

Placethepressuregauge;

Startuptheappliancebyfollowingtheinstructionsintheuser’smanual;

Checkthesupplypressure;

Afterthecheck,removethepressuregauge;

Replacethesealingscrew.



PROPANEGASCONVERSION

Thishotplateisshippedfromthefactoryequippedwithfixedburnerorificesfornaturalgasoperation.

Theburnerorificesrequiredtoconvertthehotplatetopropanegasareshippedwiththehotplatein

theshippingpackaging.Itisrecommendedthatatrainedgasservicetechnicianwiththenecessary

tools,instrumentsandskillsperformtheconversion.

Toconverttopropane,followingstepsmustbecompleted:



Switchoffthegasatthemainsupplyvalveandallowtheunittocooldownbeforecommencing

withtheconversion.

Takeoffthefrontplatetoexposetheinjectorandcontrolvalve.

Changethemainburnerinjector:

Loosenandremovethebrassorificelocatedontheendoftheburnerwithawrench.

Replacewiththeneworificefromtheconversionkit,firstapplyingasmallamountofjointing

pastetothethreadontheendofthenozzleholder,thiswillensureagoodgastightseal.



OPERATION:

sealing screw

pressure port

Picture 1

Beforeinitialuse,depresstheknobandturnthegascontrolknobtothemaximumsettingandhold

ittopurgetheairinsidethemanifoldpipeout.Itwouldtakeabout20seconds.Aftertheairinside

themanifoldpipeispurgedout.Pressthebatteryignitertostarttheflame.Holdtheknobfor20

secondsuntiltheflameisstable.Thenreleasetheknob.Iftheflamegoesout,rotatetheknobto

startingposition.Waitfor10minutesandthenrepeatabovesteps.Aftertheflameisstable,allow

theequipmenttoburn‐infor20minutes.

Seeingsmokecomingfromtheburnersorgratesisnormalduringburn‐in.After20minutesof

burn‐in,equipmentisreadyforuse.

1.Toignitetheburners,depressandturnthegascontrolknobtohighpositionandholdittopurge.

2.Youcanadjusttheflameheightbyrotatingtheknob.Therearetwoflamepositions.bigflame.

smallflame.

3.Aftercookingisdone,pleaseturnthevalvetooffposition.

CLEANING:

Tomaintaintheappearanceandincreasetheservicelife,cleanyourequipmentdaily.

DONOTcleanequipmentwithsteelwool.

1.Allowtheequipmenttocoolcompletelybeforecleaning.

2.Usingawirebrush,scrapethegrillgrate(s)toremoveanyfoodresidue.

3.Tocleanequipment,useeitheradampcloth,spongewithsoapywaterorametalscraper.

4.Drygratesthoroughlytopreventrusting.

5.Emptyandcleanthedriptray.

MAINTENANCE:

•Aqualifiedservicecompanyshouldchecktheunitforsafeandefficientoperationonanannual

basis.

•Gaspipingshallbeacertainsizeandinstalledtoprovideasupplyofgassufficienttomeetthefull

gasinputoftheequipment.

•Amanualshutoffvalveshouldbeinstalledupstreamfromthemanifoldwithin4ft.(1.2m)ofthe

equipmentandinapositionwhereitcanbereachedintheeventofanemergency.

•Checkentiregaspipingsystemforleakseverysooften.Usingagasleakdetectororsoapywater

solutionisrecommended.

•Installequipmentunderefficientexhausthoodwithflameprooffilterswithadistanceofnoless

than4feetbetweenthetopoftheequipmentandthefiltersoranyothercombustiblematerials.

*ShippedsetupforNaturalGasandincludesakitforconversiontoLPG.



Toubleshooting：

Burnerdoesnotcomeonwhenthe

controlknobisturnedon

A.Problemwithgasvalve.(Callforservice).B.Pilot

burnernotlit.C.Lowgaspressure.(Callforservice)

Toomuchheat

A.BurnervalvesadjustedtoohighB.Faultyventilation

C.OverratedgaspressureD.Improperlyadjustedburner

Unevenheatsidetoside

A.BurnervalvesimproperlyadjustedB.Applianceisnot

levelsidetosideC.Improperlyadjustedburner

Unevenheatfronttoback

A.ApplianceisnotlevelfronttobackB.Faulty

ventilationC.Improperlyadjustedburner

Pilotburnerwillnotstaylit

A.Pilotflameissettoolow.Adjustpilottoallowforgas

flow.B.ObstructioninpilotorificeC.Lowgaspressure.

(CallforService).

Yellowburnerflames A.Openburnershuttersuntilflamesareblue

Liftingburnerflames A.Closeburnershuttersuntilflamestouchburner

Fluctuatinggaspressure A.Checkforcloggedventonregulator



ProductSpecificationSheet

Gasorificedia.Gaspres.Totalpower

EHP‐6SEHP‐4SEHP‐2S

G301.3mm29mbar6.3kWx66.3kWx46.3kWx2

G301.2mm37mbar6.7kWx66.7kWx46.7kWx2

G301.1mm50mbar6kWx66kWx46kWx2

G202mm20mbar7kWx67kWx47kWx2

G25.32mm25mbar6kWx66kWx46kWx2



Explodeddiagramandpartlist

EHP‐2S



EHP‐4S



EHP‐6S





ADEXADIRECTLIMITED

GROUNDFLOORUNIT1214PURLEYWAYCROYDONCR04XGLONDONUNITEDKINGDOM

T: +44 1483 931040 [email protected] www.adexa.co.uk

ECDeclarationofConformity



AdexaDirectLimiteddeclaresthat:



EquipmentType:  GasCountertopstove



Model:EHP‐2S,EHP‐4S,EHP‐6S



ImportedBy:ADEXADIRECTLIMITED

GROUNDFLOORUNIT1214PURLEYWAYCROYDONCR04XG

LONDON,UNITEDKINGDOM

SerialNumber:



YearofManufacture:



Brand:ADEXA



ApplicationofCouncilDirective(s):(EU)2016/426(9March2016)



Standards:

EN203‐1:2014,EN203‐2‐1:2015

EN203‐3:2009



I,theundersigned,herebydeclarethattheequipmentspecifiedaboveconformstotheabove

Directive(s)andStandard(s).



Date:  20.10.2020

Signature: 



FullName:HakanBaykal



Position:PurchaseManager



This manual suits for next models

Table of contents

Other Adexa Stove manuals

Adexa

Adexa NRC-580 User manual

Popular Stove manuals by other brands

Arada

Arada Cassette Stove installation guide

Parmco

Parmco FS 600 Installation and operating instructions

MCZ

MCZ SUITE AIR 10 M2 installation guide

HearthStone

HearthStone Stowe DV 8321 Owner's manual & installation guide

Cattara

Cattara FAMILY manual

Stanley

Stanley Argon F500 OVAL Installation and operating instructions

Avalon

Avalon B-VENT instructions

Nordpeis

Nordpeis Vega user manual

Exquisit

Exquisit EKC601-5 Instructions for use and installation

Stanley

Stanley Oisin Oil MK II Installation and operation instruction

Thermocet

Thermocet Brookfield S/CC Operating and installation instructions

HASE

HASE delhi operating instructions

Vermont Castings

Vermont Castings Intrepid 2 User instructions

Italiana Camini

Italiana Camini CLASSICA Installation, use and maintenance

Avalon

Avalon Vashon Avanti DVS FS manual

Spartherm

Spartherm ambiente a1 Installation and operating manual

Dimplex

Dimplex MCFSTV12AU manual

Warmlite

Warmlite WL46040 manual